2015 TATA SAFARI light

85
D R I V I N GDRIVING IN ADVERSE CONDITIONS DRIVING IN ADVERSE CONDITIONSDRIVING IN ADVERSE CONDITIONS DRIVING IN ADVERSE CONDITIONS
DRIVING IN ADVERSE CONDITIONS
Driving on Snowy or Icy Roads Driving on Snowy or Icy RoadsDriving on Snowy or Icy Roads Driving on Snowy or Icy Roads
Driving on Snowy or Icy Roads
Set the selector knob to 4H position. Gently release the clutch
and apply the accelerator for a smooth start and to avoid wheel
spin.
CAUTION CAUTIONCAUTION CAUTION
CAUTION
Use of snow tyres and / or tyre chain is recommended.
Maintain a safe distance between vehicles to avoid sudden
braking and slow down by shifting down the gears.
Avoid sudden acceleration, braking or turning. Such sharp
manoeuvers can cause loss of traction and thereby loss of vehicle
control.
Driving on Sandy or Muddy Roads Driving on Sandy or Muddy RoadsDriving on Sandy or Muddy Roads Driving on Sandy or Muddy Roads
Driving on Sandy or Muddy Roads
In case the traction on the wheels is sufficient, you may be
able to proceed in 4H mode. However in case change in
road conditions are anticipated, it is better to select the 4L
mode. Shift the selector knob to 4L position by following
the correct procedure and proceed in the normal manner.
Your vehicle will move at a slower pace with higher engine
RPM in the same gear because of the 4L mode. To match
your power and speed requirements, you can shift up in
any of the 5 forward gears or the reverse gear.NOTICE NOTICENOTICE NOTICE
NOTICE
You may choose to reduce the tyre pressure marginally for
additional grip on loose surfaces, though with a slight loss of
ground clearance.
•Try to maintain a constant engine speed and avoid sudden
acceleration which can cause wheel spin and loss of traction,
possibly leading to bogging down of the vehicle.
•If the vehicle gets stuck in loose sand, do not keep on
accelerating as the wheel spin will only result in the
wheels sinking deeper.
•The extent of muddy / sandy, conditions and the traction
available is difficult to judge and the vehicle can get
bogged down deeply. Operation should be done at slow
speed only. If possible, get down and check the path
conditions before proceeding.
ProCarManuals.com

86
D R I V I N GDRIVING IN ADVERSE CONDITIONS DRIVING IN ADVERSE CONDITIONSDRIVING IN ADVERSE CONDITIONS DRIVING IN ADVERSE CONDITIONS
DRIVING IN ADVERSE CONDITIONS
Driving Through Water Driving Through WaterDriving Through Water Driving Through Water
Driving Through Water
•Never venture to drive through water when it flows over guard stones.
•Engine may get seriously damaged if attempted to cross over through deep water.
•If at all the situation demands that you have to drive through water then;
- Keep engine in fast idling and crawl the vehicle in low gear.
- After driving through water apply brakes several times to dry liners and to regain
original braking.
D DD D
D
o not a o not ao not a o not a
o not a
tt tttt tt
tt
empt emptempt empt
empt to start the engine if vehicle gets flooded due to water.
•Tow the vehicle to a safe place.
•Take the vehicle to nearest AUTHORISED Workshop to check entry of water in cylinders.
•It will also be necessary to replace lubricants of engine, gearbox, transfer case, front
axle and rear axle if water has entered.
•Get the starter and alternator checked.
Driving on a Rainy Day Driving on a Rainy DayDriving on a Rainy Day Driving on a Rainy Day
Driving on a Rainy Day
•Check brakes, steering and windows.
•Check tyres for wear and tyre pressure.
•Check wiper blades for proper functioning.
•Avoid harsh braking and sharp turns. It may cause loss of control and lead to a skid.
•For slowing down, shift to lower gears and brake gently.
•Keep lights ON if visibility is poor.
ProCarManuals.com

