2012 Lancia Flavia battery

WEATHER STRIP CARE –
SOFT AND HARD TOP
Lubricate all top and door glass
weather strips periodically with a
weather strip lubricant to keep them
soft and pliable.FUSES
INTEGRATED POWER
MODULE
The Integrated Power Module is lo-
cated in the engine compartment near
the air cleaner assembly. This center
contains cartridge fuses and mini
fuses. A label that identifies each
component may be printed on the in-
side of the cover. Refer to the graphic
below for FUSES/TIPM location.
Cavity
Cartridge Fuse Mini Fuse Description
1 40 Amp Green —Power Top Module
2 —20 Amp Yellow Brake Vacuum Pump
3 —10 Amp RedCenter High Mounted Stop Light (CHMSL)/
Brake Switch
4 —10 Amp Red Ignition Switch
5 —20 Amp Yellow Trailer Tow (when present)
6 —10 Amp Red Power Mirror Switch/Climate Controls
7 —30 Amp Green Ignition Off Draw (IOD) Sense 1
8 —30 Amp Green Ignition Off Draw (IOD) Sense 2
9 40 Amp Green Battery Feed – Power Seats (for versions/
markets, where provided)
10 —20 Amp Yellow Instrument Panel/Power Locks/Interior
Lights
11 —15 Amp Lt Blue Selectable Power Outlet (Inside Center Arm
Rest)
12 —20 Amp Yellow —
13 —20 Amp Yellow Ignition/Cigar Lighter
Integrated Power Module
200

VEHICLE STORAGE
If you will not be using your vehicle
for more than 21 days, you may want
to take steps to preserve your battery.
 Disengage the mini-fuse in thePower Distribution Center labeled
IOD (Ignition Off-Draw).
 Or disconnect the negative cable from the battery. Refer to “Prepa-
ration for Jump Start” in “Jump-
Starting” to identify the location of
the negative post.
 Anytime you store your vehicle, or keep it out of service (i.e., vacation)
for two weeks or more, run the air
conditioning system at idle for
about five minutes in the fresh air
and high blower setting. This will
ensure adequate system lubrication
to minimize the possibility of com-
pressor damage when the system is
started again.
REPLACEMENT BULBS
All the inside bulbs are brass or glass
wedge base. Aluminum base bulbs are
not approved and should not be used
for replacement. LIGHT BULBS – Interior Bulb No.
Front Courtesy/Reading
Lamp . . . . . . . . . . . . . . 578/W5W
Center Courtesy/Reading
Lamp . . . . . . . . . . . . . . 578/W5W
Glove Box Lamp . . . . . . . . . . . 194
Shift Indicator Lamp . . IKLE14140
Rear Compartment (Trunk)
Lamp . . . . . . . . . . . . . . . . . . . 579
NOTE:
For lighted switches, see your au-
thorized dealer for replacement.
LIGHT BULBS – Exterior Bulb No.
Bi-Halogen Headlamp . . . . . . HIR2
Front Turn Signal Lamp . . 3157NAKFront Park Lamp . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Side Repeater Lamp . . . . . . WY5W
Front Fog Lamp . . . . . . . . . . . H11
Center High Mounted Stop
(CHMSL) Lamp . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Rear Tail/Stop Lamp . . . . . . . LED
(Serviced at Authorized Dealer)
Rear Turn Signal Lamp . . . . W16W
Rear Fog Lamp . . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Backup Lamp . . . . . . . . . . . W16W
License Lamp. . . . . . . . . . . . W5W BULB REPLACEMENT
HEADLAMP
CAUTION!
Where possible, it is advisable to
have bulbs changed at a LANCIA
Dealership. Proper operation and
orientation of the external lights are
essential for driving safety and com-
plying with the law.
1. Raise and prop open the hood. Lo-
cate the connector behind the head-
lamp.
NOTE:
It may be necessary to remove the
air cleaner filter housing and po-
sition the totally integrated power
module aside prior to replacing
the low beam headlamp on the
driver's side of the vehicle.
203

