2018 FIAT 500 wheel

191
21) VEHICLE REFUELLING
•Do not bring naked flames or lit cigarettes near to the fuel tank
opening: fire risk. Keep your face away from the fuel filler to
prevent breathing in harmful vapours.
•During normal service the catalyst reaches high temperatures;
therefore do not park the car over inflammable materials (grass,
dry leaves, pine needles, etc.): fire hazard.
•Do not use a mobile phone near the refuelling pump: risk of fire.
22) SEAT BELTS - PRETENSIONERS
•Do not press the seat belt release button while the vehicle is
moving.
•Remember that in the event of an accident, the rear seat
passengers not wearing seat belts are exposed to a very serious
risk and also represent a serious danger for the front seat
occupants.
•The pretensioner may be used only once. Contact a Fiat
Dealership to have it replaced after it has been deployed.
•For maximum safety, keep the backrest upright, lean back into
it and make sure the seat belt fits closely across your chest and
pelvis. Always fasten the seat belts on both the front and the rear
seats.
•Travelling without wearing seat belts will increase the risk of
serious injury and even death in the event of an accident.
•Removing or tampering with seat belt and pretensioner
components is strictly prohibited. Any intervention on these
components must be performed by qualified and authorised
technicians. Always go to a Fiat Dealership.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)
19) START&STOP SYSTEM
•When replacing the battery, always go to a Fiat Dealership.
Replace the battery with one of the same type (HEAVY DUTY)
and with the same specifications.
•Before opening the bonnet, make sure that the vehicle is
switched off and the key is in the STOP position.
Please follow the instructions on the decal near the front
crossmember. It is advisable to extract the key when there are
other people in the car.
The car should always be left after the key has been removed
or turned to the STOP position. When refuelling, make sure
that the car is switched off with the key in the STOP position.
•For cars with Dualogic gearbox, if the engine is
automatically stopped on a slope, the engine should be
restarted by moving the gear lever
to + or – without –releasing the brake pedal.
For vehicles with Dualogic transmission, where the Hill Holder
function is present, in case of stop downhill the motor does
not cut off automatically, so as to make the Hill Holder
function - which is active only when the engine is running -
available.
•If climate comfort is to be favoured, the Start&Stop system
can be disabled, for a continuous operation of the climate
control system.
20) ACCESSORIES PURCHASED BY THE OWNER
Take care when fitting additional spoilers, alloy wheels or non-
standard wheel hubs: they could reduce the ventilation of the
brakes and affect efficiency under sharp, repeated braking or
on long descents. Make sure that nothing obstructs the pedal
stroke (mats, etc.).

193
•After installing a child restraint system, do not move the seat:
always remove the child restraint system before making any
adjustment.
•Always make sure that the chest section of the seat belt does
not pass under the arms or behind the back of the child. In the
event of an accident the seat belt will not be able to secure the
child, with the risk of injury, including fatal injury. Therefore the
child must always wear the seat belt correctly.
•Do not use the same lower anchorage to install more than one
child restraint system.
25) AIR BAG
•Do not apply stickers or other objects on the steering wheel,
on the dashboard in the passenger side airbag area, on the
side upholstery on the roof and on the seats. Never put
objects (e.g. mobile phones) on the passenger’s
side of the dashboard since they could interfere with proper
airbag inflation and also cause serious injury to the
passengers.
• SERIOUS DANGER: When there is an active passenger
airbag, DO NOT install rearward facing child restraint systems
on the front seat.
Deployment of the airbag in an accident could cause fatal
injuries to the child regardless of the severity of the impact. It is
advisable to always carry children in a child restraint system on
the rear seat, which is the most protected position in the event
of a collision.
•When an active passenger airbag is fitted, DO NOT install
rear facing child restraint systems on the front seat.
Deployment of the airbag in an accident could cause fatal
injuries to the child regardless of the severity of the impact. •Do not rest your head, arms or elbows on the door, windows
or the area in which the window bag is located to avoid possible
injury during airbag inflation. Never lean your head,
arms or elbows out of the window.
