2018 Lexus LC500 cooling

309
6
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
Maintenance and care
Clean the air intake vents and filters by
the following procedures to prevent
dust from accumulating in them, or to
prevent them from clogging.
The filters are attached to the back side of
the air intake vent grilles.
■Cleaning the air intake vents and
filters
Remove the dust from the vents and fil-
ters with a vacuum cleaner etc.
Clean the vents of the both sides.
■Cleaning the filters
If “Maintenance required for Traction
battery cooling parts See owner’s man-
ual” is shown on the multi-information
display, contact any authorized Lexus
retailer or Lexus authorized repairer,
or any reliable repairer or remove the
air intake vent grilles under the rear
seat and clean the filters.
1 Remove the grille.
NOTICE
■When cleaning the inside of the wind- shield (vehicles with Lexus Safety System+)
Do not allow glass cleaner to contact the lens. Also, do not touch the lens.
( P.204)
■Cleaning the inside of the rear win- dow
●Do not use glass cleaner to clean the rear window, as this may cause dam-age to the rear window defogger
heater wires or antenna. Use a cloth dampened with lukewarm water to gently wipe the window clean. Wipe
the window in strokes running parallel to the heater wires or antenna.
●Be careful not to scratch or damage the heater wires or antenna.
Cleaning the air intake vents and
filters (LC500h)

310
-$@-$I@0.@0.&@ &&

6-1. Maintenance and care
2Remove the filter.
3 Remove dust using a vacuum
cleaner etc. to clean the filter.
Also, remove dust on the grille as well as on the filter using a vacuum cleaner.
4 Install the filter in its original posi-
tion, and then install the grille.
5 Start the hybrid system and check
that the warning message on the
multi-information display disap-
pears.
It may take several minutes before the warning message disappears.
■Cleaning the air intake vents and filters
●Dust on the air intake vents or filters may interferes cooling of the hybrid battery (traction battery) and results in poor fuel
consumption. Clean the air intake vents and filters periodically.
●If continuing to drive the vehicle with “Maintenance required for Traction bat-tery cooling parts See owner’s manual”
shown on the multi-information display, the hybrid battery (traction battery) input and output may be restricted, leading to a
reduction in hybrid battery (traction bat- tery) output and a malfunction. It may cause poor fuel consumption or a mal-
function. If the warning message is shown, contact any authorized Lexus retailer or Lexus authorized repairer, or any reliable
repairer or clean the air intake vents and filters immediately.
●Improper handling may result in damage to the grille or filters. If you have any con-cerns about cleaning the filters, contact
any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.
●If the warning message on the multi-infor-mation display does not disappear after
cleaning the filters, have the vehicle inspected by any authorized Lexus retailer or Lexus authorized repairer, or
any reliable repairer.
●Timing of cleaning filters differs depend-
ing on the use environment of the vehicle.
NOTICE
■When cleaning the air intake vents
and filters
Observe the following precautions. Fail-
ure to do so may cause damage to the vehicle.
●When removing the air intake vent grille, make sure to turn the power
switch off to stop the hybrid system.
●Do not use water or other liquid to clean the air intake vents or filters.
●Do not allow water or foreign matter to enter the air intake vent when the grille
is removed.
●Carefully handle th e removed filters not to damage.If the filter is damaged, have it replaced
with a new filter by any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.

