2014 AUDI S4 belt

154 Airbag sys te m
- Improper repair or disassembly of the
front passenger and driver seat will pre­
vent the Advanced Airbag System from
functioning properly.
- Repairs to the front passenger seat must
be performed by qualified and properly
trained workshop personnel.
- Never remove the front passenger or
driver seat from the veh icle.
- Never remove the upholstery from the
front passenger seat.
- Never disassemble or remove parts from
the seat or disconnect wires from it.
- Never carry sharp objects in your pockets
or place them on the seat. If the weight­
sensing mat in the passenger seat is
punctured it cannot work properly.
- Never carry things on your lap or carry
objects on the passenger seat. Such
items can increase the weight registered
by the weight-sens ing mat and send the
wrong info rmation to the airbag control
unit.
- Never store items under the front pas·
senger seat. Parts of the Advanced Ai r­
bag System under the passenger seat
cou ld be damaged, preventing them and
the airbag system from working proper­
ly .
- Never place seat covers or replacement upholstery that have not been specifical­
ly approved by Audi on the front seats.
- Seat covers can prevent the Advanced Airbag System from recognizing child re­
straints or occupants on the front pas­
senger seat and prevent the side airbag
in the seat backrest from deploy ing prop­
erly.
- Never use cush ions, pillows, blankets or
similar items on the front passenger
seat. The add itional padd ing will prevent
the weight-sensing mat in the seat from
accurately reg iste ring the ch ild restra int
or person on the seat and prevent the
Advanced Airbag System from function­ ing properly .
-If you must use a child restra int on the
front passenger seat and the chi ld re- straint manufacturer's instructions
re­
qu ire the use of a towel, foam cushion or
something e lse to properly pos ition the
child restraint, make certain that the
PASSENGER AIR BAG OFF light comes
on and stays on whenever the ch ild re·
straint is installed on the front passen­
ger seat.
- If the PASSENGER AIR BAG OFF light
does not come on and stay on, immed i­
ately insta ll child restraint in a rear seat­
ing position and have the airbag system
inspected by your authorized Audi dealer.
How the Advanced Airbag System
components work together
The front Advanced Airbag System and the
side airbags supplement the protection of­
fered by the front three-point safety belts
with pretensioners and load limiters and the
adjustable head restraints to help reduce the
risk of injury in a wide range of accident and
crash situations. Be s ure to read the impor ­
tant information about safety and heed the
WARNINGS in this chapter.
Deployment of the Adv a need A irbag System
and the activation of the safety belt preten­
sioners depend on the deceleration measured
by the crash sensors and registered by the
electron ic control unit. Crash severity depends
on speed and deceleration as well as the mass
and stiffness of the vehicle or object involved
in the crash .
On the passenger side, regardless of safety
belt use, the airbag will be turned off if the
weight on the passenger seat is less than the
amount programmed in the electronic control
unit . The front airbag on the passenger side
will a lso be turned off if one of the child safe­
ty seats that has been certified under Federal Moto r Veh icle Safety Standard 208 has been
recognized on the seat. The
PAS SENGER AIR
BAG OFF
light comes on and stays on to tell
you when the front Advanced Airbag on the
passenger side has been turned off
¢ page 147, Child restraints on the front seat
- some important things to know. ...,.

A WARNING
To reduce the risk of injury when an airbag
inflates, always wear safety belts properly.
- If you are unrestrained, lean ing forward,
sitting sideways or out of position in any
way, your risk of injury is much higher.
- You w ill also receive serious injuries and
could even be killed if you are up against
the a irbag or too close to it when it in­
fla tes - even with an Advanced Airbag
~page 146.
More important things to know about
front airbags
Fig. 155 Inf lated front a irbags
Safety belts are impo rtant to help keep front
seat occupants in the p roper seated pos ition
so that airbags can unfo ld properly and pro­
v ide supp lemental protection in a fronta l col­
lision.
The front a irbags are designed to provide ad­
d itiona l protection for the chest and face of
the dr iver and the front seat passenge r when:
- safety belts are worn prope rly,
- the seats have been posit ioned so that the
occupant is properly seated as far as possi­
ble from the a irbag,
- and the head restraints have been properly adjusted .
