2020 CHEVROLET EXPRESS key

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
298 Vehicle Care
Caution (Continued)
Damage could occur and the
repairs would not be covered by
the vehicle warranty.
Brake System
Visually inspect brake lines and
hoses for proper hook-up, binding,
leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors
for surface condition. Inspect drum
brake linings/shoes for wear or
cracks. Inspect all other brake parts.
Steering, Suspension, and
Chassis Components
Visually inspect steering,
suspension, and chassis
components for damaged, loose,
or missing parts or signs of wear at
least once a year.
Inspect power steering for proper
attachment, connections, binding,
leaks, cracks, chafing, etc.
Visually check constant velocity joint
boots and axle seals for leaks.Lubricate the upper and lower
control arm ball joints, at least every
other engine oil change.
Lubricate the tie rod ball joints, idler
arm pivot shaft bearings, idler arm
socket, and pitman arm socket, at
least every other engine oil change.
Caution
Lubrication of applicable steering/
suspension points should not be
done unless the temperature is
−12 °C (10 °F) or higher,
or damage could result.
Body Component Lubrication
Lubricate all key lock cylinders,
hood hinges, liftgate hinges, and the
fuel door hinge unless the
components are plastic. Applying
silicone grease on weatherstrips
with a clean cloth will make them
last longer, seal better, and not stick
or squeak.
Underbody Maintenance
At least twice a year, spring and fall,
use plain water to flush dirt and
debris from the vehicle's underbody.
Your dealer or an underbody car
washing system can do this. If not
removed, rust and corrosion can
develop.
Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the fluid. Contaminated
fluid will decrease the life of the
transfer case and/or axles and
should be replaced.
Sheet Metal Damage
If the vehicle is damaged and
requires sheet metal repair or
replacement, make sure the body
repair shop applies anti-corrosion
material to parts repaired or
replaced to restore corrosion
protection.
Original manufacturer replacement
parts will provide the corrosion
protection while maintaining the
vehicle warranty.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
314 Service and Maintenance
UsageFluid/Lubricant
Key Lock Cylinders, Hood Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in Canada 10953474).
Power Steering System GM Power Steering Fluid (GM Part No. 19329450, in Canada 19329451).
Rear Axle (Dual Rear Wheels) SAE 75W-90 Synthetic Axle Lubricant (GM Part No. 88900401, in Canada 89021678).
Rear Axle (Single Rear Wheels) SAE 75W-85 Synthetic Axle Lubricant (GM Part No. 19300457, in Canada 19300458).
Weatherstrip Conditioning Weatherstrip lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Weatherstrip Squeaks Synthetic Grease with Teflon, Superlube (GM Part No. 12371287, in Canada 10953437).
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.
Maintenance Replacement Parts
If the vehicle has the Duramax diesel engine, see the Duramax diesel supplement.
Replacement parts identified below by name, part number, or specification can be obtained from your dealer.
Part GM Part Number ACDelco Part Number
Engine Air Cleaner/Filter 4.3L V6 Engine 84065602 A3228C

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
336 OnStar
Or
.Give OnStar Turn-by-Turn
Navigation voice commands.
. Obtain and customize the Wi-Fi
hotspot name or SSID and
password, if equipped.
Press
Qto connect to an
Advisor to:
. Verify account information or
update contact information.
. Get driving directions.
. Receive a Diagnostic check of
the vehicle's key operating
systems.
. Receive Roadside Assistance.
. Manage Wi-Fi Settings,
if equipped.
Press
>to get a priority connection
to an OnStar Advisor available 24/
7 to:
. Get help for an emergency.
. Be a Good Samaritan or
respond to an AMBER Alert. .
Get assistance in severe
weather or other crisis situations
and find evacuation routes.
OnStar Services
Emergency
Emergency Services require an
active safety and security plan. With
Automatic Crash Response, built-in
sensors can automatically alert a
specially trained OnStar Advisor
who is immediately connected in to
the vehicle to help.
Press
>for a priority connection to
an OnStar Advisor who can contact
emergency service providers, direct
them to your exact location, and
relay important information.
With OnStar Crisis Assist, specially
trained Advisors are available
24 hours a day, 7 days a week, to
provide a central point of contact,
assistance, and information during a
crisis.
With Roadside Assistance, Advisors
can locate a nearby service provider
to help with a flat tire, a battery
jump, or an empty gas tank.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Connected Services 343
devices. Manage data usage by
turning Wi-Fi on or off on your
mobile device, using the
myChevrolet mobile app, or by
contacting an OnStar Advisor. On
some vehicles, Wi-Fi can also be
managed from the Wi-Fi
Hotspot menu.
