2017 MERCEDES-BENZ SPRINTER transmission oil

1, 2, 3 ...
4ETS (Electronic Traction System).... 55
12 V socket ........................................ 206
A
ABS (Anti-lock Braking System)
Display message ............................ 178
Function/notes ................................ 53
Important safety notes .................... 53
Indicator lamp ................................ 191
Access step in the bumper
Cleaning .........................................2 33
Activating/deactivating cooling
with air dehumidification ................. 101
Activating/deactivating the roof
ventilator ...........................................1 15
Adaptive Brake Assist
Function/notes .............................1 40
ADAPTIVE ESP
®
see ESP®(Electronic Stability Program)
Add-on equipment ............................... 28
Additional indicators
Replacing bulbs ............................... 89
Replacing bulbs (roof) ......................9 2
Additives
Diesel ............................................ 274
Engine oil ...................................... .278
Adjusting the headlamp range ........... 82
ADR (working speed governor) ........151
Air bags
Deployment ..................................... 46
Front air bag (driver, front
passenger) ....................................... 45
Important safety notes .................... 44
Introduction ..................................... 44
Side impact air bag .......................... 45
Window curtain air bag .................... 46
Air filter
Indicator lamp ................................ 197
Air pressure
see Tire pressure
Air vents
Adjusting for the passenger com-
partment ........................................ 105
Adjusting on the roof ..................... 105
Importa nt sa
fety notes .................. 104 Setting the center air vents ........... 104
Setting the side air vents ...............1
05
Air vents
see Air vents
Air-conditioning system
Refrigerant ..................................... 281
see Climate control
Air-recirculation mode
Important safety notes .................. 103
Switching on/off ........................... 103
Alarm system
see ATA (Anti-Theft Alarm system)
All-wheel drive
Engaging/disengaging ................... 145
Important safety notes .................. 144
LOW RANGE transmission ratio ..... 145
Anti-lock Braking System
see ABS (Anti-lock Braking System)
Anti-lock braking system
see ABS (Anti-lock Braking System)
Anti-Theft Alarm system
see ATA (Anti-Theft Alarm system)
Anti-theft system
Interior motion sensor ..................... 58
Armrests .............................................. 76
Ashtray ............................................... 205
ASR (acceleration skid control)
Activating/deactivating ................... 54
Display message ............................ 179
Function/notes ................................ 54
Important safety notes .................... 54
Indicator lamp ................................ 191
ATA (Anti-Theft Alarm system)
Activating/deactivating ................... 57
Switching off the alarm .................... 57
Authorized workshop
see Qualified specialist workshop
Automatic car wash (care) ...............229
Automatic climate control
see Climate control
Automatic headlamp mode ................ 81
Automatic locking ............................... 64
Automatic transmission
Accelerator pedal position ............. 123
Changing gear ............................... 122
Changing gear yourself .................. 122
Driving tips .................................... 123
4Index

Emergency running mode .............. 124
Important safety notes .................. 121
Kickdown ....................................... 123
Maneuvering .................................. 123
Overview ........................................ 121
Problem (malfunction) ................... 124
Releasing the parking lock man-
ually ............................................... 124
Selector lever ................................ 121
Selector lever positions ................. 122
Shift ranges ................................... 123
Starting the engine ........................ 118
Touchshift ...................................... 122
Trailer towing ................................. 123
Transmission oil change ................ 279
Automatic transmission emer-
gency mode ....................................... 124
AUX port ............................................. 207
Auxiliary heater
see Auxiliary warm-air heater
see Hot-water auxiliary heater
Auxiliary heating
Activating/deactivating heater
booster mode ................................ 110
Adjusting ....................................... 170
Conditions for switching on ........... 107
Heating time .................................. 106
Important safety notes .................. 105
Operating with the button (control
panel) ............................................ 107
Operation with the remote con-
trol ................................................. 108
Operation with the timer ................ 112
Selecting a switch-on time ............. 107
Setting the switch-on time ............. 108
see Auxiliary heating
see Auxiliary warm-air heater
see Hot-water auxiliary heater
Auxiliary warm-air heater
Problem (malfunction) ................... 115
Axle load, permissible (trailer tow-
ing) ...................................................... 283
B
Backup lamps
Replacing bulbs ............................... 90 Backup lamps (Chassis Cab)
Replacing bulbs ............................... 91
BAS (Brake Assist System)
Display message ............................ 179
Function/notes ................................ 54
Indicator lamp ................................ 191
Basic settings
see Settings
Battery
Isolating switch .............................. 116
Replacing (SmartKey) ...................... 61
Battery (SmartKey)
Checking .......................................... 61
Important safety notes .................... 61
Replacing ......................................... 61
Battery (vehicle)
Care ............................................... 228
Charge indicator lamp ................... 194
Charging ........................................ 228
Disconnecting and connecting ....... 225
Disconnecting and connecting
(engine compartment) ................... 227
Display message ............................ 189
Important safety notes .................. 223
Installing/removing (engine com-
partment) ....................................... 228
Jump starting ................................. 238
Location ......................................... 224
Removing and installing ................. 226
Removing and installing the floor
covering ......................................... 224
Before driving off
Important safety notes .................. 118
Belt
see Seat belts
Belt warning ......................................... 44
Bleeding the fuel system .................. 120
Blind Spot Assist
Activating/deactivating ......... 143, 170
Notes/function .............................. 141
Trailer towing ................................. 143
Bottle holder
see Cup holder
Brake Assist
see BAS (Brake Assist System)
Brake Assist System
see BAS (Brake Assist System)
Index5