Because airbags i nflate in the blink of an eye
with great force, things you have on your lap
or have placed on the seat could become dan ­
ge ro us projectiles, and be pushed into you if
the airbag inflates.
When an a irbag deploys, fine dust is released.
This is normal and is not caused by a fire in
A irba g sy stem 155
the vehicle . This dust is made up mostly of a
powder used to lubricate the airbags as they
deploy. It could irr itate skin.
It is important to remembe r that wh ile the
supplementa l airbag system is designed to re­
duce the like lihood of serious injuries, other
injur ies, for example swelling, br uis ing and
minor abrasions, can also happen when air­
bags inflate. Airbags do not protect the arms
or the lower parts of the body . Front a irbags
o nly supplement the three point safe ty belts
in some fronta l co llisions in which the vehicle
decelera tion is h igh enough to deploy the air­
bags.
Front airbags will not deploy :
- if the ignition is sw itched off when a crash
occu rs,
- in side co llisions,
- in rear-end collisions,
- in rollovers,
-when the crash deceleration measured by the airbag system is less than the minimum
threshold needed for airbag dep loyment as
reg istered by the electronic contro l unit .
The front pa ssenger ai rbag will also not
deploy:
- when the front passenger seat is not occu ­
pied,
- when the weight on the front passenger
seat as sensed by the Advanced Airbag Sys­
tem ind icates that the front airbag on the
passe nger side has to be turned off by the
electronic control unit (the
PASSENGER AIR
BA G OFF
light comes on and stays o n).
A WARNING
-S itting in the wrong pos ition can in crease
the r is k of se rious inj ury i n crashes.
- To reduce the risk of injury when the air­
bags inflate, the drive r and passenge rs
m ust always s it in an upr igh t positi on,
m ust not lean against or pla ce any part
of their body too close to the area whe re
the airbags a re located. .,.

156 Airbag sys te m
- Occupants who are unbelted, out of posi­
t ion or too close to the airbag can be
seriously injured by an airbag as it un­
folds with great force in the blink of an eye
~ page 147 .
A WARNING
-
A child in a rearward-facing child safety
seat installed on the front passenger seat
w ill be seriously injured and can be k illed if
the front a irbag inflates -even with an Ad ­
vanced Airbag System.
- T he inflating a irbag will hit the child
safety seat or infant carrier with g reat
force and wi ll smash the chi ld safety seat
and child against the backrest , center
armrest, door or roof .
- Always install rear -facing child safety
seats on the rear seat.
- If you must install a rearward facing
child safety seat on the front passenger
seat because of exceptional circ umstan­
ces and the
PAS SENG ER A IR BAG OFF
light does not come on and stay on, im ·
med iately install the rear-facing child
safety seat in a rear seating position and
have the a irbag system inspected by your
authorized Audi dealer .
A WARNING
Objects between you and the a irbag will
increase the risk of injury in a crash by in­
terfering with the way the airbag unfolds
or by being pushed into you as the a irbag
inflates.
- Never hold th ings in your hands or on
yo ur lap when the vehicle is in use.
- Never transport items on or in the area
of the front passenger seat . Objects
cou ld move into the area of the front air­
bags during braking or other s udden ma­
neuver and become dangerous projec­
t iles that can cause serious personal in­
jury if the airbags inflate .
- Never place or attach accessories or oth­
er objects (such as cupholders, te le­
phone brackets, large, heavy or bu lky ob -
-
jects) on the doors, over or near the area
marked "AIRBAG" on the steer ing whee l,
instrument panel, seat backrests or be­
tween those areas and yourself . These
objects could cause inju ry in a crash, es­
pecia lly when the airbags inflate .
- Never recline the front passenger's seat to transport objects . Items can a lso
move into the area of the s ide airbag or
the front a irbag du ring bra kin g or in a
sudden maneuver. Objects nea r the air­
bags can become projectiles and cause
inj ury, partic ularly when the seat is re­
clined .