MAINTENANCE
SCHEDULE
The Scheduled Maintenance services
listed in this manual must be done at
the times or mileages specified to pro-
tect your vehicle warranty and ensure
the best vehicle performance and reli-
ability. More frequent maintenance
may be needed for vehicles in severe
operating conditions, such as dusty
areas and very short trip driving. In-
spection and service should also be
done anytime a malfunction is sus-
pected.
The oil change indicator system will
remind you that it is time to take your
vehicle in for scheduled maintenance.On Electronic Vehicle Information
Center (EVIC) equipped vehicles “Oil
Change Required” will be displayed
in the EVIC and a single chime will
sound, indicating that an oil change is
necessary.
NOTE:
 The oil change indicator mes-
sage will not monitor the time
since the last oil change. Change
your vehicles oil if it has been
12 months since your last oil
change even if the oil change in-
dicator message is NOT illumi-
nated.  Under no circumstances should
oil change intervals exceed
12 000 km or 12 months, which-
ever comes first.
Your authorized dealer will reset the
oil change indicator message after
completing the scheduled oil change.
CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
Thousands Of Kilometers 24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Flush and replace the engine coolant (or at 60 months). 
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if neces-
sary.        
212

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Check operation of lighting system (headlamps, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.).        
Check operation of windshield washer system and adjust
jets if necessary.        
Check windshield/rear window wiper blade position/
wear.        
Check cleanliness of hood and tailgate locks and cleanli-
ness and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, under-
body protection, pipes and hoses (exhaust - fuel system -
brakes), rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, wind-
shield washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check the handbrake lever stroke and adjust it, if neces-
sary. 

Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter. 
Replace spark plugs. 
213

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Replace air filter cartridge.    
Change engine oil and replace oil filter.*
Change brake fluid (or every 24 months).  
Replace pollen filter.        
* The engine oil and the oil filter must
be changed when the instrument
panel warning light comes on or in
any case every 12 months.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades. Every
3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;  check cleanliness of hood and trunk
locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
214

About Your Brakes . . . . . . . . . 145
ABS
(Anti-Lock Brake System) . . . 146
Adding Engine Coolant
(Antifreeze) . . . . . . . . . . . . . . 191
Adding Washer Fluid . . . . . . . 188
Additives, Fuel . . . . . . . . . . . 160
Air Cleaner, Engine
(Engine Air Cleaner Filter) . . . 184
Air Conditioner
Maintenance . . . . . . . . . . . . . 186
Air Conditioning Filter . . . 128,186
Air Conditioning Refrigerant . . 186
Air Conditioning
System . . . . . . . . . . . . . . 124,186
Air Conditioning, Operating
Tips . . . . . . . . . . . . . . . . . . . 129
Air Pressure, Tires . . . . . . . . . 151
Airbag . . . . . . . . . . . . . . . . . . 30
Airbag Deployment . . . . . . . . . 34
Airbag Light . . . . 32,33,36,46,108
Airbag Maintenance . . . . . . . . . 35
Airbag, Side . . . . . . . . . . 31,32,33
Airbag, Window
(Side Curtain) . . . . . . . . . . . . . 32
Alarm (Security Alarm) . . . . . . 14
Alarm System
(Security Alarm) . . . . . . . . 14,112Alterations/Modifications,
Vehicle . . . . . . . . . . . . . . . . . . . 7
Anti-Lock Brake System
(ABS) . . . . . . . . . . . . . . . . . . 146
Anti-Lock Warning Light . . . . 146
Anti-Theft Security Alarm
(Theft Alarm) . . . . . . . . . . . . . 14
Antifreeze
(Engine Coolant) . . . . . . . 191,206
Disposal . . . . . . . . . . . . . . 192
Appearance Care . . . . . . . . . . 196
Ashtray . . . . . . . . . . . . . . . . . 100
Auto Down Power Windows . . . 19
Auto Unlock, Doors . . . . . . . . . 18
Automatic Door Locks . . . . . . . 18
Automatic Headlights . . . . . . . 91
Automatic Oil Change
Indicator . . . . . . . . . . . . 110,117
Automatic Temperature
Control (ATC) . . . . . . . . . . . . 124
Automatic Transaxle . . . . . 12,134 Adding Fluid . . . . . . . . . . . 207
Selection Of Lubricant . . . . 207
Automatic Transmission . . 135,194 Adding Fluid . . . . . . . . . . . 195
Fluid and Filter Changes . . . 195
Fluid Level Check . . . . . . . 195
Fluid Type . . . . . . . . . . . . . 195
Gear Ranges . . . . . . . . . . . 137 Special Additives . . . . . . . . 195
Autostick . . . . . . . . . . . . . . . 141
Battery . . . . . . . . . . . . . . . . . 185
Keyless Transmitter
Replacement (RKE) . . . . . . . 17
Location . . . . . . . . . . . . . . 185
Belts, Seat . . . . . . . . . . . . . 23,45
Body Mechanism
Lubrication . . . . . . . . . . . . . . 187
Brake Assist System . . . . . . . . 148
Brake Fluid . . . . . . . . . . . . . . 207
Brake System . . . . . . . . . . . . 193 Anti-Lock (ABS) . . . . . . . . 146
Fluid Check . . . . . . . . 194,207
Master Cylinder . . . . . . . . . 194
Parking . . . . . . . . . . . . . . . 145
Warning Light . . . . . . . . . . 108
Brake, Parking . . . . . . . . . . . 145
Brake/Transmission
Interlock . . . . . . . . . . . . . . . . 136
Brakes . . . . . . . . . . . . . . . . . 193
Break-In Recommendations,
New Vehicle . . . . . . . . . . . . . . 44
Bulb Replacement . . . . . . . . . 203
Bulbs, Light . . . . . . . . . . . 47,203
Calibration, Compass . . . . . . . 118
216