Load bearing index (definition) ...... 261
Load index .....................................258
Load index (definition) ................... 260
M+S tires ....................................... 245
Maximum load on a tire (defini-
tion) ............................................... 261
Maximum loaded vehicle weight
(definition) ..................................... 260
Maximum permissible tire pres-
sure (definition) .............................2 61
Maximum tire load ......................... 259
Maximum tire load (definition) ....... 261
Optional equipment weight (defi-
nition) ............................................ 261
PSI (pounds per square inch) (def-
inition) ...........................................2 61
Replacing ....................................... 262
Service life ..................................... 244
Sidewall (definition) ....................... 261
Snow chains .................................. 246
Speed rating (definition) ................ 260
Storing ...........................................2 62
Structure and characteristics
(definition) ..................................... 259
Summer tires ................................. 245
TIN (Tire Identification Number)
(definition) ..................................... 261
Tire bead (definition) ......................2 61
Tire pressure (definition) ................ 261
Tire pressures (recommended) ...... 260
Tire size (data) ....................... 252, 268
Tire size designation, load-bearing
capacity, speed rating .................... 257
Tire tread ....................................... 244
Tire tread (definition) ..................... 261
Total load limit (definition) ............. 261
Traction (definition) ....................... 261
TWR (permissible trailer drawbar
noseweight) (definition) ................. 261
Uniform Tire Quality Grading
Standards (definition) .................... 260
Wear indicator (definition) ............. 261
Wheel rim (definition) .................... 260
Top Tether ............................................ 50
To

uchshift (automatic transmis-
sion) .................................................... 122
Tow-away alarm
Arming/deactivating ........................ 57 Deactivating ..................................... 57
Operation ......................................... 57
Tow-starting
Emergency engine starting ............ 242
Important safety notes .................. 239
Towing
If the vehicle is stuck ..................... 241
Installing/removing the towing
eye ................................................. 240
With a raised front or rear axle ...... 241
Towing a trailer
Axle load, permissible .................... 283
Cleaning the trailer tow hitch ......... 233
Coupling up a trailer ......................1 54
Decoupling a trailer ....................... 156
Driving tips ....................................1 52
Important safety notes .................. 152
Notes on retrofitting ......................2 82
Trailer loads ................................... 283
Towing away
Important safety guidelines ........... 239
In the event of malfunctions .......... 240
With both axles on the ground ....... 241
Trailer
Brake force booster malfunction ... 192
Trailer coupling
see Towing a trailer
Trailer loads and drawbar nose-
weights ............................................... 156
Trailer towing
Blind Spot Assist ............................ 143
PARKTRONIC ................................. 150
Permissible trailer loads and
drawbar noseweights ..................... 156
Transmission
see Automatic transmission
Transmission oil ................................ 279
Transport
Loading guidelines ......................... 208
Vehicle ...........................................2 42
Transport by rail ................................ 132
Transportation
Rail ................................................ 132
Transporting
Load distribution ............................ 210
Securing a load .............................. 210
Trim pieces (cleaning instruc-
tions) ..................................................2 34
20Index

