2018 FIAT 500 recommended oil

Thousands of kilometres751501351201059060453015
Thousands of miles4590817263543627189
Years
SERVICING AND CARE
150
43215109876
❍❍❍❍❍

Replace engine oil and oil filter (3)
Replace spark plugs (0.9 TwinAir 65 HP engines) (4)
Replace spark plugs
(0.9 TwinAir 85 HP - 1.2 8V - 1.4 16V) (4)
Replace accessory drive belt(s) (5)
Replace toothed timing drive belt (1.2 8V and 1.4 16V engines) (5)
Replace air cleaner cartridge (6)
Change brake fluid (7)
Replace filter inside the pressure regulator
(LPG versions only)
Replace paper filter (LPG in gaseous state)
(LPG versions only)
Replace passenger compartment cleaner (6)
(3) If the vehicle is used mainly on urban routes or the annual distance travelled is less than 10,000 km, the engine oil and engine oil filter
must be changed every year.
(4) For 0.9 TwinAir versions, the following are essential to ensure correct operation of the engine: only use spark plugs of the same make
and type which are specially certified for such engines (see the information in the “Engine” paragraph in the “Technical specifications”
chapter); strictly comply with the spark plug replacement interval given in the Scheduled Servicing Plan; for spark plug replacement, it is
advisable to contact a FIAT Dealership.
(5) Areas that are not dusty: advised maximum mileage 120,000 km. The belt must be replaced every 6 years, regardless of distance
travelled. Dusty areas and/or heavy conditions (cold climates, urban driving, long periods of idling): the recommended maximum distance is
60,000 km. Irrespective of the mileage, the timing drive belt must be replaced every 4 years.
(6) If the vehicle is used in dusty areas, you are advised to change this filter every 15,000 km.
(7) The brake fluid replacement has to be done every 2 years, irrespective of the mileage.
(
❍) Recommended operations () Mandatory operations


❍❍❍❍❍

SERVICING AND CARE
152
43215109876
Check soft top operation while closing and opening;
check of seals and lubrication of canvas sliding
side guide (convertible versions only)
Check handbrake lever travel and adjust, if necessary
Check conditions and wear of front/rear disc brake
pads (for versions/markets, where provided) and
operation of pad wear indicator
Visually inspect condition and wear of the rear drum brake lining
Inspect and if necessary adjust tensioning of accessory drive belt(s)
(for versions without automatic tensioner only)
Visually inspect condition of the accessory drive belt(s)
Change engine oil and replace oil filter (2)
Replace accessory drive belt(s) (3)
(2) The engine oil and filter change interval depends on driving conditions and is signalled by a warning light or message on the instrument
panel. In any case, it must never exceed 2 years. If the vehicle is mainly used in towns and cities, change the engine oil and filter every year.
(3) Areas that are not dusty: advised maximum distance 120,000 km. The belt must be replaced every 6 years, regardless of distance
travelled. Dusty areas and/or demanding use of the car (cold climates, town use, long periods of idling): advised maximum mileage
60,000 km. The belt must be replaced every 4 years, regardless of distance travelled.
(
❍) Recommended operations
() Mandatory operations





10020018016014012080604020Thousands of kilometres
Thousands of miles6012010896847248362412
Years

IMPORTANT INFORMATION AND RECOMMENDATIONS
196
The engine can be stopped even if the DPF warning light is on:
however, repeated interruptions of the regeneration process could
cause premature deterioration of the engine oil.
For this reason, always wait until the warning light switches off
before stopping the engine as described above. Do not complete
the DPF regeneration process when the vehicle is stopped.
•Water in the fuel circuit may severely damage the injection
system and cause irregular engine operation. If the warning light
or the symbol
Eturns on (together with a message on the display
for some versions), contact a Fiat Dealership as soon as possible
to have the system bled. If the above indication occurs
immediately after refuelling, water may have entered the tank: turn
the engine off immediately and contact a Fiat Dealership.
• If the system signals a pressure decrease on a specific tyre, it is
recommended to check the pressure on all four tyres. The iTPMS
does not relieve the driver from the obligation to check the tyre
pressure every month; it is not to be considered a system to
replace maintenance or a safety system. Tyre pressure must be
checked with tyres cold. Should it become necessary for whatever
reason to check pressure with warm tyres, do not reduce
pressure even though it is higher than the prescribed value, but
repeat the check when tyres are cold.
• The iTPMS cannot indicate sudden tyre pressure drops
(for example when a tyre bursts). In this case, stop the vehicle,
braking with caution and avoiding abrupt steering.
The system only warns that the tyre pressure is low: it is not able
to inflate them. Insufficient tyre inflation increases fuel
consumption, reduces the tread duration and may affect the
capacity to drive safely.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)
•If when turning the key to MAR the warning light ¬does not
turn on or if it stays on when travelling there could be a failure in
safety systems;
in this event airbags or pretensioners may not be deployed in
case of impact or, in a minor number of cases, they may be
deployed accidentally. Contact a Fiat Dealership immediately to
have the system checked.
•A fault to the
¬warning light is indicated, according to the
version, by the ¬symbol appearing on the display or by the èwarning light blinking. In this case, warning light ¬may not
indicate failures in the retaining systems. Before continuing,
contact a Fiat Dealership immediately to have the system
checked.
•The blinking
èwarning light on indicates possible ¬warning light faults. In this case, warning light ¬may not
indicate failures in the retaining systems. Contact a Fiat
Dealership immediately to have the system checked.
•If the warning light
vturns on when the car is travelling
(on certain versions together with the message on the display),
stop the car immediately and contact a Fiat Dealership.
•If the
vwarning light (or v, for versions/markets, where
provided) switches on, the degraded engine oil must be changed
as soon as possible, and never more than 500 km from the first
time that the warning light switches on. Failure to observe the
above may result in severe damage to the engine and invalidate
the warranty. The activation of this warning light is not related to
the amount of oil in the engine. Therefore, never top up with oil
when the warning light starts flashing.
•The driving speed must always be suitable for traffic and
weather conditions and the driver must always comply with the
Highway Code.