Lead Free Gasoline . . . . . . . . 158
Leaks, Fluid . . . . . . . . . . . . . . 47
Leveling, Headlight . . . . . . . . . 94
Life of Tires . . . . . . . . . . . . . 153
Light Bulbs . . . . . . . . . . . 47,203
Lights . . . . . . . . . . . . . . . . 47,91Airbag . . . . . . 32,33,36,46,108
Automatic Headlights . . . . . . 91
Back-Up . . . . . . . . . . . . . . 205
Battery Saver . . . . . . . . . . . . 94
Brake Assist Warning . . . . . 150
Brake Warning . . . . . . . . . . 108
Bulb Replacement . . . . . . . 203
Courtesy/Reading . . . . . . . . . 93
Dimmer Switch,
Headlight . . . . . . . . . . . . 91,93
Electronic Stability Program
(ESP) Indicator . . . . . . . . . 150
Engine Temperature
Warning . . . . . . . . . . . . . . 108
Exterior . . . . . . . . . . . . . . . . 47
Fog . . . . . . . . . . . . 92,112,204
Headlight Leveling . . . . . . . . 94
Headlight Switch . . . . . . . . . 91
Headlights . . . . . . . . . . . . . . 91
Headlights On Reminder . . . . 91
Headlights On With
Wipers . . . . . . . . . . . . . . 91,96
High Beam . . . . . . . . . . . . . 93 High Beam Indicator . . . . . . 114
High Beam/Low Beam
Select . . . . . . . . . . . . . . . . . 93
Illuminated Entry . . . . . . . . . 16
Instrument Cluster . . . . . . . . 91
Interior . . . . . . . . . . . . . . . . 93
License . . . . . . . . . . . . . . . 205
Lights On Reminder . . . . . . . 91
Low Fuel . . . . . . . . . . . . . . 107
Malfunction Indicator
(Check Engine) . . . . . . . . . 113
Map Reading . . . . . . . . . . . . 93
Oil Pressure . . . . . . . . . . . . 108
Park . . . . . . . . . . . . . . . . . . 91
Passing . . . . . . . . . . . . . . . . 93
Seat Belt Reminder . . . . . . . 108
Theft Alarm
(Security Alarm) . . . . . . . . 112
Tire Pressure Monitoring
(TPMS) . . . . . . . . . . . 112,155
Traction Control . . . . . . . . . 150
Turn
Signal . . . 47,91,93,111,204,205
Voltage . . . . . . . . . . . . . . . 107
Warning (Instrument Cluster
Description) . . . . . . . . . . . . 107
Loading Vehicle . . . . . . . 161,162 Capacities . . . . . . . . . . . . . 162
Locks . . . . . . . . . . . . . . . . . . . 18 Auto Unlock . . . . . . . . . . . . 18
Automatic Door . . . . . . . . . . 18
Door . . . . . . . . . . . . . . . . . . 18
Power Door . . . . . . . . . . . . . 18
Low Tire Pressure System . . . . 155
Lower Anchors and Tether for
CHildren (LATCH) . . . . . . . 40,41
Lubrication, Body . . . . . . . . . 187
Maintenance Free Battery . . . . 185
Maintenance Procedures . . . . . 182
Maintenance Schedule . . . . . . 212
Maintenance, General . . . . . . . 182
Malfunction Indicator Light
(Check Engine) . . . . . . . . . . . 113
Map/Reading Lights . . . . . . . . 93
Master Cylinder (Brakes) . . . . 194
Memory Feature (Memory
Seat) . . . . . . . . . . . . . . . . . . . 88
Methanol . . . . . . . . . . . . . . . 159
Methanol Fuel . . . . . . . . . . . . 159
Mini-Trip Computer . . . . . . . . 117
Mirrors . . . . . . . . . . . . . . . . . . 63 Electric Powered . . . . . . . . . 64
Electric Remote . . . . . . . . . . 64
Outside . . . . . . . . . . . . . . . . 64
Vanity . . . . . . . . . . . . . . . . . 64
Modifications/Alterations,
Vehicle . . . . . . . . . . . . . . . . . . . 7
220

