2011 TOYOTA AYGO fuses

212STARTING AND DRIVING
Seat belts.Check that the buckles lock
securely. Make sure the belts are not
worn or frayed.
Instruments and controls.Especially
make sure the service reminder indicators,
instrument lights, and defroster are work-
ing.
Brakes.Make sure the pedal has enough
clearance.
In the engine compartment
Spare fuses.Make sure you have spare
fuses. (See “Fuse locations” on page 259
in Section 7−1.)
Coolant level.Make sure the coolant lev-
el is correct. (See page 267 in Section
7−2 for instructions.)
Battery and cables.All the battery cells
should be filled to the proper level with
distilled water. Look for corroded or loose
terminals and a cracked case. Check the
cables for good condition and connections.
Wiring.Look for damaged, loose, or dis-
connected wires.
Fuel lines.Check the lines for leaks or
loose connections.
AFTER STARTING THE ENGINE
Exhaust system.Listen for any leakage.
Have any leaks fixed immediately. (See
“Engine exhaust cautions” on page 198 in
Section 2.)
Engine oil level.Stop the engine and
check the dipstick with the vehicle parked
on a level spot. (See page 264 in Section
7−2 for instructions.)
WHILE DRIVING
Instruments.Make sure the speedometer
and gauges are working.
Brakes.In a safe place, check that the
brakes do not pull to one side when ap-
plied.Anything unusual?Look for loose parts
and leaks. Listen for abnormal noises.
If everything looks O.K., set your mind at
ease and enjoy your trip!
AYGO WE 99E37E11 02.18

DO−IT−YOURSELF MAINTENANCE: Introduction259
Fuse locations
MS71022
MS71003
Spare
fuses
MS71008c
Fuses
3. When inspection or replacement is nec-
essary, consult any authorized Toyota
dealer or repairer, or another duly qual-
ified and equipped professional.
AYGO WE 99E37E1102.18

DO−IT YOURSELF MAINTENANCE: Electrical components277
Section 7−3
DO−IT−YOURSELF MAINTENANCE
Electrical components
DChecking battery condition 278.............................
DBattery recharging precautions 280.........................
DChecking and replacing fuses 280...........................
DAdding washer fluid 282....................................
DReplacing light bulbs 282...................................
AYGO WE 99E37E1102.18

280DO−IT YOURSELF MAINTENANCE: Electrical components
Battery recharging precautions
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed
on the vehicle, be sure to turn the
engine switch to the “LOCK” position
and then disconnect the ground cable.
2. Be sure the power switch on the re-
charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
DAlways charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
DOnly do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may ex-
plode, causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
Checking and replacing fuses
MS73033
GoodBlown
Ty p e A
MS73034
GoodBlown
Ty p e B
MS73035a
GoodBlown
Ty p e C
AYGO WE 99E37E1102.18

DO−IT YOURSELF MAINTENANCE: Electrical components281
MS73028a
If the headlights or other electrical
components do not work, check the
fuses. If any of the fuses are blown,
they must be replaced.
See “Fuse locations” on page 259 in Sec-
tion 7−1for locations of the fuses.
Turn the engine switch and inoperative
component off. Pull the suspected fuse
straight out and check it.
Determine which fuse may be causing the
problem. See page 300 in Section 8 for
the functions controlled by each circuit.
Type A fuses can be pulled out using the
pull−out tool. The location of the pull−out
tool is shown in the illustration.
If you are not sure whether a fuse has
blown, try replacing the suspected fuse
with one that you know is good.
If the fuse has blown, push a new fuse
into the clip.
If you do not have a spare fuse, in an
emergency you can pull out the “DOME”
fuse, which may be dispensable for nor-
mal driving, and use it if its amperage
rating is the same.If you cannot use one of the same amper-
age, use one that is lower, but as close
to the rating as possible. If the amperage
is lower than that specified, the fuse
might blow out again but this does not
indicate anything wrong. Be sure to get a
correct fuse as soon as possible and re-
turn the substitute to its original clip.
It is a good idea to purchase a set of
spare fuses and keep them in your ve-
hicle for emergencies.
If the new fuse immediately blows out,
there is a problem with the electrical sys-
tem. Have any authorized Toyota dealer or
repairer, or another duly qualified and
equipped professional, correct it as soon
as possible.
CAUTION
Never use a fuse with a higher am-
perage rating, or any other object, in
place of a fuse. This may cause ex-
tensive damage and possibly a fire.
AYGO WE 99E37E1102.18