A WARNING ~
The fine dust created when airbags deploy
can cause breathing prob lems for people
with a history of asthma or other breath­ i ng cond itions .
- To reduce the risk of breath ing problems,
those with asthma or other respiratory conditions shou ld get fresh air right
away by getting o ut of the veh icle or
open ing windows or doors .
- If you are in a collision in which airbags
deploy, wash your hands and face with
mild soap and wate r before eating.
- Be ca reful not to get the dust into your
eyes, o r into any c uts or sc ratches .
- If the res idue should get into your eyes ,
f lush them w ith wate r.
Monitoring the
Advanced Airbag
System
Airbag monitoring indicator light
T wo separate indicators monitor the function
of the Advanced Airbag System: the airbag
monitoring indicator light and the
PASSEN·
GER AIR BAG OFF
light.
The Advanced A irbag System (including the
electron ic cont ro l unit , sensor circu its and sys­
tem wiring) is monitored continuously to make su re that it is funct io ni ng properly

158 Airbag sys te m
make certain that the PA SSENGER AIR BAG
OFF
li ght stays on continuous ly whenever the
ignit ion is on. If the
PASS ENGER AIR BAG
OFF
light does not appear and not stay on all
the time, stop as soon as it is safe to do so
and
- react ivate the system by turning the ignition
off and then turning it on again;
- remove and reinstall the child restraint.
Make sure that the child restraint is properly
installed and that the safety belt for the
front passenger seat has been correctly
routed around the child restraint as descr i­
bed in the child restraint manufacturer's in­
structions;
- make sure that the convertible locking fea­
ture on the safety belt for the front passen­
ger seat has been activated and that t he
safety belt has been pulled tight. The belt
must not be loose o r have loops of slack so
that the sensor below the safety be lt latch
on the seat can do its job
c::> page 177 .
-make su re that th ings that may increase the
weight of the chi ld and child safety seat are
not being transported on the front passen ­
ger seat;
- make sure that the safety be lt tension sen­
sor is not b locked. Shake the safety belt
latch on the front passenger seat back and
forth;
- If a strap or tether is being used to tie the child safety seat to the front passenger
seat, make sure that it is not so tight that it
causes the we ight-sensing mat to measure
more we ight than is actua lly on the seat.
If the PASSEN GER AIR BAG OFF light still
doe s not come on
and does not stay on con­
tinuously (when the ignition is switched on),
- take the chi ld restraint off the front passen -
ger seat and install it properly at one of the
rear seat pos itions . Have the a irbag system
inspected by your authorized Audi dealer
immediately .
- move the ch ild to a rear seat pos it io n and
make sure that the child is properly restrain­
ed in a child restraint that is appropriate for
i ts size and age. The
PA
SSENGER AIR BAG OFF light sho uld
NOT come on when the ignition is on and an
adult is s itting in a proper seating position on
the front passenger seat. If the
PAS SENGER
AIR BAG OFF
light comes on and stays on or
flashes for about 5 seconds wh ile driving, un­
der these c ircumstances, make sure that:
- the adult on the front passenger seat is properly seated on the center of the seat
cushion with his or her back up aga inst the
backrest and the backrest is not recl ined
c::> page 129, Proper occupant seating posi­
tions,
- the adult is not tak ing weight off the seat by
holding on to the passenger assist handle
above the fron t passenger door or support­
ing thei r weig ht on the armrest,
- t he safety belt is being properly wo rn and
t hat there is not a lot o f slack in the safety
be lt webb ing,
- accesso ry seat covers or cushions o r othe r
t hings tha t may c ause an incorrect reading
or impression on the weight-sensing mat
under the upho lstery of the seat have been
removed from the front passenger seat,
- a sa fety belt extender has not bee n left in
the safety belt latch for the front passenger
seat.
In add ition to the
PASSENGER AIR BAG OFF
li ght in the center o f the instrument panel,
t h e message
PASSENGER AIR BAG OFF or
PASSENGER AIR BAG ON wi ll briefly appear
in the instrument cluster disp lay. This is to in­
form the dr iver of the current front passenger
airbag status.