315
6
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
Maintenance and care
WARNING
The engine compartment contains many mechanisms and fluids that may move suddenly, become hot, or become elec-
trically energized. To avoid death or seri- ous injury, observe the following precautions.
■When working on the engine com-
partment
●LC500h: Make sure that the “IGNI-
TION ON” on the multi-information display and the “READY” indicator are both off.
●Keep hands, clothing and tools away
from the moving fan and engine drive belt.
●LC500: Be careful not to touch the engine, radiator, exhaust manifold, etc.
right after driving as they may be hot. Oil and other fluids may also be hot.LC500h: Be careful not to touch the
engine, power control unit, radiator, exhaust manifold, etc. right after driv-ing as they may be hot. Oil and other
fluids may also be hot.
●Do not leave anything that may burn easily, such as paper and rags, in the engine compartment.
●Do not smoke, cause sparks or expose
an open flame to fuel. Fuel fumes are flammable.
●Take care because brake fluid can harm your hands or eyes and damage
painted surfaces. If fluid gets on your hands or in your eyes, flush the affected area with clean water imme-
diately. If you still experience discomfort, con-sult a doctor.
■When working near the electric cool-ing fan or radiator grille
Be sure the engine switch is off.
With the engine switch in IGNITION ON mode , the electric cooling fan may automatically
start to run if the air conditioning is on and/or the coolant temperature is high. ( P.323)
■Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from get-
ting in your eyes.
NOTICE
■If you remove the air cleaner filter
Driving with the air cleaner filter
removed may cause excessive engine wear due to dirt in the air.
■If the fluid level is low or high
It is normal for the brake fluid level to go down slightly as the brake pads wear or when the fluid level in the accumulator is
high. If the reservoir needs frequent refilling, it may indicate a serious problem.

318
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
LC500
Fuse box ( P.350)
Engine oil level dipstick ( P.319)
Engine coolant reservoir ( P.322)
Engine oil filler cap ( P.320)
Washer fluid tank ( P.324)
Electric cooling fan
Condenser ( P.323)
Radiator ( P.323)
For right-hand drive vehicles:
The fuse box is located on the opposite side of the engine compartment.
Engine compartment
Components
A
B
C
D
E
F
G
H

319
6
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
Maintenance and care
LC500h
Engine oil level dipstick ( P.319)
Power control unit coolant reservoir ( P.323)
Engine oil filler cap ( P.320)
Fuse boxes ( P.350)
Washer fluid tank ( P.324)
Engine coolant reservoir ( P.322)
Electric cooling fan
Condenser ( P.323)
Radiator ( P.323)
For right-hand drive vehicles:
One of the fuse boxes is located on the opposite side of the engine compartment.
■12-volt battery
 P.325
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick.
A
B
C
D
E
F
G
H
I
Checking and adding the engine
oil

323
6
-$@-$I@0.@0.&@ &&

6-3. Do-it-yourself maintenance
Maintenance and care
■Power control unit coolant reser-
voir (LC500h)
Reservoir cap
“F”/“FULL” line
“L”/“LOW” line
If the level is on or below the “L”/“LOW”
line, add coolant up to the “F”/“FULL” line.
( P.403)
■Coolant selection
Only use “Toyota Super Long Life Coolant”
or a similar high quality ethylene glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-life
hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a mix-
ture of 50% coolant and 50% deionized water. (Minimum temperature: -35°C [-31°F])
For more details about coolant, contact any authorized Lexus retailer or Lexus autho-
rized repairer, or any reliable repairer.
■If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine/power control unit coolant reservoir caps, drain cock and water pump.
If you cannot find a leak, have any autho- rized Lexus retailer or Lexus authorized repairer, or any reliable repairer, test the
cap and check for leaks in the cooling sys- tem.
Check the radiator and condenser and
clear away any foreign objects.
If either of the above parts is extremely
dirty or you are not sure of their condi-
tion, have your vehicle inspected by
any authorized Lexus retailer or Lexus
authorized repairer, or any reliable
repairer.
A
B
C
WARNING
■When the engine is hot
LC500: Do not remove the engine cool- ant reservoir cap or the coolant inlet cap. ( P.402)
The cooling system may be under pres- sure and may spray hot coolant if the cap is removed, causing serious injuries, such
as burns.
LC500h: Do not remove the
engine/power control unit coolant reser- voir caps or the coolant inlet cap. ( P.406)
The cooling system may be under pres- sure and may spray hot coolant if the cap
is removed, causing serious injuries, such as burns.
NOTICE
■When adding coolant
Coolant is neither plain water nor straight antifreeze. The correct mixture of water and antifreeze must be used to
provide proper lubrication, corrosion protection and cooling. Be sure to read the antifreeze or coolant label.
■If you spill coolant
Be sure to wash it off with water to pre- vent it from damaging parts or paint.
Checking the radiator and con-
denser

