2013 Lancia Thema cooling

 EXHAUST SYSTEM . . . . . . . . . . . . . . . . . . . . .280
 COOLING SYSTEM . . . . . . . . . . . . . . . . . . . . .281
 BRAKE SYSTEM . . . . . . . . . . . . . . . . . . . . . . .284
 AUTOMATIC TRANSMISSION . . . . . . . . . . . . .286
 ALL WHEEL DRIVE (AWD)(for versions/markets, where provided) . . . . . .287
 REAR AXLE . . . . . . . . . . . . . . . . . . . . . . . . . .287
 APPEARANCE CARE AND PROTECTION FROM CORROSION . . . . . . . . . . . . . . . . . . . . .288
 FUSES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .290
 Integrated Power Module . . . . . . . . . . . . . . . .290
 Rear Power Distribution Center . . . . . . . . . . .294
 VEHICLE STORAGE . . . . . . . . . . . . . . . . . . . . . .298
 REPLACEMENT BULBS . . . . . . . . . . . . . . . . . . .298
 BULB REPLACEMENT . . . . . . . . . . . . . . . . . . . .299
 LOW BEAM HEADLAMP, HIGH BEAMHEADLAMP, PARK/TURN LAMP, INNER
PARK LAMP, AND OUTER PARK LAMP . . . . . .299
 FRONT TURN SIGNAL LAMPS . . . . . . . . . . . . .300
REAR TURN SIGNAL AND BACKUP LAMPS . . .300 LICENSE LAMP . . . . . . . . . . . . . . . . . . . . . . . .301
 FLUID CAPACITIES . . . . . . . . . . . . . . . . . . . . . .302
FLUIDS, LUBRICANTS AND GENUINE PARTS . . .302 ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .302
 CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . .304
270

WARNING!
A hot exhaust system can start a fire
if you park over materials that can
burn. Such materials might be
grass or leaves coming into contact
with your exhaust system. Do not
park or operate your vehicle in ar-
eas where your exhaust system can
contact anything that can burn.
In unusual situations involving
grossly malfunctioning engine opera-
tion, a scorching odor may indicate
severe and abnormal catalyst over-
heating. If this should occur, safely
bring the vehicle to a complete stop,
shut the engine OFF, and allow the
vehicle to cool. Thereafter, obtain ser-
vice, including a tune-up to manufac-
turer's specifications immediately.
To minimize the possibility of catalyst
damage:
 Do not shut off the engine or inter- rupt the ignition when the trans-
mission is in gear and the vehicle is
in motion.
 Do not try to start the engine by pushing or towing the vehicle.  Do not idle the engine with any
spark plug wires disconnected or
removed, such as when diagnostic
testing, or for prolonged periods
during very rough idling or mal-
functioning operating conditions.
COOLING SYSTEM
WARNING!
 When working near the radiator cooling fan, disconnect the fan
motor lead or turn the ignition
switch to the LOCK position. The
fan is temperature controlled and
can start at anytime the ignition
switch is in the ON position.
 You or others can be badly
burned by hot engine coolant
(antifreeze) or steam from your
radiator. If you see or hear steam
coming from under the hood, do
not open the hood until the radia-
tor has had time to cool. Never try
to open a cooling system pressure
cap when the radiator is hot.
CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
Coolant ChecksCheck engine coolant (antifreeze) pro-
tection every 12 months (before the
onset of freezing weather, where appli-
cable). If the engine coolant (anti-
freeze) is dirty or rusty in appearance,
the system should be drained, flushed,
and refilled with fresh coolant. Check
the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If
dirty, clean by gently spraying water
from a garden hose vertically down the
face of the condenser.Check the coolant recovery bottle
tubing for brittle rubber, cracking,
tears, cuts, and tightness of the con-
nection at the bottle and radiator.
Inspect the entire system for leaks.
281

