2015 Peugeot RCZ fuel filter

9
RCZ_en_Chap00b_vue-ensemble_ed01-2015
Running out of fuel, Diesel 144
Checking levels
145-147
-

oil
- brake
fluid
- power
steering fluid
-
coolant
- screenwash/headlamp
wash fluid
- additive
(Diesel with particle filter)
Changing bulbs

169-176
-

front
-
rear
Cleaning and maintenance

188-189
-

interior
-
exterior Opening the bonnet

141
Under the bonnet, petrol


142
Under the bonnet, Diesel


143Energy economy mode


164
Battery

165-168
Engine compartment fuses

177-178, 181-183
Checking components


148-149
-

battery
- air
filter and passenger compartment filter
- oil
filter
- particle
filter (Diesel)
-
gearboxes
-

brake pads / discs
TECHNICAL DATA - M AINTENANCE
Petrol engines 192
Petrol weights 193-194
Diesel engine

195
Diesel weights


196
Dimensions


197-198
Identification

markings 199
OVERVIEW

11
RCZ_en_Chap00c_eco-conduite_ed01-2015
LIMIT THE CAUSES OF EXCESS
CONSUMPTION
Spread loads throughout the vehicle; place the heaviest items in the
bottom of the boot, as close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce wind resistance (roof\

bars, roof rack, bicycle carrier, trailer...). Use a roof box in preference.
Remove roof bars and roof racks after use.
At
the end of winter, remove snow tyres and refit your summer tyres.
OBSERVE THE RECOMMENdATIONS ON
MAINTENANCE
Check the tyre pressures regularly, when cold, referring to the label in
the door aperture, driver's side.
Carry out this check in particular:
-

before a long journey
,
-

at each change of season,
-


after a long period out of use.
Don't forget the spare wheel and the tyres on any trailer or caravan.
Have

your vehicle serviced regularly (engine oil, oil filter, air filter,
passenger

compartment filter...) and observe the schedule of
operations recommended in the warranty and maintenance record.
When refuelling, do not continue after the third cut-of

f of the nozzle to
avoid
any overflow.
At
the wheel of your new vehicle, it is only after the first 1 800 miles

(3 000 kilometres) that you will see the fuel consumption settle down \
to a consistent average.
ECO-DRIVING

16
RCZ_en_Chap01_controle-de-marche_ed01-2015
Engine
autodiagnosis
systemflashing.
The engine management system
has a fault. Risk of destruction of the catalytic converter.
Have
it checked by a PEUGEOT dealer or a qualified workshop.
fixed. The emission control system has
a fault. The warning lamp should go of
f when the engine is started.
If
it does not go off, contact a PEUGEOT

dealer or qualified
workshop without delay

.
Low fuel level fixed
with the
needle in the
red zone,
accompanied by
an audible signal
and a message.When

it first comes on there
remains approximately 5 litres

of
fuel in the tank.
At this point, you begin to use the
fuel reserve. Refuel as soon as possible to avoid running out of fuel.
Until
sufficient fuel has been added, this warning lamp
will come on every time the ignition is switched on,
accompanied by an audible signal and a message.
The audible signal and message are repeated with
increasing

frequency as the fuel level drops towards
"0"
.
Fuel tank capacity: approximately 55 litres.
Never continue to drive until you run out of fuel, as this
could damage the emission control and injection systems.
Warning/indicator
lamp is on CauseAction / Observations
Service on temporarily.
A minor fault has occurred for
which there is no specific warning
lamp.
Identify the fault by reading the message shown in the
screen, such as, for example:
-

opening of the doors, boot or bonnet,
-

low engine oil level,
-

low screenwash level,
-
flat remote control battery,
- saturation of the particle emission filter (Diesel)
As soon as traffic conditions permit, regenerate the
filter

by driving at a speed of at least 36 mph (60 km/h)
until the service warning lamp goes of

f.
- a fault with the tyre under-inflation detection system,
- ...
For any other faults, contact a PEUGEOT dealer or a
qualified workshop.
fixed. A major fault has occurred for
which there is no specific warning
lamp.
Identify the fault by reading the message shown on the
screen
and contact a PEUGEOT

dealer or a qualified
workshop.

