2016 Citroen C4 PICASSO fuel filter

8
C4-Picasso-II_en_Chap00b_vue-ensemble_ed01-2016
Maintenance - Technical data
Petrol weights 324-325
Diesel   weights  3 28 -329
Running
 
out
 
of
 
fuel,
 
Diesel
 

(priming
 
pump)
 
3

21
Checking
 
levels
 
2

74-276
-

oil
-
 
b

rake
 
fluid
-


coolant
-
 
s

creenwash/headlamp
 
wash
 
fluid
Checking
 
components
 
2

77-278
-

a

ir filter
-
 p

assenger
 c

ompartment
 f

ilter
-

o

il filter
-
 
e

lectric
 
parking
 
brake
-
 
b

rake
 
pads
 
/
 
discs
Changing
 bu

lbs
 3

01-309
-

front
-

rear Opening
 
the
 
bonnet
 
2

71
Under the bonnet, petrol

2

72
Under
 
the
 
bonnet,
 
Diesel
 
2

73
Petrol
 
engines
 
3

22-323
Diesel
 
engines
 
3

26 -327 Identification
 ma

rkings
 3
31
Dimensions
 3

30
12V
 
battery
 
3

15 -318
Load reduction, economy mode
26

5
Engine
 c

ompartment
 
f

uses
 31

0 - 311,
 31

4
Over view

10
C4-Picasso-II_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit the loads carried in the vehicle and reduce wind resistance (roof
bars,
  roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations
on maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   manufacturer's   service   schedule.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrous   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At the wheel of your new vehicle, it is only after the first 1 800 miles
(3 000
  kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

276
C4-Picasso-II_en_Chap07_info-pratiques_ed01-2016
Coolant level
The coolant level should be close
to  the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap  
b

y
 
two
 
turns   to   allow   the   pressure   to   drop.  
W

hen the pressure has dropped, remove the
cap
 
and
 
top-up   the   level.
Fluid specification
The coolant must conform to the
manufacturer's r ecommendations.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.To p p i n g - u p
The reservoir must be topped-up without delay
by
  a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive level
(Diesel with particle filter)
The additive reservoir low level is
indicated  by   fixed   illumination   of   this  
w

arning   lamp,   accompanied   by   an  
a

udible   signal   and   a   message   that  
t

he particle filter additive level is
too low.
The
 
warning   lamp   comes   on   when   the   ignition  
i

s
 
switched   on,   or   every   time   the   stalk   is  
o

perated,
  until   the   reservoir   is   refilled.
Next
 
time
  you   stop,   refill   the   screenwash   /  
h

eadlamp
  wash   reservoir.
Screenwash/headlamp
wash level low
In the case of vehicles fitted with
headlamp washers, when the fluid
reservoir low level is reached this
warning
  lamp   comes   on   in   the
 in

strument panel, accompanied by an
audible
  signal   and   a   message. Avoid
  prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most of these fluids are harmful to
health
  or   indeed   very   corrosive.
Do not discard used oil or fluids into
sewers
  or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
Practical information

279
C4-Picasso-II_en_Chap07_info-pratiques_ed01-2016
AdBlue® additive and SCR system
for
 
BlueHDi   Diesel   engines
To assure respect for the environment and
conformity with the new Euro 6 emissions
standard,
  without   adversely   affecting   the  
p

er formance or fuel consumption of Diesel
engines,
  CITROËN   has   taken   the   decision   to  
e

quip its vehicles with an effective system that
associates SCR (Selective Catalytic Reduction)
with a particle filter (FAP) for the treatment of
exhaust
  gases.
Presentation of the SCR system
Using a fluid called AdBlue® containing urea, a c
atalytic
 
converter
 
turns
 
up
 
to   85%   of   nitrogen  
o

xides
 
(NOx)
 
into
 
nitrogen
 
and   water,   which   are  
h

armless
 
to
 
health
 
and
 
the
 
environment. The AdBlue
® additive is held in a special
tank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once the AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions from your vehicle will no
longer
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In the event of a confirmed fault
with
 
the
 
SCR
 
system,   you   must   go  
t

o a CITROËN dealer or a qualified
workshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
7
Practical information