Taillights . . . . . . . . . . . . . . . 205
Telescoping Steering Column . . 96
Temperature Control,
Automatic (ATC) . . . . . . . . . . 124
Temperature Gauge, Engine
Coolant . . . . . . . . . . . . . 107,166
Tether Anchor, Child
Restraint . . . . . . . . . . . . . . . . . 40
Theft Alarm (Security Alarm) . . 14
Theft System
(Security Alarm) . . . . . . . . . . . 14
Tilt Steering Column . . . . . . . . 96
Time Delay, Headlight . . . . . . . 92
Tires . . . . . . . . . . . . . . . . 47,151Aging (Life of Tires) . . . . . . 153
Air Pressure . . . . . . . . . . . . 151
Chains . . . . . . . . . . . . . . . . 154
General Information . . . . . . 151
High Speed . . . . . . . . . . . . 152
Inflation Pressures . . . . . . . 151
Life of Tires . . . . . . . . . . . . 153
Pressure Monitor System
(TPMS) . . . . . . . . . . . . . . . 155
Pressure Warning Light . . . . 112
Radial . . . . . . . . . . . . . . . . 152
Replacement . . . . . . . . . . . 154
Rotation . . . . . . . . . . . . . . 155
Safety . . . . . . . . . . . . . . . . 151
Spinning . . . . . . . . . . . . . . 153 Tread Wear Indicators . . . . . 153
To Open Hood . . . . . . . . . . . . . 90
Tonneau Cover . . . . . . . . . . . . 53
Towing . . . . . . . . . . . . . . . . . 162
Disabled Vehicle . . . . . . . . . 176
Recreational . . . . . . . . . . . . 163
Traction . . . . . . . . . . . . . . . . 142
Trailer Towing . . . . . . . . . . . . 162
Transaxle Automatic . . . . . . . . . . . 12,134
Autostick . . . . . . . . . . . . . . 141
Selection of Lubricant . . . . . 207
Transmission Automatic . . . . . . . . . . 135,194
Filter . . . . . . . . . . . . . . . . . 195
Maintenance . . . . . . . . . . . 194
Transmitter Battery Service
(Remote Keyless Entry) . . . . . . 17
Transporting Pets . . . . . . . . . . 44
Tread Wear Indicators . . . . . . 153
Trip Odometer . . . . . . . . . . . . 109
Trip Odometer Reset Button . . 111
Trunk Lid (Deck Lid) . . . . . 20,21
Trunk Release Remote
Control . . . . . . . . . . . . . . . . . . 20
Trunk Release, Emergency . . . . 21
Turn Signals . . . . . 91,93,111,205 Uconnect™
(Hands-Free Phone) . . . . . . . . 65
Understanding Your
Instrument Panel . . . . . . . . . . 105
Unleaded Gasoline . . . . . . . . . 158
Untwisting Procedure, Seat
Belt . . . . . . . . . . . . . . . . . . . . 25
Vanity Mirrors . . . . . . . . . . . . . 64
Variance, Compass . . . . . . . . . 118
Vehicle Certification Label . . . 161
Vehicle Identification Number
(VIN) . . . . . . . . . . . . . . . . . . . . 7
Vehicle Loading . . . . . . . 161,162
Vehicle Modifications/
Alterations . . . . . . . . . . . . . . . . 7
Vehicle Storage . . . . . . . . 128,203
Vehicle Theft Alarm
(Security Alarm) . . . . . . . . . . . 14
Voice Recognition System
(VR) . . . . . . . . . . . . . . . . . . . 82
Warning Lights (Instrument
Cluster Description) . . . . . . . . 107
Warnings and Cautions . . . . . . . 7
Washer
Adding Fluid . . . . . . . . . . . 188
Washers, Windshield . . . 94,95,188
Washing Vehicle . . . . . . . . . . 196
223