2014 MITSUBISHI OUTLANDER SPORT catalytic converter

Plug-in Hybrid EV System2-4 General information
2
•The plug-in hybrid EV system is too hotor too cold.•The air conditioner is used.•The vehicle has not been used for a longtime.•The engine has not been operated for along time.
E00203800028
zIf the warning display appears, refuel assoon as possible.If the vehicle is runs out of fuel, theengine will not start even in a situationneed to be generated electricity, the fol-lowing conditions will occur.•The driving performance falls (sinceonly the electrical power stored in thedrive battery can be used for the driv-ing).•The heating performance cannot beavailable (except vehicles with electricheater).•The effectiveness of the heater is insuffi-cient (vehicles with electric heater).•The catalytic converter may be damageddue to excessive high temperature.
Refer to “Filling the fuel tank” on page 2-13.Refer to “Fuel remaining display screen” onpage 6-9.
E00203900029
zIt is the battery to operate the motor andthe air conditioning.In addition to the drive battery, OutlanderPHEV has the auxiliary battery to operatelamps, wipers, etc.zCompact, light-weight lithium ion batterywith high energy density is used for thedrive battery.zThe drive battery has the following char-acteristics.Please read this carefully paying attentionto the following:zThe same as ordinary lithium-ion batter-ies, the battery capacity of the drive bat-tery gradually reduces with time, resultingin reduced cruising range. Depending onthe usage conditions, such as frequentquick acceleration/deceleration,extremely hot weather, storing the vehiclein high ambient temperatures, etc., therate of battery capacity drop will increase.
Refueling (gasoline)
CAUTIONzDepending on the opera
ting conditions of
your vehicle, the fuel in the fuel tank maynot be used for a long time and stay in thetank, resulting in deterioration of the fuelquality. As this may af
fect the engine and
fuel system parts, observe the followinginstructions:•Run the engine by pressing the batterycharge switch at least once in 3 months.Refer to “Battery charge switch” on page7-23.• Refuel 20 litres or more of fuel every 6months (to make the total refueling amountin 6 months be 20 litres or more).
zIf refueling of the above
amount is not possi-
ble due to a high fuel level because the vehi-cle has not been used for a long time or forsome other reason, consult a MITSUBISHIMOTORS Authorised Service Point.
Drive battery
WA R N I N GzA sealed lithium ion
high voltage battery
(drive battery) is
adopted for Outlander
PHEV. If the drive battery is disposed ofimproperly, there is a
risk of severe burns
and electrical shock that may result inserious injury or death and there is also arisk of environmental damage.
zNever attempt to use the drive battery forany other purpose.
Characteristics
WA R N I N G
BK0203201EN.book 4 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Multi information display6-10 Instruments and controls
6
E00522401788
When the fuel is reduced to about 7 litres, theinformation screen switches to the interruptdisplay of the fuel remaining warning display,and the “ ” mark (B) on the fuel remainingdisplay flashes slowly (about once per sec-ond). After a few seconds, the informationscreen returns from the fuel remaining warn-ing display to the previous screen.When the fuel is reduced further to about 5litres, the information screen switches to thefuel remaining warning display and the “ ”mark (B) on the fuel remaining displayflashes quickly (about twice per second).
E00522101509E00527800083
The odometer indicates the distance travelled.
E00527901078
The tripmeter indicates the distance travelledbetween two points.
Fuel remaining warning display
CAUTIONzIf the warning display a
ppears, refuel as soon
as possible. If the vehicle is runs out of fuel, the enginewill not start even in
a situation need to be
generated electricity, the following condi-tions will occur.•The driving performance falls (since onlythe electrical power stored in the drive bat-tery can be used for the driving).•The heating performance cannot be availa-ble (except vehicles with electric heater).•The effectiveness of the heater is insuffi-cient (vehicles with electric heater).•The catalytic converter may be damageddue to excessive high temperature.NOTE
zOn inclines or curves, the display may beincorrect due to the movement of fuel in thetank.zBattery save or battery charge may not beactivated even if the battery save switch orthe battery charge switch is pressed, depend-ing on the remaining quantity of the drivebattery or the control condition of the sys-tem.
Outside temperature display screen
This displays the temperatureoutside the vehicle.
NOTE
zThe display setting can be changed to thepreferred units (°C or °F).Refer to “Changing the function settings” onpage 6-15.zDepending on factors such as the drivingconditions, the displayed temperature mayvary from the actual outside temperature.