Important safety instructions on
monitoring the Advanced Airbag System
A WARNING
An a irbag system that is not functioning
properly cannot provide supplemental pro­
tection in a frontal c rash.
- If the airbag ind icator light
c::> page 20
comes when the veh icle is being used,
have the system inspected immediately
by your au thorized A udi dealer .
It is
-

160 Airbag system
-Never attach any objects such as cu­
pholders or telephone mountings to the
surfaces covering the airbag units.
- For cleaning the horn pad or instrument
panel, use only a soft, dry cloth or one
moistened with plain water. Solvents or
cleaners could damage the airbag cover
or change the stiffness or strength of the
material so that the airbag cannot de­
ploy and protect properly.
- Never repair, adjust, or change any parts
of the airbag system .
- All work on the steering wheel, instru­
ment panel, front seats or electrical sys­
tem (including the installation of audio
equipment, cellular telephones and CB
radios, etc.) must be performed by a
qualified technician who has the training
and special equipment necessary.
- For any work on the airbag system, we
strongly recommend that you see your
authorized Audi dealer or qualified work­
shop.
- Never modify the front bumper or parts
of the vehicle body.
- Always make sure that the side airbag
can inflate without interference:
- Never install seat covers or replace­
ment upholstery over the front seat­
backs that have not been specifically
approved by Audi.
- Never use additional seat cushions that
cover the areas where the side airbags
inflate.
- Damage to the original seat covers or
to the seam in the area of the side air­
bag module must always be repaired
immediately by an authorized Audi
dealer.
- The airbag system can be activated only
once. After an airbag has inflated, it
must be replaced by an authorized Audi
dealer or qualified technician who has
the technical information, training and
special equipment necessary.
- The airbag system can be deployed only once. After an airbag has been deployed,
it must be replaced with new replace- ment parts designed and approved espe­
cially for your Audi model version . Re­
placement of complete airbag systems
or airbag components must be per­
formed by qualified workshops only. Make sure that any airbag service action
is entered in your Audi Warranty
& Main­
tenance booklet under
AIRBAG REPLACE­
MENT RECORD.
- In accidents when an airbag is deployed,
the vehicle battery separates the alterna­
tor and the starter from the vehicle elec­
trical system for safety reasons with a pyrotechnic circuit interrupter.
- Work on the pyrotechnic circuit inter­ rupter must only be performed by a
qualified dealer -risk of an accident!
- If the vehicle or the circuit interrupter
is scrapped, all applicable safety pre­
cautions must be followed.
@ For the sake of the environment
Undeployed airbag modules and preten­
sioners might be classified as Perchlorate
Material -special handling may apply, see
www .dtsc.ca.gov/hazardouswaste/per­
chlorate. When the vehicle or parts of the restraint system including airbag modules
safety belts with pretensioners are scrap­
ped, all applicable laws and regulations
must be observed. Your authorized Audi
dealer is familiar with these requirements
and we recommend that you have your
dealer perform this service for you.
Other things that can affect Advanced
Airbag performance
Changing the vehicle's suspension system can
change the way that the Advanced Airbag Sys­
tem performs in a crash. For example, using
tire-rim combinations not approved by Audi, lowering the vehicle, changing the stiffness of
the suspension, including the springs, suspen­
sion struts, shock absorbers etc. can change
the forces that are measured by the airbag sensors and sent to the electronic control
unit. Some suspension changes can, for

example, increase the force levels measured by the sensors and make the airbag system
deploy in crashes in which it would not deploy if the changes had not been made. Other
kinds of changes may reduce the force levels
measured by the sensors and prevent the air ­
bag from deploying when it should.
The sensors in the safety belt buckle for the
driver and front passenger seat tell the elec­
tronic control module if the safety belt is
latched or not. If the safety belt is being used,
the front airbag will deploy at a slightly high­
er rate of vehicle deceleration than if the safe­
ty belt is not being used. Therefore, in a par­
ticular collision, it is possible that an airbag
will not deploy at a seating position where the
safety belt is being used but will inflate at the
position where the safety belt is not being
used.
