2012 Lancia Flavia radiator cap

HAZARD WARNING
FLASHERS
The Hazard Warning flasher switch is
located on the instrument panel, be-
low the radio.Press the switch to turn on the
Hazard Warning flasher. When
the switch is activated, all di-
rectional turn signals will flash on and
off to warn oncoming traffic of an
emergency. Press the switch a second
time to turn off the Hazard Warning
flashers.
This is an emergency warning system
and it should not be used when the
vehicle is in motion. Use it when your
vehicle is disabled and it is creating a
safety hazard for other motorists.
When you must leave the vehicle to
seek assistance, the Hazard Warning
flashers will continue to operate even
though the ignition is placed in the
OFF position.
NOTE:
With extended use the Hazard
Warning flashers may wear down
your battery. IF YOUR ENGINE
OVERHEATS
In any of the following situations, you
can reduce the potential for overheat-
ing by taking the appropriate action.
 On the highways — Slow down.
 In city traffic — While stopped, put
transaxle in NEUTRAL, but do not
increase engine idle speed.
CAUTION!
Driving with a hot cooling system
could damage your vehicle. If tem-
perature gauge reads “H”, pull over
and stop the vehicle with the engine
at idle, when safe. Turn the air con-
ditioner off and wait until the
pointer drops back into the normal
range. After appropriate action has
been taken, if the pointer remains on
the “H”, turn the engine off imme-
diately, and call for service.
NOTE:
There are steps that you can take to
slow down an impending overheat
condition:  If your air conditioner (A/C) is
on, turn it off. The A/C system
adds heat to the engine cooling
system and turning the A/C off
can help remove this heat.
 You can also turn the tempera- ture control to maximum heat,
the mode control to floor and the
blower control to high. This al-
lows the heater core to act as a
supplement to the radiator and
aids in removing heat from the
engine cooling system.
WARNING!
You or others can be badly burned
by hot engine coolant (antifreeze) or
steam from your radiator. If you see
or hear steam coming from under
the hood, do not open the hood until
the radiator has had time to cool.
Never try to open a cooling system
pressure cap when the radiator or
coolant bottle is hot.
166

PREPARATIONS FOR
JUMP-START
The battery in your vehicle is located
between the left front headlight as-
sembly and the left front wheel splash
shield. To allow jump-starting there
are remote battery posts located on
the left side of the engine compart-
ment.WARNING!
 Take care to avoid the radiatorcooling fan whenever the hood is
raised. It can start anytime the
ignition switch is on. You can be
injured by moving fan blades.
(Continued)
WARNING!(Continued)
 Remove any metal jewelry such as
watch bands or bracelets that
might make an inadvertent elec-
trical contact. You could be seri-
ously injured.
 Batteries contain sulfuric acid
that can burn your skin or eyes
and generate hydrogen gas which
is flammable and explosive. Keep
open flames or sparks away from
the battery.
1. Set the parking brake, shift the
automatic transmission into PARK
and turn the ignition to LOCK.
2. Turn off the heater, radio, and all
unnecessary electrical accessories.
3. Remove the protective cover over
the remote positive (+)battery post.
To remove the cover, press the locking
tab and pull upward on the cover. 4. If using another vehicle to jump-
start the battery, park the vehicle
within the jumper cables reach, set
the parking brake and make sure the
ignition is OFF.
WARNING!
Do not allow vehicles to touch each
other as this could establish a
ground connection and personal in-
jury could result.
JUMP-STARTING
PROCEDUREWARNING!
Failure to follow this procedure
could result in personal injury or
property damage due to battery ex-
plosion.
Remote Battery Posts
1 — Remote Positive (+) Post (cov-
ered with protective cap)
2 — Remote Negative (-) Post
Locking Tab
173