Proper use
Observe the following information when oper-
ating your vehicle:
Rthe safety notes in these operating instruc-
tions
Rthe technical data in these Operating Instruc-
tions
Rtraffic laws and regulations
Rmotor vehicle laws and safety standards
There are various warning stickers affixed to the
vehicle. If you remove warning stickers, you and
others may fail to recognize the dangers. Leave
the warning stickers in their original position.
GWARNING
Modifications to electronic components, their software as well as wiring can impair their
function and/or the function of other net-
worked components. In particular, systems
relevant to safety could also be affected. As a
result, these may no longer function as inten-
ded and/or jeopardize the operating safety of
the vehicle. There is an increased risk of an
accident and injury.
Never tamper with the wiring as well as elec-
tronic components or their software. You
should have all work to electrical and elec-
tronic equipment carried out at a qualified
specialist workshop.
The general operating permit for your vehicle
could be rendered invalid if you carry out mod-
ifications to electronic components, their soft-
ware as well as wiring.
GWARNING
Gases and fluids from substances that con-
stitute a health hazard or react aggressively
can escape even from securely closed con-
tainers. When transporting such substances
in the vehicle interior, your ability to concen-
trate or your health could be affected during
the journey. Malfunctions, short circuits or
electrical component system failures may
also result. There is a risk of an accident and
fire.
Do not store or transport any substances in
the vehicle interior which are hazardous to
health or react aggressively.
These instructions must also be observed for
vehicles where the cargo compartment is not
fully separated from the driver's cab.
Partition with door/window: always keep the
door/window in the partition closed during
transport.
Examples of substances that are hazardous to
health and/or react aggressively:
RSolvents
RFuel
ROil and grease
RCleaning agents
RAcids
Protection of the environment
Economic and environmentally aware
driving
HEnvironmental note
Daimler's declared policy is one of compre-
hensive environmental protection.
The objectives are for the natural resources
that form the basis of our existence on this
planet to be used sparingly and in a manner
that takes the requirements of both nature
and humanity into account.
You too can help to protect the environment
by operating your vehicle in an environmen-
tally responsible manner.
Fuel consumption and the rate of engine,
transmission, brake and tire wear are affected
by these factors:
Roperating conditions of your vehicle
Ryour personal driving style
You can influence both factors. You should
bear the following in mind:
Introduction25
Z

Useful information
This Operator's Manual describes all models as
well as standard and optional equipment of your
vehicle that were available at the time of going
to print. Country-specific variations are possi-
ble. Note that your vehicle may not be equipped
with all of the described functions. This also
applies to systems and functions relevant to
safety.
Read the information on qualified specialist
workshops (
Ypage 27).
Key
Important safety notes
GWARNING
When the double locks are activated, the
doors can no longer be opened from the
inside. People in the vehicle can no longer get
out, e.g. in hazardous situations. There is a
risk of injury.
Therefore, do not leave any people unsuper-
vised in the vehicle, particularly children, eld-
erly people or people in need of special assis-
tance. Do not activate the double lock when
people are in the vehicle.
GWARNING
If you leave children unsupervised in the vehi-
cle, they could set it in motion by, for example:
Rrelease the parking brake.
Rshift the automatic transmission out of park
position Por shift manual transmission into
neutral.
Rstart the engine.
In addition, they may operate vehicle equip-
ment and become trapped. There is a risk of
an accident and injury.
When leaving the vehicle, always take the
SmartKey with you and lock the vehicle. Never
leave children unsupervised in the vehicle.
GWARNING
If you attach heavy or large objects to the
SmartKey, the SmartKey could be uninten-
tionally turned in the ignition lock. This could
cause the engine to be switched off. There is a risk of an accident.
Do not attach any heavy or large objects to the
SmartKey. Remove any bulky key rings before
inserting the SmartKey into the ignition lock.
Do not keep the key with remote control:
Rwith electronic devices, e.g. a mobile phone
or another key with remote control
Rwith metallic objects, e.g. coins or metal foil
Rin metallic objects, e.g. metal cases
This can affect the key's functionality.
Key functions of the remote control
General notes
The vehicle is equipped with either 2 or 4 remote
controls with a folding key, or 4 mechanical
keys. In this Operator's Manual, both the
mechanical keys and the keys with remote con-
trol are referred to as keys. The remote control
key has a range of up to 32 ft (10 m). Use the
remote control of the key only when in immedi-
ate proximity of the vehicle. This prevents theft.
Remote controls that are not included in the
scope of delivery for the vehicle must be pro-
grammed before use. Further information can
be obtained at any authorized Sprinter Dealer.
The key's remote control locks/unlocks the
driver's door and/or the following centrally if
the factory settings have not been changed:
Rthe driver's and the front-passenger door
Rthe sliding doors
Rthe rear doors
iIf the driver's or front-passenger door is not
closed, the corresponding door is not locked.
If a sliding door or a rear door is not closed
properly, none of the rear doors are locked.
If there is a key is in the ignition lock, the remote
control is inoperative. When locking or unlock-
ing the vehicle with the remote control, always
pay attention to the indicator lamp signaling.
Also check the locking knobs of the doors.
Key59
Opening and closing
Z