MyChevrolet Mobile App (If
Available)
Download the myChevrolet mobile
app to compatible Apple and
Android smartphones. Chevrolet
users can access the following
services from a smartphone:
.Remotely start/stop the vehicle,
if factory-equipped.
. Lock/unlock doors, if equipped
with automatic locks.
. Activate the horn and lamps.
. Check the vehicle’s fuel level, oil
life, or tire pressure,
if factory-equipped with the Tire
Pressure Monitor System.
. Send destinations to the vehicle.
. Locate the vehicle on a map
(U.S. market only). .
Turn the vehicle's Wi-Fi hotspot
on/off, manage settings, and
monitor data consumption,
if equipped.
. Locate a dealer and schedule
service.
. Request roadside assistance.
. Set a parking reminder with pin
drop, take a photo, make a note,
and set a timer.
. Connect with Chevrolet on social
media.
Features are subject to change. For
myChevrolet mobile app information
and compatibility, see
my.chevrolet.com.
An active OnStar or connected
service plan may be required.
A compatible device,
factory-installed remote start, and
power locks are required. Data rates
apply. See www.onstar.com for
details and system limitations.
Remote Services
Contact an OnStar Advisor to
unlock the doors or sound the horn
and flash the lamps.
Marketplace
OnStar Advisors can provide offers
from restaurants and retailers on
your route, help locate hotels,
or book a room. These services
vary by market.
Diagnostics
By monitoring and reporting on the
vehicle's key systems, OnStar
Advanced Diagnostics, if equipped,
provides a way to keep up on
maintenance. Capabilities vary by
model. See www.onstar.com for
details and system limitations.
Features are subject to change. For
updates on feature capabilities, see
my.chevrolet.com. Message and
data rates may apply.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 349
K
Keyless EntryRemote (RKE) System . . . . . . . . . . 9
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
L
Labeling, Tire Sidewall . . . . . . . . . . 257
Lamps Daytime Running (DRL) . . . . . . .112
Dome . . . . . . . . . . . . . . . . . . . . . . . . . .114
Exterior Controls . . . . . . . . . . . . . . .110
Exterior Lamps OffReminder . . . . . . . . . . . . . . . . . . . . 111
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . .116
License Plate . . . . . . . . . . . . . . . . . 247
Malfunction Indicator (Check Engine) . . . . . . . . . . . . . . . . . . . . . . . 93
Reading . . . . . . . . . . . . . . . . . . . . . . .115
Taillamps . . . . . . . . . . . . . . . . . . . . . 246
Lamps, Bulb Replacement . . . . . . 245
Lane Departure Warning (LDW) . . . . . . . . . . . . . . . . 190
Lane Departure Warning Light . . . 96
Lap-Shoulder Belt . . . . . . . . . . . . . . . 36
LATCH System
Replacing Parts after aCrash . . . . . . . . . . . . . . . . . . . . . . . . . 70 LATCH, Lower Anchors and
Tethers for Children . . . . . . . . . . . . 62
Lighter, Cigarette . . . . . . . . . . . . . . . . 84
Lighting Entry . . . . . . . . . . . . . . . . . . . . . . . . . .115
Entry/Exit . . . . . . . . . . . . . . . . . . . . . .115
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . .115
Illumination Control . . . . . . . . . . . .114
Lights Airbag On-Off . . . . . . . . . . . . . . . . . . . 91
Airbag Readiness . . . . . . . . . . . . . . . 90
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 95
Brake System Warning . . . . . . . . . 94
Charging System . . . . . . . . . . . . . . . 92
Check Engine (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 93
Cruise Control . . . . . . . . . . . . . . . . . . 99
Engine Oil Pressure . . . . . . . . . . . . 97
Flash-to-Pass . . . . . . . . . . . . . . . . . . 111
High-Beam On . . . . . . . . . . . . . . . . . . 98
High/Low Beam Changer . . . . . . 111
Lane Departure Warning . . . . . . . . 96
Low Fuel Warning . . . . . . . . . . . . . . 98
Seat Belt Reminders . . . . . . . . . . . . 90
Security . . . . . . . . . . . . . . . . . . . . . . . . 98
StabiliTrak OFF . . . . . . . . . . . . . . . . . 96
Tire Pressure . . . . . . . . . . . . . . . . . . . 97 Lights (cont'd)
Tow/Haul Mode . . . . . . . . . . . . . . . . . 96