143
RCZ_en_Chap07_verifications_ed01-2015
DIESEL ENGINE
The various caps and covers allow access for checking the levels of the various fluids, for replacing certain components and for priming the fuel system.
1.
Power steering reservoir
.
2.

Screenwash and headlamp wash reservoir
.
3.

Coolant reservoir
.
4. Brake
fluid reservoir.
5.

Battery / Fuses.
6.

Fusebox. 7. Air
filter.
8.

Engine oil dipstick.
9.

Engine oil filler cap.
10.

Priming pump.
11

.
Bleed screw
.
7/
CHECKS

F0
147
RCZ_en_Chap07_verifications_ed01-2015
dIESEL FUEL A dd ITIVE LEVEL ( dIESEL WITH
P

ARTICLE FILTER )
The additive reservoir low level is indicated by fixed illumination of this warning lamp, accompanied by an audible signal and a
message
that the particle filter additive level is too low.
Topping up
The reservoir must be topped up without delay by a PEUGEOT dealer
or a qualified workshop.
USEd PROdUCTS
Avoid prolonged contact of used oil or fluids with the skin.
Most of these fluids are harmful to health or indeed very corrosive.
Do
not discard used oil or fluids into sewers or onto the ground.
Take
used oil to a PEUGEOT

dealer or a qualified workshop
(France) or to an authorised waste disposal site.
COOLANT LEVEL
The coolant level should be close to the "MAx" mark but
should never exceed it.
When the engine is warm, the temperature of the coolant is regulated
by the fan.
In addition, as the cooling system is pressurised, wait at least one hou\
r
after switching of
f the engine before carrying out any work.
To avoid any risk of scalding, unscrew the cap by two turns to allow the \
pressure to drop. When the pressure has dropped, remove the cap and
top up the level. The cooling fan may start after switching off the engine: take care
with articles and clothing that might be caught by the fan blades.
Fluid specification
The coolant must conform to the manufacturer's recommendations.
SCREENWASH AN d HEA d LAMP WASH FLUI d
In the case of vehicles fitted with headlamp washers, the low fluid
level is indicated by an audible signal and a message in
the instrument panel screen.
T

op up the reservoir when you next stop the vehicle.
Fluid specification
For optimum cleaning and to avoid freezing, this fluid must not be topped up with or replaced with plain water .
In
wintry conditions, the use of an ethyl alcohol or methanol base fluid is
recommended.
7/
CHECKS

192
RCZ_en_Chap09_caracteristiques_ed01-2015
Engine1.6 THP
150 hp 1.6 THP 155 hp 1.6 THP
160 hp 1.6 THP
200 hp 1.6 THP
270 hp
Gearbox Automatic
(6-speed) Manual
(6-speed) Automatic
(6-speed) Automatic
(6-speed) Manual
(6-speed) Manual
(6-speed)
Model code:
4
j ... 5FE-
j
5FV
-85FV-A
5FV-A/GT** 5FM-
j
5FM-

j /GT**5FU-8
5FU-M
5FU-8/GT**
5FU-M/GT** 5FG-M
Cubic capacity (cc) 1 5981 5981 598 1 598 1 598
Bore x stroke (mm) 77 x 85.877 x 85.877 x 85.8 77 x 85.8 77 x 85.8
Max power: EU standard (kW)* 11 011 5120147199
Max power engine speed (rpm) 6 0506 0006 000 5 500 6 000
Max
torque: EU standard (Nm) 240240240275330
Max
torque engine speed (rpm)1 400 1 4001 400 1 700 1 900
Fuel UnleadedUnleadedUnleaded Unleaded Unleaded
Catalytic converter Ye sYe sYe sYe sYe s
Engine oil capacity (in litres)
(with
filter replacement) 4.25
4.254.254.25 -
PETROL ENGINES AND GEARBO x ES
* The maximum power quoted is the type approved value obtained on a test bed, under the conditions defined in European legislation
(directive 1999/99/CE).
**
GT Line version.

