Page 430 of 2057
24.
25.
G1065599en
2008.50 Kuga 8/2011 418-02-41
Wiring Harnesses
418-02-41
REMOVAL AND INSTALLATIONTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUALE102431
Page 432 of 2057
28.TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL 29.
Torque: 10 Nm
Installation
1.
To install, reverse the removal procedure . G1065599en
2008.50 Kuga 8/2011 418-02-43
Wiring Harnesses
418-02-43
REMOVAL AND INSTALLATION
Page 461 of 2057
Generic Electronic Module (GEM)
Refer to Wiring Diagrams Section 419-10, for
schematic and connector information.
Special Tool(s) / General Equipment
Terminal Probe Kit
418-S035Digital multimeter
Ford approved diagnostic tool
Description of operation
A diagnosis of the generic electronic module (GEM)
can be performed with the Ford approved
diagnostic tool. Furthermore, an integrated service
mode enables testing of the input and output
signals without the need for further tools. To enable
activation of service mode:
• Switch off the ignition
• Switch off all other electrical consumers
• Apply the handbrake
• Shift to neutral
• Close the doors.
Activate service mode
Proceed as follows to activate service mode:
• PRESS and HOLD the switch of the heated rear
window
• SWITCH ON the ignition.
• RELEASE the switch of the heated rear window
A signal sounds and the turn signal lamps
illuminate to indicate that service mode has been
successfully activated.
NOTE: If the alarm is armed (in vehicles fitted with
an anti-theft alarm system), service mode cannot
be activated.
Input signals
SWITCH the windshield wiper switch to the "Off"
position to test the input signals. The following is
a list of the switch signals to be tested, in no
particular order: • Turn signals (right, left, hazard warning lights)
• Windshield wiper stage I
• Windshield wiper stage II
• Windshield washer system
• Rear window wiper
• Rear window washer system
• Doors open/closed
• Door key cylinder set/reset switch
• Remote control for central locking with double
locking
• Hood up/down (in vehicles fitted with anti-theft alarm system)
• Tailgate open/closed
• Mini liftgate open/closed
• Manual A/C request signal
• Manual AUX heater request signal
• Heated windshield (if fitted)
• Parking brake
• Brake fluid level
• Cruise control system
• Autolamps
• Dipped beam
• Main beam
• Headlamp flasher
• Side lights
• Reversing lamp
• Tailgate release
• Mini liftgate release
• Interior scanning system
• Ignition switch, terminal 15 (turn key to 0 position, then turn key to II position.)
An acoustic signal sounds and the turn signal
lamps flash to indicate receipt of each input signal
by the generic electronic module.
Test the windshield wiper "intermittent mode" stage
input signal (only vehicles with adjustable
intermittent mode)
The windshield wiper switch must be switched to
"intermittent mode" in order to test the input signal.
The delay times of the input signals can then be
tested by operating the rotary switch. Each change
of the rotary switch position is indicated by an
acoustic signal and illumination of the turn signals. G1055084en
2008.50 Kuga 8/2011 419-10-11
Multifunction Electronic Modules
419-10-11
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL29011A
Page 782 of 2057
6 F U D S S H G 9 H K L F O H $ L U % D J D Q G 6 D I H W \ % H O W 3 U H W H Q V L R Q H U ' L V S R V D O , Q 9 H K L F O H ' L V S R V D O
6 S H F L D O 7 R R O V
$ G D S W H U % R [ $ &
418143
6 &
7 H V W D Q G ' H S O R \ P H Q W / H D G
$ L U % D J 3 \ U R W H F K Q L F 6 D I H W \
% H O W
IA40007
' L V S R V D O
: $ 5 1 , 1 * 6
7 R D Y R L G D F F L G H Q W D O G H S O R \ P H Q W W K H
U H V W U D L Q W V F R Q W U R O P R G X O H 5 & 0 E D F N X S
S R Z H U V X S S O \ P X V W E H G H S O H W H G : D L W D W
O H D V W R Q H P L Q X W H D I W H U G L V F R Q Q H F W L Q J W K H
E D W W H U \ J U R X Q G F D E O H V E H I R U H
F R P P H Q F L Q J D Q \ U H S D L U R U D G M X V W P H Q W W R
W K H V X S S O H P H Q W D O U H V W U D L Q W V \ V W H P 6 5 6
R U D Q \ F R P S R Q H Q W V D G M D F H Q W W R W K H 6 5 6
V H Q V R U V ) D L O X U H W R I R O O R Z W K H V H
L Q V W U X F W L R Q V P D \ U H V X O W L Q S H U V R Q D O L Q M X U \
7 R P L Q L P L ] H W K H S R V V L E L O L W \ R I S U H P D W X U H
G H S O R \ P H Q W G R Q R W X V H U D G L R N H \ F R G H