With the engine at normal operating
temperature (but not running), check
the cooling system pressure cap for
proper vacuum sealing by draining a
small amount of engine coolant (anti-
freeze) from the radiator drain cock.
If the cap is sealing properly, the
engine coolant (antifreeze) will begin
to drain from the coolant recovery
bottle. DO NOT REMOVE THE
COOLANT PRESSURE CAP WHEN
THE COOLING SYSTEM IS HOT.
Cooling System – Drain, Flush,
And Refill
If the engine coolant (antifreeze) is
dirty or contains a considerable
amount of sediment, clean and flush
with a reliable cooling system cleaner.
Follow with a thorough rinsing to re-
move all deposits and chemicals.
Properly dispose of old engine coolant
(antifreeze).
Refer to the “Maintenance Schedule”
for the proper maintenance intervals.Selection Of Coolant
Use only the manufacturer's recom-
mended engine coolant (antifreeze).
Refer to “Fluids, Lubricants, and
Genuine Parts” in “Maintaining Your
Vehicle” for further information.
CAUTION!
 Mixing of engine coolant (anti-
freeze) other than specified en-
gine coolant (antifreeze), may re-
sult in engine damage and may
decrease corrosion protection. If a
non-specified engine coolant (an-
tifreeze) is introduced into the
cooling system in an emergency, it
should be replaced with the speci-
fied engine coolant (antifreeze) as
soon as possible.
 Do not use plain water alone or alcohol-based engine coolant
(antifreeze) products. Do not use
additional rust inhibitors or anti-
rust products, as they may not be
compatible with the radiator en-
gine coolant (antifreeze) and may
plug the radiator.
(Continued)
CAUTION!(Continued)
 This vehicle has not been de- signed for use with Propylene
Glycol based engine coolant (an-
tifreeze). Use of Propylene Glycol
based engine coolant (antifreeze)
is not recommended.
Adding Coolant
Your vehicle has been built with an
improved engine coolant (antifreeze)
that allows extended maintenance in-
tervals. This engine coolant (anti-
freeze) can be used up to ten years or
240 000 km before replacement. To
prevent reducing this extended main-
tenance period, it is important that
you use the same engine coolant (an-
tifreeze) throughout the life of your
vehicle.
When adding engine coolant (anti-
freeze):
Use only high purity water such as
distilled or deionized water when
mixing the water/engine coolant (an-
tifreeze) solution. The use of lower
282

quality water will reduce the amount
of corrosion protection in the engine
cooling system.Please note that it is the owner's respon-
sibility to maintain the proper level of
protection against freezing according to
the temperatures occurring in the area
where the vehicle is operated.NOTE: Mixing engine coolant
(antifreeze) types will decrease the
life of the engine coolant (anti-
freeze) and will require more fre-
quent engine coolant (antifreeze)
changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle.The cap should be inspected and
cleaned if there is any accumulation of
foreign material on the sealing surfaces.
WARNING!
 The warning words “DO NOTOPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine cool-
ant (antifreeze) when the engine
is overheated. Do not loosen or
remove the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or
under pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your
community. To prevent ingestion by
animals or children, do not store
ethylene glycol-based engine coolant
(antifreeze) in open containers or allow it to remain in puddles on the
ground. If ingested by a child or pet,
seek emergency assistance immedi-
ately. Clean up any ground spills im-
mediately.
Coolant Level
The coolant bottle provides a quick
visual method for determining that
the coolant level is adequate. With the
engine OFF and cold, the level of the
coolant in the bottle should be be-
tween the ranges indicated on the
bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing engine cool-
ant (antifreeze). Advise your service
attendant of this. As long as the en-
gine operating temperature is satis-
factory, the coolant bottle need only
be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.
283

Points To Remember
NOTE: When the vehicle is
stopped after a few kilometers of
operation, you may observe vapor
coming from the front of the engine
compartment. This is normally a
result of moisture from rain, or
high humidity accumulating on
the radiator and being vaporized
when the thermostat opens, allow-
ing hot engine coolant (antifreeze)
to enter the radiator.
If an examination of your engine com-
partment shows no evidence of radia-
tor or hose leaks, the vehicle may be
safely driven. The vapor will soon dis-
sipate.
 Do not overfill the coolant recoverybottle.
Check engine coolant (antifreeze)
freeze point in the radiator and in
the coolant recovery bottle. If engine
coolant (antifreeze) needs to be
added, contents of coolant recovery
bottle must also be protected against
freezing.
 If frequent engine coolant (anti- freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
Maintain engine coolant (antifreeze)
concentration at 50% engine coolant
(antifreeze) (minimum) and dis-
tilled water for proper corrosion pro-
tection of your engine, which con-
tains aluminum components. Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsat-
isfactory engine coolant (anti-
freeze) performance, poor gas mile-
age, and increased emissions. BRAKE SYSTEM
In order to assure brake system per-
formance, all brake system compo-
nents should be inspected periodi-
cally. Refer to the “Maintenance
Schedule” for the proper maintenance
intervals.
WARNING!
Riding the brakes can lead to brake
failure and possibly an accident.
Driving with your foot resting or
riding on the brake pedal can result
in abnormally high brake tempera-
tures, excessive lining wear, and
possible brake damage. You would
not have your full braking capacity
in an emergency.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
(Continued)
284