•If when turning the key to MAR the warning light
¬does not
turn on or if it stays on when travelling, there could be a failure in
the safety systems; in this event airbags or pretensioners may not
be deployed in the event of impact or, in a lower number of
cases, they deploy accidentally.
Contact a Fiat Dealership immediately to have the system
checked.
•Do not cover the front seat backrests with extra covers if they
are equipped with side bags.
•Do not travel carrying objects in your lap, in front of your chest
or between your lips (pipe, pencils, etc.):
they could cause severe injury if the airbag is deployed.
•Always drive keeping your hands on the steering wheel rim so
the airbag can inflate freely if necessary. Do not drive with your
body bent forward. Keep your back straight against the backrest.
•If the car has been stolen or in the case of attempt to steal it, if
it has been subjected to vandalism or floods, have the airbag
system checked by a Fiat Dealership.
•The airbags may also be deployed when the car is not moving,
if the key is in the ignition and turned to MAR or when the engine
is off, if the car is hit by another moving vehicle. Therefore, even if
the vehicle is stationary, when an active front passenger airbag is
fitted, DO NOT install rearward facing child restraint systems on
the front passenger seat.
Deployment of the airbag following an impact could cause fatal
injuries to the child.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)

195
•Remember that the servo-brake and power steering are not
operational until the engine has been started, therefore much
effort than usual is required on the brake pedal and steering
wheel.
•For vehicles featuring a Dualogic gearbox, if the engine is not
started with a gear engaged, a warning is sounded to notify
the driver of the potential danger due to the gear being
automatically put into neutral.
•This starting procedure must be performed by expert
personnel because incorrect actions could cause electrical
discharge of considerable intensity. Furthermore, battery fluid
is poisonous and corrosive: avoid contact with skin and eyes.
Keep naked flames and lighted cigarettes away from the
battery and do not cause sparks.
•Remove any metal objects (e.g. rings, watches, bracelets),
that might cause an accidental electrical contact and cause
serious injury.
•Do not attempt to charge a frozen battery: it must be thawed
first, otherwise it may explode.
If freezing has occurred, the battery should be checked by
skilled personnel to make sure that the internal elements are
not damaged and that the body is not cracked, with the risk of
leaking poisonous and corrosive acid.
27) HANDBRAKE
• The car should be braked after a few clicks of the lever, if it is
not, contact a Fiat Dealership to have it adjusted.
• Never leave children in the unattended car. Always remove
the ignition key when leaving the car and take it out with you. • In the case of parking manoeuvres on roads on a gradient, the
front wheels must be steered towards the pavement
(when parking downhill), or in the opposite direction if the vehicle
is parked uphill. Block the wheels with a wedge or a stone if the
car is parked on a steep slope.
28) USING THE MANUAL GEARBOX
Press the clutch pedal fully to change gears correctly. It is
therefore essential that there is nothing under the pedals: make
sure the mats are lying flat and do not get in the way of the pedals.
29) TOWING TRAILERS
•The ABS with which the car is equipped will not control the
braking system of the trailer. Particular caution is required on
slippery roads.
•Do not, under any circumstances, modify the vehicle braking
system to control the trailer breaking system.
The towing braking system must be completely independent of the
vehicle’s hydraulic system.
30) SNOW TYRES
The maximum speed for snow tyres marked
“Q” is 160 km/h, while it is 190 km/h for “T” tyres and 210 km/h for
“H” tyres.
The highway code speed limits must however always be complied
with.
31) WARNING LIGHTS AND MESSAGES
•If the warning light
xturns on when travelling (on certain
versions together with the message on the display) stop the car
immediately and contact a Fiat Dealership.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)

197(CONTINUES)
32) CHANGING A WHEEL
•The space-saver wheel (for versions/markets, where
provided) is specific to your car, do not use it on other models,
or use the space-saver wheel of other models on your car.
The space-saver wheel must only be used in an emergency.
Never use it for more than strictly necessary and never exceed
80 km/h.
•On the space-saver wheel there is an orange label,
summarising the main warnings regarding space-saver wheel
usage restrictions. Never remove or cover the label. The label
contains the following indications in four languages: “Warning!