322
C4-Picasso-II_en_Chap09_caracteristiques-techniques_ed01-2016
Petrol enginePureTech 110 S&SPureTech 130 S&S
Gearbox Manual (6-speed)Manual (6-speed)EAT6 automatic (6-speed)
Model code 3D
3D...
 3

E...
 3
A...3D...
 3

E...
 3
A...
HNX...
M/1S
  -   M/2SMHNY…
M/1S
  -   M/2SMHNY…
T/1S
  -   T/2S
Cubic capacity (cc) 1 19 9
Bore
  x   stroke   (mm) 75
  x   90.5
Max
  power*:   EU   standard   (kW) 96
Max
  power   engine   speed   (rpm) 5 500
Max
  torque:   EU   standard   (Nm) 230
Max
  torque   engine   speed   (rpm) 1 750
Fuel Unleaded
Catalytic converter yes
Engine
  oil   capacity,   with   filter   replacement  
(in litres) 4.25
Petrol engines and gearboxes
3D...: 
CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* The
  maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

323
C4-Picasso-II_en_Chap09_caracteristiques-techniques_ed01-2016
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* The
  maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Petrol engine
THP 150 / 160THP 165 S&S
Gearbox EAT6 automatic (6-speed)EAT6 automatic (6-speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
5GX   -   5GY...
A-A/1-A/2-A/D-
 A/
1D-
 A/
2D-Y-Y/1-Y/2
5G Z T/S
Cubic capacity (cc) 1 5981 598
Bore   x   stroke   (mm)
77   x   85.8
77   x   85.8
Max   power*:   EU   standard   (kW)
110   /   121
121
Max   power   engine   speed   (rpm)
6 000 6 000
Max   torque:   EU   standard   (Nm)
240 240
Max   torque   engine   speed   (rpm)
1 400 1 400
Fuel UnleadedUnleaded
Catalytic converter yesyes
Engine   oil   capacity   (in   litres)  
(with filter replacement) 4.25
4.25
9
Technical data

326
C4-Picasso-II_en_Chap09_caracteristiques-techniques_ed01-2016
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
HDi 115BlueHDi 100 S&S
Gearbox Manual (6-speed)Manual (6-speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
9HC... 8   -   8/1
BHY...
6/1S   -   6/2SM
Cubic capacity (cc) 1 5601 560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
85 73
Max   power   engine   speed   (rpm)
3   600
3   750
Max   torque:   EU   standard   (Nm)
270 254
Max   torque   engine   speed   (rpm)
1 750 1 750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter noyes
Engine   oil   capacity,   with   filter   replacement  
(in litres) 3.75
3.75
* The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

327
C4-Picasso-II_en_Chap09_caracteristiques-techniques_ed01-2016
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
BlueHDi 115/120 S&SBlueHDi 135/15 0 S&S
Gearbox Manual (6-speed)EAT6 automatic
(6-speed) Manual (6-speed) EAT6 automatic
(6-speed)
Model code 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A...
BHZ   -   BHX...
M/S   -   M/1S
BHZ   -   BHX...
T/1S   -   T/2S
AHX-AHR-AHV-AHS...
M/S   -   M/1S
AHX...
T/S   -   T/1S
Cubic capacity (cc) 1 5601 997
Bore   x   stroke   (mm)
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
85   /   88
11 0
Max   power   engine   speed   (rpm)
3   500
3   750
Max   torque:   EU   standard   (Nm)
300 370
Max   torque   engine   speed   (rpm)
1 750 1 750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter yesyes
Engine   oil   capacity,   with   filter   replacement  
(in litres) 3.75
6 .1
* The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
9
Technical data