FLUID CAPACITIES
Metric
Fuel (Approximate)
All Engines 72 Liters
Engine Oil with Filter
3.6 Liter Engine 5.6 Liters
3.0L Diesel Engine 9.2 Liters
Cooling System *
3.6 Liter Engine 9.5 Liters
3.0L Diesel Engine 12 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
FLUIDS, LUBRICANTS AND GENUINE PARTS
ENGINE
Component Fluids and Lubricants Specs (Genuine Parts)
Engine Coolant* Red protective agent with antifreeze action, based on inhibited monoethyl
glycol with organic formula. Exceeds CUNA NC 956-16, ASTM D 3306
specifications, FIAT Classification 9.55523 (PARAFLU UP Contractual
Technical Reference N° F101.M01. Cooling circuit usage percentage:
50% water 50% PARAFLU UP **)
Engine Oil – 3.6L Engine*** SAE Grade 5W-30 fully synthetic engine oil that meets FIAT Classification
9.55535–CR1, API SN, ILSAC GF-5 (SELENIA K POWER, Contractual
Technical Reference N° F042.F11)
302

Bulb Replacement. . . . . . . .298, 299
Bulbs, Light . . . . . . . . . . . . .58, 298
Camera, Rear . . . . . . . . . . . . . .138
Capacities, Fluid . . . . . . . . . . . .302
Caps, Filler Radiator (Coolant Pressure) . .283
Carbon Monoxide Warning . . . . . .56
Cargo Area Features . . . . . . . . . .150
Cargo Compartment . . . . . . . . . .150
Cellular Phone . . . . . . . . . . . . . .184
Chains, Tire . . . . . . . . . . . . . . .232
Chart, Tire Sizing . . . . . . . . . . . .222
Check Engine Light (Malfunction Indicator Light) . . . . . . . . . . .159
Checking Your Vehicle For Safety . .56
Checks, Safety . . . . . . . . . . . . . . .56
Child Restraint . . . . . .46, 50, 52, 53
Child Restraint Tether Anchors . . . . . . . . . . . . . . .51, 52
Child Safety Locks . . . . . . . . . . . .21
Child Seat . . . . . . . . . . . . . . . . . .47
Clean Air Gasoline . . . . . . . . . . .239
Cleaning Wheels . . . . . . . . . . . . . . . .289
Windshield Wiper Blades . . . .279
Climate Control . . . . . . . . . . . . .184
Clock . . . . . . . . . . . . . . . . . . . .181 Coin Holder
. . . . . . . . . . . . . . .148
Cold Weather Operation . . . . . . .196
Compact Disc (CD) Maintenance . . . . . . . . . . . . .184
Compact Spare Tire . . . . . . . . . .230
Computer, Trip/Travel . . . . . . . . .171
Connector UCI . . . . . . . . . . . . . . . . . .182
Universal Consumer
Interface (UCI) . . . . . . . . . . .182
Conserving Fuel . . . . . . . . . . . . .169
Console, Floor . . . . . . . . . . . . . .148
Console, Overhead . . . . . . . . . . .140
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . . .283
Cooling System . . . . . . . . . . . . .281
Adding Coolant (Antifreeze) . .282
Coolant Capacity . . . . . . . . . .302
Coolant Level . . . . . . . .281, 283
Disposal of Used Coolant . . . .283
Drain, Flush, and Refill . . . . .282
Inspection . . . . . . . . . . . . . .283
Points to Remember . . . . . . .284
Pressure Cap . . . . . . . . . . . .283
Radiator Cap . . . . . . . . . . . .283
Selection of Coolant
(Antifreeze) . . . . . . . . .282, 302
Corrosion Protection . . . . . . . . . .288 Cruise Control (Speed Control)
. . .121
Cupholders . . . . . . . . . . . .147, 290
Data Recorder, Event . . . . . . . . . .45
Daytime Brightness, Interior Lights . . . . . . . . . . . . . . . . . .114
Deck Lid, Emergency Release . . . . .27
Deck Lid, Power Release . . . . . . . .26
Defroster, Rear Window . . . . . . . .151
Defroster, Windshield . . . . . .57, 187
Delay (Intermittent) Wipers . . . . .115
Diagnostic System, Onboard . . . . .273
Diesel Fuel . . . . . . . . . . . . . . . .240
Dimmer Switch, Headlight . . . . . .112
Dipsticks Oil (Engine) . . . . . . . . . . . . .274
Disposal Antifreeze (Engine Coolant) . .283
Engine Oil . . . . . . . . . . . . . .275
Door Locks . . . . . . . . . . . . . . . . .20
Door Locks, Automatic . . . . . . . . .21
Driving Through Flowing, Rising, or
Shallow Standing Water . . . . .211
Driving to Achieve Maximum Fuel Economy . . . . . . . . . . . . . . . .169
Electrical Power Outlets . . . . . . .145
Electric Rear Window Defrost . . . .151
321