Traction Control System
(TCS)/StabiliTrak . . . . . . . . . . . . . . 97
Locking Rear Axle . . . . . . . . . . . . . . 180
Locks Automatic Door . . . . . . . . . . . . . . . . . 14
Cargo Door Relocking . . . . . . . . . . 14
Delayed Locking . . . . . . . . . . . . . . . . 14
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Lockout Protection . . . . . . . . . . . . . . 14
Power Door . . . . . . . . . . . . . . . . . . . . . 14
Safety . . . . . . . . . . . . . . . . . . . . . . 14, 15
Loss of Control . . . . . . . . . . . . . . . . . 154
Low Fuel Warning Light . . . . . . . . . . 98
Lower Anchors and Tethers for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . . 62
M
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 316
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 310
Maintenance Schedule . . . . . . . . . 305 Recommended Fluids and
Lubricants . . . . . . . . . . . . . . . . . . . 313
Malfunction Indicator Lamp . . . . . . 93

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 351
ProgramCourtesy Transportation . . . . . . 327
Prohibited Fuels . . . . . . . . . . . . . . . . 192
Proposition 65 Warning,
California . . . . . . . . . . . .215, 240, 288, Back Cover
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 330
R
Radio Frequency Statement . . . . 331
Radio Reception . . . . . . . . . . . . . . . . 125
RadiosAM-FM Radio . . . . . . . . . . . . . . . . . 123
Satellite . . . . . . . . . . . . . . . . . . . . . . . 124
Reading Lamps . . . . . . . . . . . . . . . . . 115
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 241
Locking . . . . . . . . . . . . . . . . . . . . . . . 180
Rear Climate Control System . . . 146
Rear Doors . . . . . . . . . . . . . . . . . . . . . . 18
Rear Heating System . . . . . . . . . . . 146
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 29
Rear Vision Camera (RVC) . . . . . 184
Rear Windows . . . . . . . . . . . . . . . . . . . 25
Rearview Mirrors . . . . . . . . . . . . . . . . 22
Reclining Seatbacks . . . . . . . . . . . . . 28 Recommended
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 313
Records Maintenance . . . . . . . . . . . . . . . . . . 316
Recreational Vehicle Towing . . . . 292
Reimbursement Program,
GM Mobility . . . . . . . . . . . . . . . . . . . 325
Remote Keyless Entry (RKE) System . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Remote Vehicle Start . . . . . . . . . . . . 12
Replacement Parts Airbags . . . . . . . . . . . . . . . . . . . . . . . . . 55
Maintenance . . . . . . . . . . . . . . . . . . 314
Replacing Airbag System . . . . . . . . 55
Replacing LATCH System
Parts after a Crash . . . . . . . . . . . . . 70
Replacing Seat Belt System Parts after a Crash . . . . . . . . . . . . . 43
Reporting Safety Defects
Canadian Government . . . . . . . . 332
General Motors . . . . . . . . . . . . . . . 332
U.S. Government . . . . . . . . . . . . . 331
Restraints
Where to Put . . . . . . . . . . . . . . . . . . . 61
Retained Accessory Power (RAP) . . . . . . . . . . . . . . . . . . 167 Roads
Driving, Wet . . . . . . . . . . . . . . . . . . 155
Roadside Assistance Program . . . . . . . . . . . . . . . . . . . . . . . 325
Rotation, Tires . . . . . . . . . . . . . . . . . . 268
Routing, Engine Drive Belt . . . . . . 320
Running the Vehicle While Parked . . . . . . . . . . . . . . . . . . . . . . . . 171
S
Safety Defects ReportingCanadian Government . . . . . . . . 332
General Motors . . . . . . . . . . . . . . . 332
U.S. Government . . . . . . . . . . . . . 331
Safety Locks . . . . . . . . . . . . . . . . . 14, 15
Safety System Check . . . . . . . . . . . . 42
Satellite Radio . . . . . . . . . . . . . . . . . . 124
Scheduling Appointments . . . . . . . 327
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 33 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Extender . . . . . . . . . . . . . . . . . . . . . . . . 42
How to Wear Seat BeltsProperly . . . . . . . . . . . . . . . . . . . . . . . 34
Lap-Shoulder Belt . . . . . . . . . . . . . . 36
Reminders . . . . . . . . . . . . . . . . . . . . . . 90
Replacing after a Crash . . . . . . . . 43
Use During Pregnancy . . . . . . . . . . 41