2012 Lancia Voyager lights

REPLACEMENT BULBS
LIGHT BULBS –
Interior Bulb Number
Center & Rear Dome Lamp . . . 578
Center & Rear Reading
Lamps . . . . . . . . . . . . . . . . . . 578
Front Door Courtesy Lamp . . . 578
Front Header Reading Lamps (for
versions/markets, where pro-
vided) . . . . . . . . . . . . . . . . . . 578
Liftgate Lamp(s) . . . . . . . . . . . 578
Overhead Console Reading
Lamps . . . . . . . . . . . . . . . . PC579
Removable Console Lamp (for
versions/markets, where
provided) . . . . . . . . . . . . . . . . 194
Visor Vanity Lamps . . . . . 6501966
NOTE:
For lighted switches, see your
dealer for replacement instruc-
tions.
All of the interior bulbs are glass
wedge base or glass cartridge types.
Aluminum base bulbs are not ap-
proved and should not be used for
replacement.LIGHT BULBS –
Exterior
Bulb Number
Headlamp . . . . . . . . . . . . . . . H11
Headlamp (HID) (for versions/
markets, where provided) . . . . D1S
Front Turn Signal . . . . . PY27 / 7W
Front Position Lamp . . . . . . . W5W
Front Fog Lamp . . . . . . . . . . . H11
Side Repeater Lamps . . . . . . W5W
Backup Lamp . . . . . . . . . P27 / 7W
Tail/Stop Lamp . . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Rear Turn
Signal Lamps . . . . . . . . PY27 / 7W
Rear Fog Lamps . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Center High-Mounted
Stop Lamp . . . . . . . . . . . . . . LED
(Serviced at Authorized Dealer)
License Plate Lamp . . . . . . . W5W BULB REPLACEMENT
HIGH INTENSITY
DISCHARGE HEADLAMPS
(HID) (for versions/markets,
where provided)
CAUTION!
Where possible, it is advisable to
have bulbs changed at a LANCIA
Dealership. Proper operation and
orientation of the external lights are
essential for driving safety and com-
plying with the law.
The headlamps are a type of high
voltage discharge tube. High voltage
can remain in the circuit even with the
headlamp switch off and the key re-
moved. Because of this, you should
not attempt to service a headlamp
bulb yourself. If a headlamp bulb
fails, take your vehicle to an au-
thorized dealer for service.
308

WARNING!A transient high voltage occurs at the
bulb sockets of High Intensity Dis-
charge (HID) headlamps when the
headlamp switch is turned ON. It may
cause serious electrical shock or elec-
trocution if not serviced properly. See
your authorized dealer for service.NOTE:On vehicles equipped with High In-
tensity Discharge (HID) headlamps,
when the headlamps are turned on,
there is a blue hue to the lamps. This
diminishes and becomes more
white after approximately 10 sec-
onds, as the system charges.QUAD HEADLAMPS (for
versions/markets, where
provided)CAUTION!
Where possible, it is advisable to
have bulbs changed at a LANCIA
Dealership. Proper operation and
orientation of the external lights are
essential for driving safety and com-
plying with the law.1. Raise the hood to access the high or
low beam bulbs at the rear of the
headlamp housing.
2. Release the two tabs on the side of
the connector and remove the connec-
tor from the bulb.
3. Twist the headlamp bulb and pull
the bulb from the headlamp housing.
4. Install the new headlamp bulb and
twist until locked into the headlamp
housing.
CAUTION!
Do not touch the new bulb with your
fingers. Oil contamination will se-
verely shorten bulb life. If the bulb
comes in contact with an oily sur-
face, clean the bulb with rubbing
alcohol.
5. Reconnect the wiring connector to
the bulb.
FRONT TURN SIGNAL AND
SIDE MARKER LAMPS
Access to change the turn signal or
side marker bulb is from the rear of
the headlamp housing. 1. Twist the turn signal or side
marker socket to remove the socket.
2. Pull bulb from the socket.
3. Replace the bulb and reinstall
socket.
SIDE REPEATER LAMPS
The side repeater lamps are located in
both front fenders.
1. Push the side repeater lamp to the
right and release retaining tab on the
left.
2. Pull side repeater lamp out and
disengage bulb socket from lamp.
3. Press, then rotate and pull bulb
from socket.
4. Install bulb to socket.
5. Push the lamp socket into the side
repeater lamp.
Side Repeater Bulb Replacement
309

CENTER HIGH-MOUNTED
STOP LAMP (CHMSL)
The CHMSL uses LED lights are not
serviceable. The CHMSL must be re-
placed as an assembly, see your au-
thorized dealer.LICENSE LAMP
There are two license plate lamps, and
they are located under the tailgate
lamp bar and above the license plate.
1. Remove the two lens assembly
mounting screws.2. Remove the bulb from the socket.
Replace the bulb and reattach the lens
assembly.
FLUID CAPACITIES
Metric
Fuel (Approximate) 76 Liters
Engine Oil with Filter
3.6L Engine 5.6 Liters
2.8L Diesel Engine 6.5 Liters
Cooling System *
3.6L Engine 12.6 Liters
2.8L Diesel Engine 13.8 Liters
* Includes heater and coolant recovery bottle filled to MAX level. Add 2.8 Liters for versions/markets, where provided
with a rear heater.
311

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Flush and replace the engine coolant (or at 60 months). 
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if neces-
sary.        
Check operation of lighting system (headlamps, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.).        
Check operation of windshield washer system and adjust
jets if necessary.        
Check windshield/rear window wiper blade position/
wear.        
Check cleanliness of hood and tailgate locks and cleanli-
ness and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, under-
body protection, pipes and hoses (exhaust - fuel system -
brakes), rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, wind-
shield washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check the handbrake lever stroke and adjust it, if neces-
sary. 