89
D R I V I N GDRIVING SAFET DRIVING SAFETDRIVING SAFET DRIVING SAFET
DRIVING SAFET
Y YY Y
Y
control of the vehicle and increase
the risk of injury yourself and
others.
mobile phones mobile phonesmobile phones mobile phones
mobile phones
Avoid using mobile phones while
driving a car. This could divert your
attention from the road and result
in an accident.
F FF F
F
a aa a
a
tigue 'R tigue 'Rtigue 'R tigue 'R
tigue 'R
est R est Rest R est R
est R
e ee e
e
viv vivviv viv
viv
e sur e sure sur e sur
e sur
viv vivviv viv
viv
e' e'e' e'
e'
Do not attempt driving when you
feel tired, sleepy long distance
driving can tire you very much and
fatigue can dull your reflexes and
judgment. Take a brake and get
refreshed at intervals.SAFETY CHECKS SAFETY CHECKSSAFETY CHECKS SAFETY CHECKS
SAFETY CHECKS
Windshield/wiper/windshield Windshield/wiper/windshieldWindshield/wiper/windshield Windshield/wiper/windshield
Windshield/wiper/windshield
washer washerwasher washer
washer
Always keep windshield glass
clean to avoid any distraction in
visibility. Ensure proper working of
wipers and condition of wiper
blade. Ensure that windshield
washer reservoir is full. Do not
operate wiper alone when the
windshield glass is dry this would
damage the windshield.
Headlights HeadlightsHeadlights Headlights
Headlights
Keep headlight lenses clean. Check
for operation of headlamps in both
high/low beam condition. Check for
correct focusing of headlamps. Use
only recommended type of bulbs.
Do not use the high beam unless it
is inevitable. Its dazzle may glare
the driver of the oncoming car the
condition thus causing an accident.
DRIVING SAFETY DRIVING SAFETYDRIVING SAFETY DRIVING SAFETY
DRIVING SAFETY
Seat Belt Seat BeltSeat Belt Seat Belt
Seat Belt
Seat-belts are life saving
equipment, use of seat-belt
reduces the chance of injury and
severity of injury in case of an
accident. It is strongly
recommended that all the car
occupants should always wear
seat-belt, while car is in motion.
W WW W
W
ARNING ARNINGARNING ARNING
ARNING
If the vehicle is fitted with air bags,
the air bag is a supplementary
restraint system and can only
provide intended protection when
the seat-belts are worn. For
maximum safety in any collision a
seat-belt must be worn.
Influence of Alcohol Influence of AlcoholInfluence of Alcohol Influence of Alcohol
Influence of Alcohol
Avoid driving under the influences
of alcohol or drugs. Alcohol and
drugs will severely impair your
ProCarManuals.com

90
D R I V I N GDRIVING SAFET DRIVING SAFETDRIVING SAFET DRIVING SAFET
DRIVING SAFET
Y YY Y
Y
Side indicators / Hazard warning Side indicators / Hazard warningSide indicators / Hazard warning Side indicators / Hazard warning
Side indicators / Hazard warning
Ensure that all side indicators/
hazard warning lights are always in
working condition and they are used
when required.
Horn HornHorn Horn
Horn
Ensure the horn is working properly.
Horn provides safety to other road
users by alerting your presence.
Brakes BrakesBrakes Brakes
Brakes
Ensure brakes are working properly.
Check brake fluid level in reservoir.
Don not drive the car when brake
warning lamp is 'ON'.
T TT T
T
yr yryr yr
yr
es eses es
es
Check the condition of tyres for any
abnormalities. Maintain correct
tyre pressure, it is very importantparticularly when subjected to
extreme condition, such as high
speed, high load and high outside
temperature. Do not use worn or
bald tyres on the front wheels.
First Aid Kit First Aid KitFirst Aid Kit First Aid Kit
First Aid Kit
First aid kit is provided in your
vehicle. This is for use in case of
minor injuries. It is to be regularly
checked for any disintegration and
should be updated regularly.
A AA A
A
d dd d
d
v vv v
v
anc ancanc anc
anc
e e e e
e
W WW W
W
ar arar ar
ar
ning ning ning ning
ning
T TT T
T
r rr r
r
iangle iangleiangle iangle
iangle
There is an advanced warning
triangle provided along with your
vehicle. In case there is a
breakdown and the vehicle is
parked at the side of the road, then
the triangle is to be kept as per
instructions given below :Remove advance warning triangle
from case and assemble.
Place the triangle on the road
behind the vehicle when it
stranded on the road. The triangle
must be at least 5 meters behind
the vehicle in the same lane of
traffic.
Increase the distance to 150
meters on a highway or if a bad/hill
top obscures the view.
ProCarManuals.com