For temporary use only! 80 km/h max! Replace with standard
wheel as soon as possible. Never cover this indication.” Never
apply a wheel cap on a space-saver wheel.
•If you change the type of wheel (alloy rims instead of
steel rims and vice versa) you will have to change the entire set
of fastening bolts with another set of suitably sized bolts.
•Alert other drivers that the car is stationary in compliance
with local regulations: hazard warning lights, warning triangle,
etc. Any passengers on board should leave the car, especially
if it is heavily laden. Passengers should stay away from on-
coming traffic while the wheel is being changed. On hills or
uneven roads, use chocks or appropriate objects to block the
wheels of the vehicle.
•The driving features of the car may change when a space-
saver wheel is fitted. Avoid violent acceleration and braking,
abrupt steering and fast cornering.
The total life of a space-saver wheel is approximately 3,000
km, after which it must be replaced by another wheel of the
same type. Never install a traditional tyre on a rim designed to
be used as a space-saver wheel.
PERSONAL SAFETY
(CONTINUED)
Have the wheel repaired and refitted as soon as possible. Using
two or more space-saver wheels at the same time is forbidden.
Do not apply grease to the bolt threads before fitting: they could
come unscrewed.
•Snow chains cannot be fitted to the space-saver wheel.
So, if a front (drive) wheel is punctured and chains are needed,
a rear wheel should be fitted to the front of the car and the
space-saver wheel should be fitted to the rear. In this way,
equipped with two normal drive wheels at the front, they can be
fitted with snow chains, thus resolving the emergency situation.
•If the hub cap is not fitted correctly, it may come off when the
car is travelling.
Never tamper with the inflation valve.
Never introduce tools of any kind between rim and tyre. Check
tyre and space-saver wheel pressures regularly, complying with
the values given in the “Technical specifications” chapter.
•The jack is a tool developed and designed only for changing a
wheel, if a tyre gets punctured or damaged, on the vehicle with
which it is supplied or on other vehicles of the same model.
Any other use, e.g. to jack up other vehicle models or different
things, is strictly prohibited. Never use it to carry out
maintenance or repairs under the vehicle or to change
summer/winter wheels and vice versa.
Never go under the raised vehicle. If any work under the vehicle
is necessary, contact the Fiat Service Network. Incorrect
placing of the jack can cause the vehicle to drop: use it only in
the positions indicated.

199(CONTINUES)
PERSONAL SAFETY
(CONTINUED)
• The electronic Cruise Control can be dangerous if the system is
unable to maintain a constant speed. In specific conditions speed
may be excessive, resulting in the risk of losing control of the
vehicle and causing accidents. Do not use the device in heavy
traffic or on winding, icy, snowy or slippery roads.
39) SERVICING - CHECKING FLUID LEVELS
•Never smoke while working in the engine compartment: gas
and inflammable vapours may be present, with the risk of fire.
•Be very careful when working in the engine compartment when
the engine is hot: you may get burned. Remember that when the
engine is hot, the fan may operate: danger of injury. Scarves, ties
and other loose clothing might be pulled by moving parts.
•The cooling system is pressurised. If necessary, only replace
the plug with another original or the operation of the system may
be adversely affected. Do not remove the reservoir plug when the
engine is hot: you risk scalding yourself.
•Do not travel with the windscreen washer fluid reservoir empty:
the windscreen washer is essential for improving visibility.
•Some commercial windscreen washer additives are flammable.
The engine compartment contains hot components which may
set it on fire.
•Brake fluid is poisonous and highly corrosive. In the event of
accidental contact, immediately wash the affected parts with
water and mild soap. Then rinse thoroughly. Call a doctor
immediately if swallowed.
•Symbol
πon the contain indicates a synthetic brake fluid,
which is different from a mineral fluid.
Use of a mineral type fluid will damage the special rubber seals of
the braking system beyond repair.
•Battery fluid is poisonous and corrosive. Avoid contact with skin
and eyes. Keep naked flames and sources of sparks away from
the battery: risk of explosion and fire. •Before towing, turn the ignition key to MAR and then to STOP
without removing it. The steering column will automatically lock
when the key is removed and the wheels cannot be steered.