It is important that nothing interfere
with the safety belt buckles so that the sen­
sors can send the correct information about
safety belt use to the electronic control unit .
& WARNING
Changing the vehicle's suspension includ­
ing use of unapproved tire-rim combina­
tions can change Advanced Airbag per­
formance and increase the risk of serious personal injury in a crash.
- Never install suspens ion components
that do not have the same performance characteristics as the components origi­
nally installed on your vehicle.
- Never use tire-rim combinations that
have not been approved by Audi.
A WARNING 1= -
Items stored between the safety belt
buckle and the center console can cause
the sensors in the buckle to send the
wrong information to the electronic con­
trol module and prevent the Advanced Air ­
bag System from working properly.
- Always make sure that nothing can inter-
fere with the safety belt buckles and that
they are not obstructed.
Airbag system 161
Side airbags
Description of side airbags
The airbag system can provide supplemental
protection to properly restrained occupants .
Fig. 157 Side a irbag locatio n in the driver 's seat
~ co Q)
The side airbags are located in the sides of the
front seat backrests~
fig. 157 and the rear
backrest facing the doors. They are identified
by the word "AIRBAG".
The side airbag system basically consists of:
- the electronic control module and external
side impact sensors
- the two airbags located in the sides of the front backrests and the two airbags* located
in the rear backrest
- the airbag warning light in the instrument
cluster .
The airbag system is monitored electronically
to make certain that it is functioning properly
at all times . Each time you turn on the igni­
tion, the airbag system indicator light will
come on for a few seconds (self diagnostics).
The side airbag system supplements the safe­
ty belts and can help to reduce the risk of in­
jury to the driver's and front passenger's up­
per torso on the side of the vehicle that is
struck in a side collision. The airbag deploys
only in side impacts and only when the vehicle
accelerat ion registered by the control unit is
high enough. If this rate is below the refer­
ence value programmed into the control unit,
the side airbags will not be triggered,
even
though the car may be badly damaged as a re­
sult of the collision . It is not possible to de -
fine an airbag triggering range that will cover
II>

162 Airbag system
every possible angle of impact, since the cir­
cumstances wi ll vary considerably between
one co llision and another. Important factors
include, for examp le, the nature (hard or soft)
of the impacting object, the angle of impact,
vehicle speed, etc. c::>
page 163, Important
safety instructions on the side airbag system.
Aside from their normal safety function, safe­
ty belts work to help keep the driver or front passenger in position in the event of a side
coll is io n so that the side a irbags can provide
protection .
The airbag system is
not a substitute for your
safety belt. Rather, it is part of the overall oc ­
cupant restraint system in your ve hicle. Al­
ways remember that the side airbag system
can only help to protect you if you a re wearing
your safety be lt and wear ing it prope rly . T his
is another reason why you should a lways wear
your safety belts, not just because the law re ­
quires you to do soc::>
page 138, General
notes.
I t is important to remember that while the
supp lemental side airbag system is designed
to reduce the likelihood of serious injuries,
othe r injuries, for example, swell ing, bruising,
and minor abrasions can also be associated
wi th deployed side airbags. Remember too,
side airbags will deploy on ly once and on ly in
certain k inds of acc idents -your safety belts
are a lways there to offer protect ion.
Vehicle damage, repair costs or even the lack
of vehicle damage are not necessari ly an indi ­
cation of over-sensit ive or failed airbag activa­
tion . In some co llisions, both front and s ide
a irbags may inflate. Remember too , that air­
bags will deploy only once and only in certa in
kinds of collisions -your safety belts are al­
ways there to offer protection in those acci­
dents in which airbags are not supposed to
deploy or when they have already deployed.
The side airbag syst em will not depl oy:
- when the ign ition is turned off
- i n s ide collisions when the accelerat ion
measured by the sensor is too low
- i n front-end co llisions -
in rear -end collisions
- in rollovers.
In some types of accidents the front airbags,
s ide curtain airbags and s ide a irbags may be
t rigge red togethe r.
_&. WARNING
- Safety belts and the airbag system wil l
only provide protection when occupants
are in the proper seating position
c::> page 163.