105
AIR FIL AIR FILAIR FIL AIR FIL
AIR FIL
TER TERTER TER
TER
Air Filter Air FilterAir Filter Air Filter
Air Filter
The air filter element should be cleaned as per service schedule .
Replace the air filter element with a new one when the service
indicator shows red band even after cleaning in vehicle operations.
Always use genuine air filter element.
Replacement of Air Filter Element Replacement of Air Filter ElementReplacement of Air Filter Element Replacement of Air Filter Element
Replacement of Air Filter Element
a) Disconnect air filter from hose. Unscrew top cover of the air
filter.
b) Remove the cover of the air filter.
c) Remove the air filter element.
d) Clean the air filter element with pressurised air. Do not tap or
hammer the element on ground.
e) Check element for puncture or pin holes by light source.
f ) If found OK install paper filter element. Fit the cover and tighten air
filter screws at the place.
g) Clean the hose connecting the air filter to turbocharger pipe.
Reset the indicator by pressing the rubber cap, red band will disappear
from Service Indicator.
M A I N T E N A N C E
1. Service Indicator 2. Air filter
ProCarManuals.com

115
CL CLCL CL
CL
UT UTUT UT
UT
CH, CH,CH, CH,
CH,
BR BR BR BR
BR
AKE AKEAKE AKE
AKE
,, ,,
,
PO PO PO PO
PO
WER STEERING WER STEERINGWER STEERING WER STEERING
WER STEERING
Clutch Fluid Clutch FluidClutch Fluid Clutch Fluid
Clutch Fluid
The Tata Safari vehicle is equipped with a diaphragm type clutch Which is
hydraulically actuated.
The level of clutch fluid in clutch fluid container should be in between
Min. and Max. marks. If it is not, then add clutch fluid.
In case of spongy or hard clutch pedal, please contact the nearest
Authorised Workshop and get the defect rectified.
Brake Fluid Brake FluidBrake Fluid Brake Fluid
Brake Fluid
Check the level of Brake fluid in Brake fluid container.
It should be in between Min. and Mix. marks.
If it is not, then add brake fluid.
In case of spongy or hard pedal or low brake efficiency, please contact
the nearest Authorised Workshop and get the defect rectified.
Power Steering Fluid Power Steering FluidPower Steering Fluid Power Steering Fluid
Power Steering Fluid
Power steering is fitted for lighter steering effect and easy
manoeuverability. The system consists of steering gear box, hydraulic
pump and hydraulic tank suitably connected by piping. Pump drive is
though ‘V’ belt from engine. Power assistance is available during normal
operating conditions. In case of failure in hydraulic system, the steering
can be operated mechanically with increased steering effort for bringing
the vehicle to Authorised Workshop.
M A I N T E N A N C E
1. Brake Fluid Container
2. Clutch Fluid Container
Power Steering Fluid Container
ProCarManuals.com