•When towing, remember that without the help of the brake
servo and electric power steering, a greater effort is required on
the pedal and steering wheel.
•Do not use flexible cables when towing and avoid jerky
movements.
•During towing, make sure that the trailer hitch does not
damage any components it is touching.
•When towing the vehicle, you must comply with all specific
traffic regulations, both in terms of the towing device and
behaviour on the road.
•Do not start the engine while towing the car.
•The (front/rear) tow hook must be used exclusively for
roadside assistance operations.
You are allowed to tow the vehicle for short distances using an
appropriate device in accordance with the highway code (a rigid
bar), to move the vehicle on the road in readiness for towing or
transport via a breakdown vehicle.
The tow hook MUST NOT be used to tow vehicles off the road
or where there are obstacles and/or for towing operations using
cables or other non-rigid devices. In compliance with the above
conditions, towing must take place with the two vehicles (one
towing, the other towed) aligned as much as possible along the
same centre line.
38) ELECTRONIC CRUISE CONTROL
•Never move the shift lever to neutral when driving with the
device active.
• In the event of device malfunction or failure, contact a Fiat
Dealership.

200
PERSONAL SAFETY
(CONTINUED)
42) INTERIORS
•Never use flammable products, such as petrol ether or rectified
petrol to clean the inside of the car. The electrostatic charges which
are generated by rubbing during the cleaning operation may cause
a fire.
•Do not keep aerosol cans in the vehicle: they might explode.
Aerosol cans must not be exposed to a temperature exceeding
50°C. When the vehicle is exposed to sunlight, the internal
temperature can greatly exceed this value.
43) TECHNICAL SPECIFICATIONS – FUEL SUPPLY
Modifications or repairs to the supply system that are not carried
out correctly or do not take the system technical specifications
into account can cause malfunctions leading to the risk of fire.
44) TECHNICAL SPECIFICATIONS – RIM PROTECTOR
TYRES
DO NOT fit wheel hub caps when using integral hub caps fixed
(with springs) to the steel rim and after sale tyres provided with
Rim Protector. Use of unsuitable tyres and wheel caps may cause
sudden decrease of tyre pressure.
45) LPG
•Note that in some countries (including Italy) there are legal
restrictions in force for parking/garaging motor vehicles fuelled by
gas that is denser than air; LPG comes under this category.
•Do not switch between the two operating modes (petrol/LPG)
whilst starting the engine.
•The LPG supply system is equipped with a “consumption”
function linked to the LED display of LPG level on the switch; this
function activates only after a consistent variation in fuel level has
been detected. •Running the battery with an excessively low liquid level will
damage the battery beyond repair and could even cause its
explosion.
•If the vehicle must remain unused for a long time at a very low
temperature, remove the battery and take it to a warm place, to
avoid freezing.
•When performing any operation on the battery or near it,
always protect your eyes with special goggles.
40) TYRES AND WHEELS
•Remember that the road holding qualities of your car also
depend on correct tyre pressures.
•If tyre pressure is too low, the tyre may overheat and be
severely damaged as a result.
•Do not switch tyres from the right hand side of the vehicle to the
left hand side, and vice versa.
•Never submit alloy rims to repainting treatments requiring the
use of temperatures exceeding 150°C.
The mechanical properties of the wheels could be impaired.
41) WINDSCREEN AND –REAR WINDOW WIPER
•Driving with worn windscreen/rear window wiper blades is a
serious hazard, because visibility is reduced in bad weather.
•If the window needs to be cleaned, make sure the device is
deactivated or the key is on STOP.
IMPORTANT INFORMATION AND RECOMMENDATIONS
(CONTINUES)

IMPORTANT INFORMATION AND RECOMMENDATIONS
204(CONTINUES)
• Warning light mwill blink for 60 seconds after starting or
during prolonged cranking to indicate a fault to the glow plug
heating system.
Use the car normally if the engine starts and go to a Fiat
Dealership as soon as possible.
• Never bump start the engine by pushing, towing or coasting
downhill. This could cause fuel to flow into the catalytic
converter and damage it beyond repair.
• Never use a fast battery-charger to start the engine as this could
damage the electronic systems of your vehicle, particularly the
ignition and engine fuel supply control units.