SPECIFICATIONS291
Section 8
SPECIFICATIONS
DDimensions 292...........................................
DWeights 293...............................................
DEngine 294................................................
DFuel 294..................................................
DService specifications 294..................................
DTires 299.................................................
DFuses 300................................................
AYGO WE 99E37E11 02.18

300SPECIFICATIONS
Fuses
MS81007a
Engine room R/B (top side)
MS81012a
Engine room R/B (back side)
MS81008a
Instrument panel J/B (left side)
MS81009a
Instrument panel J/B (right side)
MS81010a
Instrument panel J/B (back side)
AYGO WE 99E37E11 02.18

SPECIFICATIONS301
Fuses (type A)
1. H−LP RH (HI) 10 A (with daytime
running light system):Right−hand
headlights
2. H−LP LH (HI) 10 A (with daytime run-
ning light system):Left−hand head-
lights, gauges and meters
3. H−LP RH (LO) 10 A (with daytime
running light system):Right−hand
headlights
4. H−LP LH (LO) 10 A (with daytime
running light system):Left−hand
headlights, gauges and meters
5. DIMMER 20 A (with daytime running
light system):“H−LP LH (HI)”, “H−LP
RH(HI)”, “H−LP LH (LO)”, “H−LP RH
(LO)” fuses, daytime running light sys-
tem
H−LP LH 10 A (without daytime run-
ning light system):Left−hand head-
lights
6. ABS NO.2 25 A (without vehicle sta-
bility controlsystem):Anti−lock brake
systemand vehicle stability control sys-
tem
VSC NO.2 30 A (with vehicle stability
control system):Anti−lock brake sys-
tem and vehicle stability control system
7.AM230A:Starting system, “IG1”,
“IG2”, “STA” fuses
8. HAZARD 10 A:Turn signal lights,
emergency flashers, gauges and meter-
s
9. H−LP RH 10 A (without daytime run-
ning light system):Right−hand head-
lights
10. DOME 15 A:Gauges and meters, inte-
rior light, audiosystem, tachometer
11 . E F I 1 5 A :Electric cooling fan, multi-
port fuel injection system/sequential
multiport fuel injection system
12. HORN 10 A:Horn
13. SPARE 7.5 A:Spare fuse
14. SPARE 10 A:Spare fuse15. SPARE 15 A:Spare fuse
16. STA 7.5 A:Multi−mode manual trans-
mission, multiport fuel injection system/
sequential multiport fuel injection
system
17. EFI NO.2 7.5 A:Multiport fuel injection
system/sequential multiport fuel injec-
tion system, multi−mode manual trans-
mission
18. STOP 10 A:Stop lights, high mounted
stoplight, anti−lock brake system, mul-
ti−mode manual transmission
19. D/L 25 A:Power door locksystem,
wireless remote control system
20. DEF 20 A:Rear window defogger
21. TAIL 7.5 A:Daytime running light sys-
tem, tail lights, license plate lights,
position lights, headlight beam level
control system, instrumentpanel lights
22. OBD 7.5 A:On−board diagnosis sys-
tem
23. ECU−B7.5A:Multi−mode manual
transmission, daytime running light sys-
tem, vehicle stability control system,
gauges and meters, rear fog light
24. ECU−IG 7.5 A:Anti−lock brake system,
vehicle stability control system, electric
power steering system, electric cooling
fan
25. BACK UP 10 A:Back−up lights, power
door locksystem, wireless remote con-
trol system, power windows, rear win-
dow defogger, tachometer, air condition-
ing system,heatersystem
26. WIP 20 A:Windshield wiper and wash-
er, rear window wiper and washer
27. ACC 15 A:Power outlet, audiosystem
AYGO WE 99E37E11 02.18