116
POWER STEERING POWER STEERINGPOWER STEERING POWER STEERING
POWER STEERING
Procedure for Oil Filling and Bleeding of Power Procedure for Oil Filling and Bleeding of PowerProcedure for Oil Filling and Bleeding of Power Procedure for Oil Filling and Bleeding of Power
Procedure for Oil Filling and Bleeding of Power
Steering SteeringSteering Steering
Steering (Ensure that Power Steering fluid reservoir is totally
clean before starting the work)
1 . Fill the reservoir nearly full. Crank the engine for 10
seconds without allowing it to start (if possible). If engine
does start, shut the engine immediately. Check & refill
the reservoir repeat atleast three times, each time
checking & refilling the reservoir.
2 . Check for leakage in the system and if noticed take
corrective action.
3 . Start the engine and steer the vehicle from full left to full
right turns 3-4 times.
4 . Add fluid if necessary to maintain the level upto filter top.
NOTICE NOTICENOTICE NOTICE
NOTICE
Do not force the wheel against lock position either
extreme left or right. The power steering pump may get
damaged. Hold it lightly.
5 . When the engine is at steady speed, check for bubble
or foaming in the oil. If present it indicates that air is
getting sucked into the systems. Check the suction
line/fittings and correct if necessary.
6 . Once the system is bled properly and free from foaming
there should not be any appreciable change in oil level
in the reservoir, when the engine is started or stopped
repeatedly.
7 . Now the system is ready for driving.
Final oil level should be at ‘H’ mark on dip stick.
NOTICE NOTICENOTICE NOTICE
NOTICE
* Do not allow fluid level to drop significantly or run out
of the reservoir during the above operation. This may
induce air to the system.
* Do not start the engine without oil in the power steering
system. This will result in serious damage to the
pump. In case of emergency disconnect the pump belt
and then start the engine.
* Always use recommended oil from closed containers.
Any dirty oil poured in the system will result in damage
to pump and gear box.
M A I N T E N A N C E
ProCarManuals.com

126
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
Polishes : Polishes :Polishes : Polishes :
Polishes :
Polishes and cleaners can restore shine to the painted surface
that has oxidised and become dull. They normally contain mild
abrasives and solvents that remove the top layer of the finish
coat. Polish your car if the finish does not regain its original shine
after using wax.
Cleaning of Carpets : Cleaning of Carpets :Cleaning of Carpets : Cleaning of Carpets :
Cleaning of Carpets :
Vacuum clean the carpet regularly to remove dirt. Dirt will make
the carpet wear out faster. Periodically shampoo the carpet to
keep it looking new.
Use carpet cleaners (preferably foam type). Follow the
instructions that come with the cleaner, applying it with a
sponge or soft brush. Keep the carpeting as dry as possible
by not adding water to the foam.
Cleaning of Windows, Front & Rear Glasses : Cleaning of Windows, Front & Rear Glasses :Cleaning of Windows, Front & Rear Glasses : Cleaning of Windows, Front & Rear Glasses :
Cleaning of Windows, Front & Rear Glasses :
Clean the windows inside and outside with commercially
available glass cleaners.
This will remove the haze that builds up on the inside of
windows. Use a soft cloth or paper towels to clean all glass and
plastic surfaces.VEHICLE CARE : VEHICLE CARE :VEHICLE CARE : VEHICLE CARE :
VEHICLE CARE :
The car is subjected to many external influences such as climate,
road conditions, industrial pollution and proximity to the sea.
These conditions demand regular care of the car body. Dirt,
insects, bird droppings, oil, grease, fuel and stone chippings should
be removed as soon as possible.
W WW W
W
ashing : ashing :ashing : ashing :
ashing :
Do not wash the car in direct sunlight, wash in shade. Spray the
car thoroughly with a cold water jet (car on a washing pit or
hoist). Mix car shampoo in the wash water. No solvent (fuel,
thinners) need be used.
NOTICE NOTICENOTICE NOTICE
NOTICE
Avoid wiping of painted surface in dry condition as it may
leave scratches on the painted surface.
Use a soft bristle brush, sponge or soft cloth and rinse it
frequently while washing. When you have washed the whole
exterior, dry it with a chamois or soft cloth. After drying the car,
inspect it for chips and scratches that could allow corrosion to
start. Apply touch up paint where necessary.
For vehicles with Rear View Camera : Use cover for camera For vehicles with Rear View Camera : Use cover for cameraFor vehicles with Rear View Camera : Use cover for camera For vehicles with Rear View Camera : Use cover for camera
For vehicles with Rear View Camera : Use cover for camera
during washing. during washing.during washing. during washing.
during washing.
M A I N T E N A N C E
ProCarManuals.com