In unusual situations involving
grossly malfunctioning engine opera-
tion, a scorching odor may suggest
severe and abnormal catalyst over-
heating. If this occurs, stop the ve-
hicle, turn off the engine and allow it
to cool. Service, including a tune-up
to manufacturer's specifications,
should be obtained immediately.
To minimize the possibility of cata-
lytic converter damage:
 Do not shut off the engine or inter- rupt the ignition, when the trans-
mission is in gear and the vehicle is
in motion.
 Do not try to start the engine by pushing or towing the vehicle.
 Do not idle the engine with any spark plug wires disconnected or
removed, such as when diagnostic
testing, or for prolonged periods
during very rough idle or malfunc-
tioning operating conditions. COOLING SYSTEM
WARNING!
 When working near the radiator
cooling fan, disconnect the fan
motor lead or turn the ignition
switch to the LOCK position. The
fan is temperature controlled and
can start at anytime the ignition
switch is in the ON position.
 You or others can be badly burned
by hot engine coolant (antifreeze)
or steam from your radiator. If
you see or hear steam coming
from under the hood, do not open
the hood until the radiator has
had time to cool. Never try to open
a cooling system pressure cap
when the radiator is hot.
CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we do
recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
Coolant ChecksCheck engine coolant (antifreeze) pro-
tection every 12 months (before the on-
set of freezing weather, where appli-
cable). If the engine coolant (antifreeze)
is dirty or rusty in appearance, the sys-
tem should be drained, flushed, and re-
filled with fresh engine coolant (anti-
freeze). Check the front of the A/C
condenser for any accumulation of bugs,
leaves, etc. If dirty, clean by gently
spraying water from a garden hose ver-
tically down the face of the condenser.Check the coolant recovery bottle
tubing for brittle rubber, cracking,
tears, cuts, and tightness of the con-
nection at the bottle and radiator. In-
spect the entire system for leaks.
190

NOTE:
Mixing engine coolant (antifreeze)
types will decrease the life of the
engine coolant (antifreeze) and
will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that the engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle.
The cap should be inspected and
cleaned if there is any accumulation
of foreign material on the sealing sur-
faces.
WARNING!
 The warning words “DO NOTOPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine coolant
(antifreeze) when the engine is
overheated. Do not loosen or re-
move the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or un-
der pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your
community. To prevent ingestion by
animals or children, do not store eth-
ylene glycol based engine coolant (an-
tifreeze) in open containers or allow it to remain in puddles on the ground. If
ingested by a child or pet, seek emer-
gency assistance immediately. Clean
up any ground spills immediately.
Coolant Level
Four-Cylinder Engines –
the cool-
ant bottle provides a quick visual
method for determining that the en-
gine coolant (antifreeze) level is ad-
equate. With the engine idling and
warm to normal operating tempera-
ture, the level of the engine coolant
(antifreeze) in the bottle should be
between the “ADD” and “FULL”
lines, shown on the bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing coolant. Ad-
vise your service attendant of this. As
long as the engine operating tempera-
ture is satisfactory, the coolant bottle
need only be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.
192

Points To Remember
NOTE:
When the vehicle is stopped after a
few kilometers of operation, you
may observe vapor coming from
the front of the engine compart-
ment. This is normally a result of
moisture from rain, snow, or high
humidity accumulating on the ra-
diator and being vaporized when
the thermostat opens, allowing hot
engine coolant (antifreeze) to enter
the radiator.
If an examination of your engine com-
partment shows no evidence of radia-
tor or hose leaks, the vehicle may be
safely driven. The vapor will soon dis-
sipate.
 Do not overfill the coolant recoverybottle.
 Check engine coolant (antifreeze) freeze point in the radiator and in
the coolant recovery bottle. If en-
gine coolant (antifreeze) needs to
be added, the contents of the cool-
ant recovery bottle must also be
protected against freezing.  If frequent engine coolant (anti-
freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
 Maintain engine coolant (anti- freeze) concentration at 50% en-
gine coolant (antifreeze) (mini-
mum) and distilled water for
proper corrosion protection of your
engine, which contains aluminum
components.
 Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsat-
isfactory cooling performance, poor
gas mileage, and increased emis-
sions. BRAKE SYSTEM
In order to assure brake system per-
formance, all brake system compo-
nents should be inspected periodi-
cally. Refer to the “Maintenance
Schedule” for the proper maintenance
intervals.
WARNING!
Riding the brakes can lead to brake
failure and possibly a collision. Driv-
ing with your foot resting or riding
on the brake pedal can result in ab-
normally high brake temperatures,
excessive lining wear, and possible
brake damage. You would not have
your full braking capacity in an
emergency.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we do
recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
193