Problems with the transmission
ProblemPossible causes/consequences andMSolutions
The transmission mal-
functions when shifting
gear.The transmission is losing oil.
XHave the transmission checked immediately at a qualified specialist
workshop.
The acceleration charac-
teristics have deteriora-
ted noticeably.
The transmission does
not shift.The transmission is in emergency mode.
It is only possible to shift into second gear or reverse gear R.
XStop the vehicle.
XDepress the brake pedal.
XMove the selector lever to positionP.
XSwitch off the engine.
XWait at least 10 seconds before restarting the engine.
XDepress the brake pedal.
XMove the selector lever to positionDor R.
In position D, the transmission shifts into second gear; in position R,
the transmission shifts into reverse gear.
XHave the transmission checked immediately at a qualified specialist
workshop.
Releasing the parking lock manually
In the event of a malfunction, it is possible to
manually release the selector lever from the
lock in parking position P, e.g. to have the vehi-
cle towed away.
XApply the parking brake.
XRemove cover :.
XSlide implement ;as far as it will go into the
opening.
XPush the implement in and simultaneously
move the selector lever out of position P.
The selector lever lock is released. You can
now move the selector lever freely again until
it is returned to position P.
XRemove implement;.
XRe-install cover:.
iThe screwdriver from the vehicle tool kit
could function as the implement, for instance
(
Ypage 236).
Refueling
Important safety notes
GWARNING
Fuel is highly flammable. Improper handling of
fuel creates a risk of fire and explosion.
Avoid fire, open flames, smoking and creating
sparks under all circumstances. Switch off the
engine and, if applicable, the auxiliary heating
before refueling.
GWARNING
Fuel is poisonous and hazardous to health.
There is a risk of injury.
You must make sure that fuel does not come into contact with your skin, eyes or clothing
124Refueling
Driving and parking