Electric Remote Mirrors. . . . . . . . .68
Electronic Brake Control System . .216
Anti-Lock Brake System . . . . .216
Brake Assist System . . . . . . . .216
Traction Control System . . . . .216
Electronic Speed Control (Cruise Control) . . . . . . .120, 121
Electronic Stability Control (ESC) . . . . . . . . . . . .217
Electronic Vehicle Information Center (EVIC) . . . . . . . .138, 163
Emergency Deck Lid Release . . . . .27
Emergency, In Case of Freeing Vehicle When Stuck . .262
Hazard Warning Flasher . . . . .254
Jump Starting . . . . . . . . . . . .260
Overheating . . . . . . . . . . . . .254
Towing . . . . . . . . . . . . . . . .266
Emergency Trunk Release . . . . . . .27
Engine Air Cleaner . . . . . . . . . . . . .275
Break-In Recommendations . . .55
Compartment . . . . . . . .271, 272
Compartment
Identification . . . . . . . .271, 272
Coolant (Antifreeze) . . . .281, 302
Cooling . . . . . . . . . . . . . . . .281
Exhaust Gas Caution . . . . . . . .56
Fails to Start . . . . . . . . . . . .196 Flooded, Starting
. . . . . . . . .196
Fuel Requirements . . . . . . . .238
Jump Starting . . . . . . . . . . . .260
Oil . . . . . . . . . . . . . . .274, 302
Oil Change Interval . . . .168, 274
Oil Disposal . . . . . . . . . . . . .275
Oil Filter . . . . . . . . . . . . . . .275
Oil Selection . . . . .274, 275, 302
Oil Synthetic . . . . . . . . . . . .275
Overheating . . . . . . . . . . . . .254
Starting . . . . . . . . . . . . . . . .195
Temperature Gauge . . . . . . . .162
Enhanced Accident Response Feature . . . . . . . . . . . . . . . . . .43
Entry System, Illuminated . . . . . . .17
Ethanol . . . . . . . . . . . . . . . . . .239
Event Data Recorder . . . . . . . . . . .45
Exhaust Gas Caution . . . . . . . . . .56
Exhaust System . . . . . . . . . .56, 280
Exterior Folding Mirrors . . . . . . . .67
Exterior Lighting . . . . . . . . . . . .109
Exterior Lights . . . . . . . . . . . . . .58
Filler Location Fuel . . . . . . . . . .160
Filters Air Cleaner . . . . . . . . . . . . .275
Air Conditioning . . . . . .189, 277
Engine Oil . . . . . . . . . .275, 302 Flashers
Hazard Warning . . . . . . . . . .254
Turn Signal . . . . . . .58, 112, 158
Flash-To-Pass . . . . . . . . . . . . . .112
Flooded Engine Starting . . . . . . .196
Floor Console . . . . . . . . . . . . . .148
Fluid, Brake . . . . . . . . . . . . . . .304
Fluid Capacities . . . . . . . . . . . . .302
Fluid Leaks . . . . . . . . . . . . . . . . .58
Fluid Level Checks . . . . . . . . . . .287
Automatic Transmission . . . . .286
Brake . . . . . . . . . . . . . . . . .285
Cooling System . . . . . . . . . . .281
Engine Oil . . . . . . . . . . . . . .274
Transfer Case . . . . . . . . . . . .287
Fluids, Lubricants and Genuine Parts . . . . . . . . . . . . .302
Fog Lights . . . . . . . . . . . . . . . .158
Fog Lights, Rear . . . . . . . . . . . .111
Folding Rear Seat . . . . . . . . . . . .105
Forward Collision Warning . .132, 166
Freeing A Stuck Vehicle . . . . . . . .262
Fuel . . . . . . . . . . . . . . . . .238, 240
Additives . . . . . . . . . . . . . . .239
Conserving . . . . . . . . . . . . . .169
Diesel . . . . . . . . . . . . . . . . .240
Filler Door (Gas Cap) . . . . . .160
Gasoline . . . . . . . . . . . . . . .238
Gauge . . . . . . . . . . . . . . . . .160
322