Capacities, Antifreeze
(Engine Coolant) . . . . . . . . . . . 16
Capacities, Fluid . . . . . . . . . . 206
Caps, FillerFuel . . . . . . . . . . . . . . . . . 160
Oil (Engine) . . . . . . . . . . . . 181
Power Steering . . . . . . . . . . 144
Radiator
(Coolant Pressure) . . . . . . . 192
Car Washes . . . . . . . . . . . . . . 196
Carbon Monoxide Warning . . . . 45
Cellular Phone . . . . . . . . . 65,123
Chains, Tire . . . . . . . . . . . . . 154
Checking Your Vehicle For
Safety . . . . . . . . . . . . . . . . . . . 45
Checks, Safety . . . . . . . . . . . . . 45
Child Restraint . . . . . 37,39,41,43
Child Restraint Tether
Anchors . . . . . . . . . . . . . . . 40,41
Cigar Lighter . . . . . . . . . . . . 100
Clean Air Gasoline . . . . . . . . . 159
Cleaning Wheels . . . . . . . . . . . . . . . 197
Windshield Wiper Blades . . . 188
Climate Control . . . . . . . . . . . 123
Clock . . . . . . . . . . . . . . . . . . 122
Coin Holder . . . . . . . . . . . . . 101
Compass . . . . . . . . . . . . . . . . 117
Compass Calibration . . . . . . . 118 Compass Variance . . . . . . . . . 118
Computer, Trip/Travel . . . . 16,117
Console, Floor . . . . . . . . . . . . 101
Convertible . . . . . . . . . . . . . . . 53
Convertible Top . . . . . . . . . . . . 53
Coolant Pressure Cap
(Radiator Cap) . . . . . . . . . . . 192
Cooling System . . . . . . . . . . . 190
Adding Coolant
(Antifreeze) . . . . . . . . . . . . 191
Coolant Capacity . . . . . . . . 206
Coolant Level . . . . . . . 190,192
Disposal of Used Coolant . . . 192
Drain, Flush, and Refill . . . . 191
Inspection . . . . . . . . . . . . . 192
Points to Remember . . . . . . 193
Pressure Cap . . . . . . . . . . . 192
Radiator Cap . . . . . . . . . . . 192
Selection of Coolant
(Antifreeze) . . . . . . . . . 191,206
Corrosion Protection . . . . . . . 196
Crankcase Ventilation Module . . 16
Cruise Light . . . . . . . . . . . . . 111
Cupholders . . . . . . . . . . . 100,198
Customer Programmable
Features . . . . . . . . . . . . . . . . 121
Data Recorder, Event . . . . . . . . 36
Deck Lid, Emergency Release . . 21 Deck Lid, Power Release . . . . . 20
Defroster, Rear Window . . . . . 102
Defroster, Windshield . . . . 46,126
Delay (Intermittent) Wipers . . . 95
Diagnostic System, Onboard . . 182
Diesel Fuel . . . . . . . . . . . . . . 206
Dimmer Switch, Headlight . . . . 93
Dipsticks
Automatic Transmission . . . 195
Oil (Engine) . . . . . . . . . . . . 183
Power Steering . . . . . . . . . . 144
Disabled Vehicle Towing . . . . . 176
Disposal Antifreeze
(Engine Coolant) . . . . . . . . 192
Engine Oil . . . . . . . . . . . . . 184
Door Locks . . . . . . . . . . . . . . . 18
Door Locks, Automatic . . . . . . 18
Driver's Seat Back Tilt . . . . . . . 88
Driving On Slippery Surfaces . . . . . 142
Through Flowing, Rising, or
Shallow Standing Water . . . 142
Electric Rear Window
Defrost . . . . . . . . . . . . . . . . . 102
Electric Remote Mirrors . . . . . . 64
Electrical Power Outlets . . . . . . 98
217