V D Y H U V Z K H Q Z R U N L Q J R Q W K H 6 5 6 ) D L O X U H
W R I R O O R Z W K L V L Q V W U X F W L R Q P D \ U H V X O W L Q
S H U V R Q D O L Q M X U \
% H I R U H G H S O R \ L Q J W K H D L U E D J P R G X O H R U
V D I H W \ E H O W S U H W H Q V L R Q H U S \ U R W H F K Q L F P D N H
V X U H W K D W D O O S H U V R Q Q H O L Q W K H Y L F L Q L W \ D U H
D Z D U H W K D W D O R X G Q R L V H E D Q J L V D E R X W W R
R F F X U ' R Q R W O H W D Q \ E R G \ D S S U R D F K F O R V H U
W K D Q P H W H U V ) D L O X U H W R I R O O R Z W K L V
L Q V W U X F W L R Q P D \ U H V X O W L Q S H U V R Q D O L Q M X U \
7 K H D L U E D J P R G X O H R U W K H V D I H W \ E H O W
S U H W H Q V L R Q H U V K R X O G Q R W E H K D Q G O H G
L P P H G L D W H O \ I R O O R Z L Q J G H S O R \ P H Q W D V W K H
D L U E D J P R G X O H Z L O O E H Y H U \ K R W ) D L O X U H W R I R O O R Z W K L V L Q V W U X F W L R Q P D \ U H V X O W L Q
S H U V R Q D O L Q M X U \
$ I W H U G H S O R \ P H Q W W K H L Q I O D W R U V E H F R P H V
L Q H U W G L U H F W F R Q W D F W W R W K H V N L Q R U H \ H V R I
D Q \ I U H H S \ U R W H F K Q L F U H V L G X H V V K R X O G E H
D Y R L G H G ) D L O X U H W R I R O O R Z W K L V L Q V W U X F W L R Q
P D \ U H V X O W L Q S H U V R Q D O L Q M X U \
$ O Z D \ V Z H D U J O R Y H V D Q G V D I H W \ J O D V V H V
Z K H Q K D Q G O L Q J G H S O R \ H G D L U E D J P R G X O H V
D Q G V D I H W \ E H O W S U H W H Q V L R Q H U V ) D L O X U H W R
I R O O R Z W K L V L Q V W U X F W L R Q P D \ U H V X O W L Q
S H U V R Q D O L Q M X U \
, I W K H D L U E D J P R G X O H R U V D I H W \ E H O W
S U H W H Q V L R Q H U S \ U R W H F K Q L F U H V L G X H V K R X O G
F R Q W D F W W K H H \ H V Z D V K W K H H \ H V Z L W K F O H D Q
Z D W H U D Q G V H H N P H G L F D O D V V L V W D Q F H ) D L O X U H
W R I R O O R Z W K L V L Q V W U X F W L R Q P D \ U H V X O W L Q
S H U V R Q D O L Q M X U \
, I D O D U J H D P R X Q W R I D L U E D J R U V D I H W \ E H O W
S U H W H Q V L R Q H U S \ U R W H F K Q L F U H V L G X H L V
L Q K D O H G V H H N P H G L F D O D V V L V W D Q F H ) D L O X U H
W R I R O O R Z W K L V L Q V W U X F W L R Q P D \ U H V X O W L Q
S H U V R Q D O L Q M X U \
5 H I H U W R % D W W H U \ ' L V F R Q Q H F W D Q G & R Q Q H F W
% D W W H U \ 0 R X Q W L Q J D Q G & D E O H V
* H Q H U D O 3 U R F H G X U H V
5 H I H U W R ) O R R U & R Q V R O H , Q V W U X P H Q W
3 D Q H O D Q G & R Q V R O H 5 H P R Y D O D Q G , Q V W D O O D W L R Q
5 H I H U W R ) O R R U & R Q V R O H , Q V W U X P H Q W
3 D Q H O D Q G & R Q V R O H 5 H P R Y D O D Q G , Q V W D O O D W L R Q
(
Y R O W E D W W H U \
6 S H F L D O 7 R R O V 6 &
* H Q . X J D
%
6 X S S O H P H Q W D O 5 H V W U D L Q W 6 \ V W H P
%
* ( 1 ( 5 $ / 3 5 2 & ( ' 8 5 ( 6
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 1240 of 2057
Driveshaft(15 514 0)
Removal
All vehicles
1.Refer to: Health and Safety Precautions (100-00
General Information, Description and
Operation).
2. Refer to: Lifting(100-02 Jacking and Lifting,
Description and Operation).
3.
E98543
x7
Vehicles with 2.0L diesel engine
4.
E114034
Vehicles with 2.5L engine
5.
E114375
All vehicles
6.
x2
x2
x2
x2
x2
x2
E114188
G1070580en2008.50 Kuga8/2011
205-01- 2
Driveshaft
205-01- 2
REMOVAL AND INSTALLATION
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 1244 of 2057
All vehicles
7. CAUTION: Make sure that theinstallation marks are aligned.
1. Torque: 35Nm
2. Torque: 35Nm
3. Torque: 35Nm
3
x2
2
1
2
1
x3
3
x2
2
1
2
1
x3
E101042
8.Torque: 25Nm
x2
x2
x2
x2
x2
x2
E114188
G1070580en2008.50 Kuga8/2011
205-01- 6
Driveshaft
205-01- 6
REMOVAL AND INSTALLATION
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 1248 of 2057
Rear axle
1
2
3
E102418
Description
Item
Rear axle differential.
1
All-wheel drive control unit
2
Haldex controlled coupling
3
G1076980en2008.50 Kuga8/2011
205-02- 3
Rear Drive Axle/Differential
205-02- 3
DESCRIPTION AND OPERATION
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 1271 of 2057
Vehicles with 2.5L engine
6.
E98543
x7
7.
E114375
8.
x2
x2
x2
x2
E114188
9.
1
2x6
x3
1
2x6
x3
E101018
G1076971en2008.50 Kuga8/2011
205-02-26
Rear Drive Axle/Differential
205-02- 26
REMOVAL AND INSTALLATION
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