319

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter (*). 
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter. Every 12 000 km or 12 months whichever comes first
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 000 km
or 48 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi-
tion;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;  short, repeated journeys (less than
7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
320

Required Maintenance Intervals
Refer to the Maintenance Schedules on the following pages for the required maintenance intervals.
Thousands Of Kilometers20 40 60 80 100 120 140 160 180 200
Months 12 24 36 48 60 72 84 96 108 120
Flush and replace the engine coolant (or at
60 months). 
Check battery charge status and possibly recharge.          
Check tire condition/wear and adjust pressure, if
necessary.          
Check operation of lighting system (headlamps,
direction indicators, hazard warning lights, luggage
compartment, passenger compartment, glove com-
partment, instrument panel warning lights, etc.).          
Check operation of windscreen washer system and
adjust jets if necessary.          
Check windshield/rear window wiper blade
position/wear.          
Check cleanliness of hood and tailgate locks and
cleanliness and lubrication of linkages.          
Visually inspect condition of: exterior bodywork,
underbody protection, pipes and hoses (exhaust -
fuel system - brakes), rubber elements (boots,
sleeves, bushes, etc.).          
Check conditions and wear of front disc brake
pads.          
Check conditions and wear of rear disc brake pads.          
322

Periodic Checks
Every1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level. Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than
7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;  visually inspect conditions of: en-
gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
324

Adding Engine Coolant
(Antifreeze) . . . . . . . . . . . . . . 296
Adding Fuel . . . . . . . . . . . . . 258
Adding Washer Fluid . . . . . . . 294
Additives, Fuel . . . . . . . . . . . 258
Adjustable Pedals . . . . . . . . . 127
Air Cleaner, Engine (Engine
Air Cleaner Filter) . . . . . . . . . 289
Air Conditioner
Maintenance . . . . . . . . . . . . . 292
Air Conditioning . . . . . . . . . . 209
Air Conditioning Controls . . . . 209
Air Conditioning Filter . . . 220,293
Air Conditioning Refrigerant . . 292
Air Conditioning
System . . . . . . . . . . . 209,213,292
Air Conditioning System, Zone
Control . . . . . . . . . . . . . . . . . 209
Air Conditioning, Operating
Tips . . . . . . . . . . . . . . . . . . . 220
Air Conditioning, Rear
Zone . . . . . . . . . . . . . . . 212,218
Air Pressure, Tires . . . . . . . . . 245
Airbag . . . . . . . . . . . . . . . . 44,50
Airbag Deployment . . . . . . . . . 50
Airbag Light . . . . . . 49,52,64,167
Airbag Maintenance . . . . . . . . . 51
Airbag, Side . . . . . . . 46,48,49,50Airbag, Window (Side
Curtain) . . . . . . . . . . . . 46,48,50
Alarm (Security Alarm) . . . . . . 16
Alarm Light . . . . . . . . . . . . . 168
Alterations/Modifications,
Vehicle . . . . . . . . . . . . . . . . . . . 7
Anti-Lock Warning Light . . . . 164
Anti-Theft System . . . . . . . . . . 16
Antifreeze (Engine
Coolant) . . . . . . . . . . . . . 296,311
Disposal . . . . . . . . . . . . . . 297
Appearance Care . . . . . . . . . . 300
Ashtray . . . . . . . . . . . . . 143,145
Auto Down Power Windows . . . 27
Auto Up Power Windows . . . . . 27
Automatic Dimming Mirror . . . 75
Automatic Door Locks . . . . . . . 23
Automatic Headlights . . . . . . . 121
Automatic Temperature
Control (ATC) . . . . . . . . . . . . 213
Automatic Transaxle Adding Fluid . . . . . . . . 300,313
Fluid Level Check . . . . . . . 300
Selection Of Lubricant
. . 299,313
Special Additives . . . . . . . . 300
Automatic
Transmission . . . . . . 230,299,300 Adding Fluid . . . . . . . . . . . 300
Fluid and Filter Changes . . . 300 Fluid Change . . . . . . . . . . . 300
Fluid Type . . . . . . . . . . . . . 299
Gear Ranges . . . . . . . . . . . 232
Battery . . . . . . . . . . . . . . . . . 291 Gas Caution . . . . . . . . . . . . 291
Jump Starting . . . . . . . . . . 277
Keyless Transmitter
Replacement (RKE) . . . . . . . 21
Saving Feature
(Protection) . . . . . . . . . . . . 122
Belts, Seat . . . . . . . . . . . . . . . . 64
Blind Spot Monitoring . . . . . . . 78
Body Mechanism
Lubrication . . . . . . . . . . . . . . 293
Brake Assist System . . . . . . . . 242
Brake Control System,
Electronic . . . . . . . . . . . . . . . 241
Brake Fluid . . . . . . . . . . . . . . 313
Brake System . . . . . . . . . . . . 298 Fluid Check . . . . . . . . 299,313
Parking . . . . . . . . . . . . . . . 238
Warning Light . . . . . . . . . . 168
Brake/Transmission
Interlock . . . . . . . . . . . . . . . . 231
Brakes . . . . . . . . . . . . . . . . . 298
Break-In Recommendations,
New Vehicle . . . . . . . . . . . . . . 62
Bulb Replacement . . . . . . . . . 308
326