382
-$@-$I@0.@0.&@ &&

7-2. Steps to take in an emergency
• “Shift system malfunction” • “P switch malfunction”• “Shift system unavailable”
●If any of the following messages is shown on the multi-information display, it may indicate a malfunction in a system or part. Immediately have the vehicle inspected by any autho-
rized Lexus retailer or Lexus authorized repairer, or any reliable repairer. • “Hybrid System Malfunction” (LC500h)•“Check Engine”
• “Hybrid Battery System Malfunction” (LC500h) • “Accelerator System Malfunction”
●If any of the following messages is shown on the multi-information display, it may indicate a malfunction. Immediately stop the vehicle and contact any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.
•“Braking Power Low” • “Charging System Malfunction”• “Oil Pressure Low”
●LC500h: If “Aux Battery Low” is shown, observe the following.
• If the message disappears in a few minutes*
Keep the hybrid system operating for more than approximately 15 minutes to charge the 12-volt battery.
• If the message does not disappear Refer to “If the 12-volt battery is discharged” ( P.392) to start the hybrid system*: It is displayed for approximately 6 seconds.
●If “Battery low” is shown, the 12-volt battery charge is insufficient. Recharge or replace the 12-volt battery.
●LC500h: If “Maintenance Required for Traction battery Cooling Parts” is shown, the fil- ters may be clogged, the air intake vents may be blocked, or there may be a gap in the
duct. Therefore, perform the following correction procedure. • If the air intake vents and filters of the hybrid battery (traction battery) are dirty, perform the procedure on P.309 to clean them.
• If the warning message is shown when the air in take vents and filters of the hybrid battery (traction battery) are not dirty, have the vehicle inspected by any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer.
■If a message that indicates the need for visi ting your any authorized Lexus retailer or
Lexus authorized repairer, or any reliable repairer is shown
The system or part shown on th e multi-information display is malfunctioning. Have the vehi-
cle inspected by any authorized Lexus retailer or Lexus authorized repairer, or any reliable repairer immediately.
■Warning buzzer
In some cases, the buzzer may not be heard due to being in a noisy location or audio sound.
NOTICE
■While the engine oil level warning message is displayed
Continued engine operation with low engine oil will damage the engine.

400
-$@-$I@0.@0.&@ &&

7-2. Steps to take in an emergency
1Stop the vehicle in a safe place and
turn off the air conditioning system,
and then stop the engine.
2 If you see steam:
Carefully lift the hood after the
steam subsides.
If you do not see steam:
Carefully lift the hood.
3 After the engine has cooled down
sufficiently, inspect the hoses and
WARNING
■After recharging the 12-volt battery
Have the 12-volt battery inspected at any authorized Lexus retailer or Lexus authorized repairer, or any reliable
repairer as soon as possible. If the 12-volt battery is deteriorating, continued use may cause the 12-volt battery to emit a
malodorous gas, which may be detri- mental to the health of passengers.
■When exchanging the 12-volt battery
After exchanging, securely attach the exhaust hose and exhaust hole plug to
the exhaust hole of the exchanged 12- volt battery. If not properly installed, gases (hydrogen) may leak into the vehi-
cle interior, and there is the possible dan- ger of the gas igniting and exploding.
NOTICE
■When handling jumper cables
When connecting the jumper cables, ensure that they do not become entan-gled in the cooling fan or engine drive
belt.
■To prevent damaging the vehicle
The exclusive jump starting terminal is to be used when charging the 12-volt bat-tery from another vehicle in an emer-
gency. It cannot be used to jump start another vehicle.
If your vehi cle overheats
(LC500)
The following may indicate that
your vehicle is overheating.
 The engine coolant temperature
gauge ( P.88) is in the red zone
or a loss of engine power is expe-
rienced. (For example, the vehicle
speed does not increase.)
 “Engine Coolant Temp High” is
shown on the multi-information
display.
 Steam comes out from under the
hood.
Correction procedures