Odometer Tr i p m e t e r
BK0203201EN.book 10 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

11
MaintenanceService precautions ......................................................................... 11-2Catalytic converter .......................................................................... 11-3Bonnet ............................................................................................. 11-3Engine oil ........................................................................................ 11-5Engine coolant/Plug-in hybrid EV system coolant ......................... 11-6Wa s h e r f l u i d . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 7Brake fluid ...................................................................................... 11-7Auxiliary battery ............................................................................. 11-8Ty r e s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 9Wiper blade rubber replacement ................................................... 11-12General maintenance .................................................................... 11-14Fusible links .................................................................................. 11-15Fuses ............................................................................................. 11-15Replacement of lamp bulbs .......................................................... 11-21
BK0203201EN.book 1 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Catalytic converterMaintenance 11-3
11
E01000202437
The exhaust gas scavenging devices usedwith catalytic converter are extremely effi-cient for the reduction of noxious gases. Thecatalytic converter is installed in the exhaustsystem.It is important to keep the engine properlytuned to ensure proper catalyst operation andprevent possible catalyst damage.
E01000303868
1. Pull the release lever towards you tounlock the bonnet.
zMake sure that the engine and Plug-inHybrid EV system has cooled down beforeremoving the radiator cap and EV coolingsystem reserve tank cap, because hotsteam or boiling water otherwise will gushfrom the filler port and may scald you.zDo not smoke, cause sparks or allow openflames around fuel or auxiliary battery.The fumes are flammable.zBe extremely cautious when workingaround the auxiliary battery. It containspoisonous and corrosive sulphuric acid.zDo not get under your vehicle with just thebody jack supporting it. Always use auto-motive jack stands.zImproper handling of
components and
materials used in the vehicle can endangeryour personal safety. We recommend youto consult a specialist for necessary infor-mation.zThe components inside the engine roommight be very hot to the touch.To a v o i d b e i n g b u r n t , m a k e s u r e a l l c o m -ponents have sufficiently cooled beforebeginning an inspection. These compo-nents are affixed with the label indicatingprecautions for handling. Follow theinstructions on the label.WA R N I N G
1- Brake fluid reservoir (RHD)2- Engine oil level gauge3- Engine oil cap4- Brake fluid reservoir (LHD)5- Washer fluid reservoir6- EV cooling system reservoir7- Engine coolant reservoirCatalytic converter
WA R N I N GzAs with any vehicle, do not park or oper-ate this vehicle in areas where combustiblematerials such as dry grass or leaves cancome in contact with a hot exhaust since afire could occur.zPaint should not be applied to the catalyticconverter.NOTE
zUse fuel of the type recommended in “Fuelselection” on page 2.
Bonnet To o p e n
BK0203201EN.book 3 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Alphabetical index
13-1
13
Numerics
4-wheel drive operation
.......................
7-20
A
Accessory (Installation)
.......................
2-14
Accessory socket
................................
8-66
Active stability control (ASC)
..............
7-32
Adaptive Cruise Control System (ACC) 7-43Air conditioner
Automatic climate control air conditioner
.
8-4Important operation tips for the air condi-tioner
...........................................
8-11
Air purifier
.........................................
8-12
Airbag
...............................................
5-21
AM/FM radio
.....................................
8-12
Antenna
.............................................
8-40
Anti-lock brake system (ABS)
.............
7-29
Ashtray
..............................................
8-65
Assist grips
........................................
8-72
Audio
AM/FM radio
.................................
8-12
CD player
......................................
8-12
To listen to a disc in the rear-seat display
.
8-34Troubleshooting
.............................
8-38
Automatic transmission
Fluid
............................................
12-10
Auxiliary battery
................................
11-8
Auxiliary battery charge warning lamp
.6-39
B
Battery
Auxiliary battery charge warning lamp
.....
6-39Discharged battery (Emergency starting)
..
9-2Specification
..................................
12-8
Battery charge switch
..........................
7-23
Battery save switch
.............................
7-22
Bluetooth® 2.0 interface
.....................
8-41
Bonnet
..............................................
11-3
Bottle holders
.....................................
8-71
Brake
Anti-lock brake
..............................
7-29
Braking
.........................................
7-26
Fluid
...................................
11-7
, 12-10
Parking brake
...................................
7-4
Brake assist system
.............................
7-28
Brake warning lamp
............................
6-37
Bulb capacity
....................................
11-22
C
Capacities
.........................................
12-10
Card holder
...............................
8-65
, 8-69
Cargo area cover
.................................
8-71
Cargo loads
........................................
7-70
Catalytic converter
..............................
11-3
Cautions on the handling of 4-wheel drive vehicles
............................................
7-22
CD player
...........................................
8-12
Central door locks
...............................
4-15
Charging indicator
..............................
6-37
Check engine warning lamp
.................
6-38
Child restraint
.....................................
5-15
Child restraint anchorage points
...........
5-16
Child-protection rear doors
..................
4-15
Cleaning
Exterior of your vehicle
...................
10-3
Interior of your vehicle
....................
10-2
Clutch
Fluid
............................................
12-10
Coat hook
...........................................
8-72
Combination headlamps and dipper switch
...
6-40Compliance label
................................
12-3
Coolant (engine)
......................
11-6
, 12-10
Coolant (plug-in hybrid EV system)
.....
11-6
Corner sensor
.....................................
7-63
Cruise control
.....................................
7-35
Cup holder
.........................................
8-70
BK0203201EN.book 1 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分