longed rolling of the wheels, e.g. when being
towed, will result in transmission damage.
If the vehicle threatens to skid or cannot be
stopped when moving at low speed:
XShift the transmission to neutral position N.
XTry to maintain control of the vehicle using
corrective steering.
Drive particularly carefully on slippery roads.
Avoid sudden acceleration, steering and braking
maneuvers. Do not use cruise control.
You can find further information on winter tires
and snow chains in the "Winter operation" sec-
tion (
Ypage 245).
Driving off-road
Important safety notes
GWARNING
If you drive on a steep incline at an angle or
turn when driving on an incline, the vehicle
could slip sideways, tip and rollover. There is a risk of an accident.
Always drive on a steep incline in the line of
fall (straight up or down) and do not turn the
vehicle.
GWARNING
When driving off-road, your body is subject to
forces from all directions, due to the uneven
surface. You could be thrown from your seat,
for instance. There is a risk of injury.
Always wear a seat belt, even when driving off-
road.
GWARNING
If you drive over obstacles or in ruts, the steer-
ing wheel may jerk out of your grip, causing
injury to your hands.
Always hold the steering wheel firmly with
both hands. When driving over obstacles, you
must expect steering forces to increase
briefly and suddenly.
GWARNING
Flammable material such as leaves, grass or
twigs may ignite if they come into contact with
hot parts of the exhaust system. There is a risk of fire.
When driving off road or on unpaved roads,
check the vehicle's underside regularly. In
particular, remove parts of plants or other
flammable materials which have become
trapped. In the case of damage, contact a
qualified specialist workshop.
!When driving off-road or on unpaved surfa-
ces, check the underside of the vehicle and
the wheels and tires at regular intervals. In
particular, remove any trapped foreign
objects, e.g. stones and branches.
Such foreign objects may:
Rdamage the chassis, the fuel tank or the
brake system
Rcause imbalances and thus vibrations
Rbe flung out when you continue driving
If there is any damage, inform a qualified spe-
cialist workshop.
When driving off-road and on construction sites,
sand, mud and water mixed with oil, for exam-
ple, may get into the brakes. This may lead to a
reduction in braking performance or total brake
failure, also as a result of increased wear. The
braking characteristics will vary depending on
the material that has got into the system. Clean
the brakes after driving off-road. If you then
notice reduced braking performance or hear
scraping noises, have the brake system checked
at a qualified specialist workshop. Adjust your
driving style to the changed braking character-
istics.
Driving off-road or on construction sites increa-
ses the possibility of vehicle damage which may
in turn lead to the failure of certain assemblies
and systems. Adapt your driving style to the off- road driving c
onditions. Drive carefully. Have
any vehicle damage rectified at a qualified spe-
cialist workshop as soon as possible.
When driving on rough terrain, do not shift the
transmission into the neutral position. You could
lose control when attempting to brake the vehi-
cle with the service brake. If your vehicle cannot
manage an uphill slope, drive back down the
slope in reverse gear.
Driving tips135
Driving and parking
Z

iSuch data is vehicle-specific and may differ
from that shown. Always observe the specifi-
cations on your vehicle's identification plate.
Engine number
The engine number is stamped on the crank-
case. More information may be obtained at any
qualified specialist workshop.
Service products and capacities
Important safety notes
GWARNING
Service products may be poisonous and haz-
ardous to health. There is a risk of injury.
Comply with instructions on the use, storage
and disposal of service products on the labels
of the respective original containers. Always
store service products sealed in their original
containers. Always keep service products out
of the reach of children.
HEnvironmental note
Dispose of service products in an environ-
mentally responsible manner.
Service products include the following:
RFuels, e.g. diesel
RAdditives for the exhaust gas aftertreatment,
e.g. Diesel Exhaust Fluid (DEF)
RLubricants, e.g. engine oil, transmission oil
RCoolant
RBrake fluid
RWasher fluid
RClimate control system refrigerants
Approved service products comply with the
highest quality standards and are listed in the
MB Specifications for Service Products. Only
use service products approved for the vehicle.
This is an important condition for the warranty.
You will recognize the approved service prod-
ucts by the inscription on the container: MB
Approval (e.g. MB Approval 228.5)
Other identifications and recommendations
refer to quality level or a specification according to an MB Sheet Number (e.g. MB 228.5). They
are therefore not necessarily approved.
Further information can be obtained at any
qualified specialist workshop.
Additives for approved service products are nei-
ther required nor permitted. Approved fuel addi- tives are the exception. Additives can cause
engine damage and must therefore not be
added to the service products.
The use of additives is always the responsibility
of the vehicle operator. The use of additives may
result in the restriction or loss of yo ur Li
mited
Warranty entitlements.
Fuel
Important safety notes
GWARNING
Fuel is highly flammable. Improper handling of
fuel creates a risk of fire and explosion.
Avoid fire, open flames, smoking and creating
sparks under all circumstances. Switch off the
engine and, if applicable, the auxiliary heating
before refueling.
GWARNING
Fuel is poisonous and hazardous to health.
There is a risk of injury.
You must make sure that fuel does not come into contact with your skin, eyes or clothing
and that it is not swallowed. Do not inhale fuel
vapors. Keep fuel away from children.
If you or others come into contact with fuel,
observe the following:
RWash away fuel from skin immediately
using soap and water.
RIf fuel comes into contact with your eyes,
immediately rinse them thoroughly with
clean water. Seek medical assistance with-
out delay.
RIf fuel is swallowed, seek medical assis-
tance without delay. Do not induce vomit-
ing.
RImmediately change out of clothing which
has come into contact with fuel.
Service products and capacities273
Technical data
Z