195
RCZ_en_Chap09_caracteristiques_ed01-2015
Engine2.0 H d i 160 hp
Gearbox Manual
(6-speed)
Model code:
4
j ... RHH-8
Cubic capacity (cc) 1 997
Bore x stroke (mm) 85 x 88
Max power: EU standard (kW)* 120
Max power engine speed (rpm) 3 750
Max
torque: EU standard (Nm) 340
Max
torque engine speed (rpm) 2 000
Fuel Diesel
Catalytic converter Ye s
Particle
filter Ye s
Engine oil capacity (in litres)
(with
filter replacement) 5.25
DIESEL
ENGINE AND GEARBO x
* The maximum power quoted is the type approved value obtained on a test bed, under the conditions defined in European legislation
(directive 1999/99/CE).
9/
TECHNICAL DATA

279
RCZ_en_Chap11_Index-alpha_ed01-2015
ABS and EBFD systems.................... 89
Accessories ..................................... 190
Accessory socket, 12V
......................69
Access to rear seats

..........................58
Active bonnet

..................................... 92
Adjusting headlamps


.........................81
Adjusting the steering wheel


.............................................. 54
Advice on driving


.............................. 11 5
Airbags


.............................................. 99
Airbags, front
........................... 100, 103
Airbags, lateral......................... 101, 103
Air conditioning
.................................. 10
Air conditioning, digital


........................................ 60, 61
Air
filter ............................................ 148
Air
flow ......................................... 59, 62
Air vents............................................. 59
Alarm
................................................. 41
Alert / warning log


.............................. 34
Alloy wheels..................................... 189
Anti-lock braking system (ABS)


.........89
Anti-pinch........................................... 44
Anti-theft

........................................... 11

8
Arches, aluminium


...........................188
Armrest, front
..................................... 70
Ashtray
.............................................. 69
Assistance call


...................88, 201, 202
Audible warning


................................. 88
Audio streaming (Bluetooth)


............................ 244, 272
Audio systems
......................... 203, 259 Automatic illumination
of headlamps ............................76, 79
Automatic operation of hazard warning lamps


.................................87
Automatic rain sensitive windscreen wipers


....................83, 85
Auxiliary sockets


........71, 245, 267, 269A/ A/
Battery ..............................148, 165-167
Battery , charging .............................. 167
Battery, remote control
....................................... 39, 40
Bluetooth (hands-free)
.......................... 226, 270
Bluetooth


(telephone)
............................ 226, 270
Bodywork

......................................... 188
Bonnet
............................................. 141
Boot
............................................. 33, 49
Boot lamp
.......................................... 74
Brake discs

...................................... 149
Brake lamps

............................. 172, 175
Brake pads


...................................... 149
Braking assistance system


................89B/
Capacity, fuel tank ........................... 139
CD MP3 ................................... 241, 266
Central locking

............................. 38, 47
Changing a bulb


.......................169-176
Changing a fuse


.......................177-183
Changing a wheel


.....................157-161
Changing a wiper blade
............. 86, 163
Changing the remote control battery

................................. 39
Changing the time


.................26, 33, 35
CHECK

.............................................. 25
Checking levels

........................145-147
Checking the engine oil level
.................................... 21, 145
Checking tyre pressures (using the kit)


................................ 156
Checks

...................................... 142-149
Children
...................... 98, 100, 104-1

14
Child seats


...............104, 105, 109-114
Child seats, ISOFI
x ..........................11 2
Cleaning (advice)............................. 188
Clock.................................................. 26
Closing the boot........................... 38, 49
Closing the doors......................... 38, 46
Colour screen, retractable


...........34, 36
Connectors, audio


.....71, 245, 267, 269
Coolant level


.............................. 21, 147
Coolant temperature indicator
.......................................... 21
Cruise control

.................................. 132
Customising stickers........................ 188
Cup holder


......................................... 67C/
ALPHABETICAL INDEx
ALPHABETICAL INdEX