Monitor, Tire Pressure
System . . . . . . . . . . . . . . . . . 155
Multi-Function Control Lever . . 91
New Vehicle Break-In Period . . 44
Occupant Restraints . . . . 21,32,34
Occupant Restraints
(Sedan) . . . . . . . . . . . . . . . 31,32
Octane Rating, Gasoline
(Fuel) . . . . . . . . . . . . . . 158,206
Odometer . . . . . . . . . . . . . . . 109Trip . . . . . . . . . . . . . . 109,111
Oil Change Indicator . . . . 110,117
Oil Change Indicator,
Reset . . . . . . . . . . . . . . . 110,117
Oil Filter, Change . . . . . . . . . 184
Oil Filter, Selection . . . . . . . . 184
Oil Pressure Light . . . . . . . . . 108
Oil, Engine . . . . . . . . . . . 183,206 Capacity . . . . . . . . . . . . . . 206
Change Interval . . . 110,117,183
Checking . . . . . . . . . . . . . . 183
Dipstick . . . . . . . . . . . . . . . 183
Disposal . . . . . . . . . . . . . . 184
Filter . . . . . . . . . . . . . 184,206
Filter Disposal . . . . . . . . . . 184
Materials Added to . . . . . . . 184
Recommendation . . . . . . . . 206 Synthetic . . . . . . . . . . . . . . 184
Viscosity . . . . . . . . . . . . . . 206
Onboard Diagnostic System . . 182
Operating Precautions . . . . . . 182
Operator Manual
(Owner's Manual) . . . . . . . . . . . 6
Outside Rearview Mirrors . . . . . 64
Overheating, Engine . . . . . . . 166
Owner's Manual
(Operator Manual) . . . . . . . . . . 6
Paint Care . . . . . . . . . . . . . . . 196
Parking Brake . . . . . . . . . . . . 145
Passenger Seat Back Tilt
(Easy Entry System) . . . . . . . . 88
Passing Light . . . . . . . . . . . . . 93
Personal Settings . . . . . . . . . . 121
Pets . . . . . . . . . . . . . . . . . . . . 44
Phone, Cellular . . . . . . . . . . . . 65
Phone, Hands-Free
(Uconnect™) . . . . . . . . . . . . . 65
Power Deck Lid Release . . . . . . . . . 20
Door Locks . . . . . . . . . . . . . 18
Mirrors . . . . . . . . . . . . . . . . 64
Outlet (Auxiliary Electrical
Outlet) . . . . . . . . . . . . . . . . 98
Seats . . . . . . . . . . . . . . . . . . 85
Steering . . . . . . . . . . . . . . . 144 Windows . . . . . . . . . . . . . . . 19
Power Steering Fluid . . . . . . . 207
Power Transfer Unit . . . . . . . . 207
Pregnant Women and Seat
Belts . . . . . . . . . . . . . . . . . . . . 29
Pretensioners Seat Belts . . . . . . . . . . . . . . 27
Programmable Electronic
Features . . . . . . . . . . . . . . . . 121
Radial Ply Tires . . . . . . . . . . . 152
Radiator Cap (Coolant
Pressure Cap) . . . . . . . . . . . . 192
Radio (Sound Systems) . . . . . 122
Radio Operation . . . . . . . . . . 123
Radio Remote Controls . . . . . . 123
Rear Cupholder . . . . . . . . . . . 101
Rear Window Defroster . . . . . 102
Rear Window Features . . . . . . 102
Recorder, Event Data . . . . . . . . 36
Recreational Towing . . . . . . . . 163
Refrigerant . . . . . . . . . . . . . . 186
Release, Hood . . . . . . . . . . . . . 90
Reminder, Lights On . . . . . . . . 91
Reminder, Seat Belt . . . . . . . . . 29
Remote Control
Door Locks . . . . . . . . . . . . . 16
Security Alarm . . . . . . . . . . . 14
221