• Do not connect the cable to the negative terminal (–) of the flat
battery. The following spark could lead to battery explosion and
cause serious harm.
Only use the specific earth point; do not use
any other exposed metallic part.
• A quick burst on the accelerator before turning off the engine
serves absolutely no practical purpose; it wastes fuel and is
especially damaging to turbocharged engines.
14) USING THE GEARBOX: MANUAL AND DUALOGIC
• Do not drive with your hand resting on the gear lever as the
force exerted, even if slight, could lead over time to premature
wear of the gearbox internal components.
• If the gearbox is faulty, contact a Fiat Dealership as soon as
possible to have the system checked.
• Avoid keeping your hand placed on this lever in between
gear changes or Auto/Manual mode.
• Using the paddles incorrectly (paddles pushed towards the
dashboard) could break them.• In order to safeguard the efficiency of the clutch, do not use the
accelerator to keep the car still (for example:
stopped on a hill); the clutch could overheat and be damaged;
use the brake pedal and only operate the accelerator pedal when
you decide to set off.
• If the messages continue to be shown in the display, contact a
Fiat Dealership.
15) SNOW CHAINS
• Keep the vehicle’s speed down when snow chains are fitted;
never exceed 50 km/h.
• With snow chains, use the accelerator with extreme care to
prevent, or to limit as much as possible, slipping of the drive
wheels that could cause chain breakage, resulting in damage to
the car body or mechanical components.
• Avoid potholes, steps and pavements and avoid driving long
distances on roads not covered with snow to avoid damaging the
car and the roadbed.
16) POWER SOCKET
Only accessories with a maximum power of 180 W (maximum
absorption 15 A)
can be connected to the socket.
17) DIESEL FILTER
The presence of water in the supply circuit may cause severe
damage to the injection system and irregular engine operation.
If the warning light or the symbol
Eon the colour display turns
on, contact a Fiat Dealership as soon as possible to have the
system bled.
VEHICLE SAFETY
(CONTINUED)

207
• Although the LPG system has numerous safety features, it is
advisable to proceed as follows every time the vehicle is not in
use for a long period or moved in an emergency as a result of a
breakdown or accident:
unscrew the fastening devices, then remove the cover B. Close
the LPG valve rotating the ring nut C clockwise; refit the cover and
tighten the fixing devices.
• It is strictly forbidden to use any additive in the LPG.
• Periodically (at least once every six months) it is advisable to
let the LPG in the tank run out and, at the first refuelling, check
that it does not exceed the maximum capacity of 30.5 litres
(including reserve). If the level is above 30.5 litres (reserve
included) contact a Fiat Dealership immediately.
In special usage conditions:
• starting up and operation at low ambient temperature
• LPG supply with low propane content: the system may
switch temporarily to petrol operation, without any indication.
In the case of:
• low LPG levels in the tank
• request for high performance (e.g. overtaking, car fully laden,
steep hills): the system can automatically switch to petrol
operation to guarantee the required engine performance; in this
event, the performed switching is shown by the orange (petrol)
LED lit and the green (LPG) LED off on the switch. When the
above conditions stop, the system automatically restores the
LPG operation; the orange (petrol) LED turns off and the green
(LPG) LED is lit on the switch.
(CONTINUED)
VEHICLE SAFETY
• To achieve the automatic switching described above, make sure
that there is always enough fuel in the petrol tank.
• There must therefore always be enough petrol in the tank to
protect the petrol pump and to guarantee temporary switching
from LPG to petrol operation.
30) CHANGING A WHEEL
When turning the jack handle make sure that it can turn freely
without scraping your hand against the ground. The moving
components of the jack (“worm screw” and joints) can also cause
injuries: avoid touching them. If you come into contact with
lubricating grease, clean yourself thoroughly.
31) FIX&GO QUICK TYRE REPAIR KIT
• The sealant fluid is effective with external temperatures between
-40°C and +55°C. The sealant has an expiry date. It is possible to
repair tyres which have been damaged on tread up to a diameter
of 6 mm. Show the cartridge and the label to the personnel
charged with handling the tyre treated with the tyre repair kit.