-If the airbag indicator light r:!:> page 20
comes when the vehicle is being used,
have the system inspected immediately
by y our authorized A udi dealer . It is pos­
sible that the airbag will inflate when it
is not supposed to, or will not inflate
when it should.
How supplemental side airbags work -
Side airbags deploy instantly and can help re­
duce the risk of upper torso injuries for occu­
pants who are properly restrained .
Fig. 158 In flated side a irbags o n left s ide of ve hicle
When the system is trigge red, the a irbag is
filled wi th propellan t gas an d breaks through
a seam in the seat surface area marked "AIR­
BAG". It expands between the side trim panel
and the passenger. In order to help provide
t h is addit ional protec tion, the side airbag
must inflate within a fraction of a second at
very h igh speed and with great force . The sup ­
plementa l side airbag could injure you if your
seat ing pos ition is not proper or up right or if
items are located in the area where the s up­
pleme ntal side airbag expands. This applies
especially to ch ild ren
c::> page 16 7, Child ..,.

Safety. Supplemental side airbags inflate be­
tween the occupant and the door pane l on the
side of the vehicle that is struck in certain s ide
collis ion¢
fig. 158 .
Although they a re not a soft pillow, they can
"cushion" the impact and in this way they can he lp to reduce the r isk of injury to the upper
part of the body.
A fine dust may develop when the airbag de­ p loys. This is norma l and does not mean there
is a fire in the veh icle .
Important safety instructions on the
side airbag system
Airbags are only supplemental restraints. Al­
ways properly wear safety belts and ride in a
proper seating position .
There is a lot that you and your passengers
must know and act accordingly to help the
safety belts and a irbags do the ir job to pro­
vide supplemental protection .
A WARNING
An inflating side airbag can cause ser ious
or fatal injury. Improperly wearing safety
belts and improper seating positions in­
crease the risk of ser ious personal inju ry
and death whenever a vehicle is being
used.
- In orde r to reduce the risk of injury when
the supplemental side airbag inflates :
- Always sit in an upright pos ition and
never lean against the area where the
supp lemental s ide a irbag is located.
- Never let a chi ld or anyone else rest
their head against the side trim panel
in the area where the supp lemental
side ai rbag inflates.
- Always make sure that safety belts are
wo rn correctly,
- Do not let anyone sitting in the front
seat put their hand or any other parts
of their body out of the window.
- Always make sure that the side airbag
can inflate witho ut interference.
A irbag system 163
-Never install seat covers or rep lace­
ment upholstery over the front seat­
backs that have not been specifically
approved by Audi.
- Never use additional seat c ushions that
cover the areas where the side a irbags
deploy.
- Damage to the orig inal seat cove rs or
to the seam in the area of the side a ir­
bag module must always be repaired
i mmediately by an author ized Audi
dealer.
- Objects between you and the airbag ca n
increase the risk of injury in an accident
by inter fer ing with the way the airbag
unfo lds o r by being pushe d in to yo u as
the airbag inflates .
- Never place or attach accessor ies or
othe r objects (such as cupho lders, tele­
phone brackets, or even large, bu lky
objects) on the doo rs, over or near the
area marked "A IRBAG" on the seat
bac krests.
-Such objects a nd accessories can be­
come dangerous project iles and cau se
i njury when the s upplementa l side air­
bag deploys .
- Never carry any ob je cts o r pe ts in the
deployment space be twee n them and
the airbags or allow ch ild ren or other
passengers to trave l in t his position.
- Always use the b uilt-in coat hooks on ly
for lightweight clo thing . Never leave any
heavy or sharp-edged objects in the
pockets that may interfere w ith side air­
bag deployment and can cause personal
injury in an acc ident.
- Always prevent the side airbags from be­ ing damaged by heavy objects knocking
aga inst or hitting the sides of the seat­
backs .
- The airbag system can only be triggered
once . If the airbag has been triggered,
the system must be replaced by an au­
thorized Audi dealersh ip.
- Damage (cracks, deep scratches etc .) to
the o rig inal seat cove rs or to the seam i n
the area of the side airbag module must .,,. •
•