2011 AUDI TT ROADSTER light

the airbag system from working proper­ly.
- Never place seat covers or replacement
upholstery that have not been specifical­
ly approved by Audi on the front seats.
- Seat covers can prevent the Advanced
Airbag System from recognizing child re­
straints or occupants on the front pas­
senger seat and prevent the side airbag
in the seat backrest from deploying prop ­
erly .
- Never use cushions, pillows, blankets or similar items on the front passenger
seat. The additional padding will prevent
the weight-sensing mat in the seat from
accurately registering the child restraint
or person on the seat and prevent the
Advanced Airbag System from function ­
ing properly.
- If you must use a child restraint on the
front passenger seat and the child re­
straint manufacturer's instructions re­
quire the use of a towel, foam cushion or
something else to properly position the
child restraint, make certain that the
PASSENGER AIR BAG OFF light comes
on and stays on whenever the child re­
straint is installed on the front passen­
ger seat .
- If the
PASSENGER AIR BAG OFF light
does not come on and stay on, have the
airbag system inspected by your Audi
dealer.
How the Advanced Airbag System
components work together
The front Advanced Airbag System and the
side airbags supplement the protection of­
fered by the front three-point safety belts
with pretensioners and load limiters and the adjustable head restraints to help reduce the
risk of injury in a wide range of accident and
crash situations . Be sure to read the impor­
tant information about safety and heed the
WARNINGS in this chapter.
Deployment of the Advanced Airbag System
and the activation of the safety belt preten-
Airbag system 123
sioners depend on the deceleration measured
by the crash sensors and registered by the
electronic control unit. Crash severity depends
on speed and deceleration as well as the mass
and stiffness of the vehicle or object involved
in the crash .
When the electronic control unit registers a
low severity crash and the safety belt is being
used, the airbag will not deploy. I f the safety
belt is not being used, the first stage deploys,
followed by the second stage after a much lat­
er time in the crash sequence.
If the electronic control unit registers a crash
of medium severity , the first stage of the air ­
bag deploys followed by the second stage at a
much later time in the crash sequence -re­
gardless of whether the safety belt is being
used or not . In higher severity crashes as reg­
istered by the electronic control unit, both the
first and second stages deploy almost at the
same time.
On the passenger side, regardless of safety
belt use, the airbag will be turned off if the
weight on the passenger seat is less than the
amount programmed in the electronic control
unit. The front airbag on the passenger side
will also be turned off if one of the child safe­
ty seats that has been certified under Federal
Motor Vehicle Safety Standard 208 has been
recognized on the seat. The
PASSENGER AIR
BAG OFF
light comes on and stays on to tell
you when the front Advanced Airbag on the passenger side has been turned off
¢ page 116, Child r estraints on the front s eat
- some important things to know.
_&, WARNING
To reduce the risk of injury when an airbag
inflates, always wear safety belts properly .
- If you are unrestrained , leaning forward,
sitting sideways or out of position in any
way, your risk of injury is much higher.
- You will also receive serious injuries and
could even be killed if you are up against
the airbag or too close to it when it in­
flates -even with an Advanced Airbag
¢ page 115.
•
•

-The inflating airbag will hit the child
safety seat or infant carrier with great
force and w ill smash the ch ild safety seat
and child against the backrest, center
arm rest, door or roof.
- If you must install a rearward facing
child safety seat on the front passenger
seat because of exceptional circumstan­ ces and the
PASSENGER AIR BAG OFF
light does no t come on and stay on, im­
med iately install the rear-facing child
safety seat in a rear seating position and
have the airbag system inspected by your
Audi dealer .
&_ WARNING
Objects between you and the airbag will
increase the risk of in jury in a crash by in­
terfering with the way the airbag unfolds or by being pushed into you as the a irbag
inflates.
- Never hold th ings in your hands or on
your lap when the vehicle is in use .
- Never transport items on or in the area
of the front passenger seat. Objects
could move into the area of the front air­
bags dur ing braking or other sudden ma­
neuver and become dange rous projec­
t il es that can cause serious personal in­
jury if the airbags inflate.
- Never place o r attach accessories or oth­
er objects (such as cup ho lders, tele­
phone brackets, large, heavy or b ulky ob­
jects) on the doors, over or near the area
marked "AIRBAG" on the steering wheel,
instrument panel, seat backrests or be­
tween those areas and yourself. These
objects could cause injury in a crash, es­
pecially when the airbags inflate.
- Never recline the front passenger's seat
to transport objects. Items can also move into the area of the side airbag or
the front airbag dur ing braking or in a
sudden maneuver. Objects near the air­
bags can be come project iles and cause
injury, part icularly when the seat is re­
cl ined.
-
A irbag sys tem 125
&_ WARNING
The fine dust created when airbags deploy
can cause breathing prob lems fo r people
with a history of as thma or other breath­
ing cond itions.
- To reduce the risk of breath ing problems,
those with asthma o r other respiratory
conditions s hou ld get fresh air r ight
away by getting o ut of the veh icle or
open ing windows or doors.
- If you are in a collision in which airbags
deploy, wash your hands and fa ce with
mild soap and wate r before eating.
- Be ca reful not to get the dust in to your
eyes, o r into any c uts or sc ratches.
- If the residue should get into your eyes,
f lush them w ith wate r.
Monitoring the
Advanced Airbag System
fl~ Airbag monitoring indicator light
Two separate indicators monitor the function
of the Advanced Airbag System: the airbag
monitoring indicator light and the
PASSEN­
GER AIR BAG O FF
light.
T he Advanced A irbag System (includ ing the
electron ic co ntro l unit, sensor circu its and sys­
tem wiring) is monitored continuously to
make sure that it is function ing properly
whenever the ignition is on. Each time you
turn on the ignition, the airbag mon itoring in­
dicator light
I will come on for a few seconds
(self diagnostics).
Th e syste m mu st b e in spected when the
indicator light
I :
- does not come on when the ignition is
sw itched on,
- does not go out a few seconds after you
have switched on the ignit ion, or
- comes on while driving.
If an airbag system malfunction is detected,
the indicator light wi ll first start flashing to
catch the driver's attention and then stay on
llo-
•
•

126 Airbag system
con tinuously to serve as a constant remin der
to have the system inspected immed iately.
I f a malfu nction occurs that turns the front
a ir bag on the passenger side off, the
PAS SEN­
GER AIR BAG OFF
li ght will come on and stay
on whenever the ignition is on .
.&_ WARNING
An airbag system that is not functioning
properly cannot provide supplemental pro­
tection in a frontal crash.
- If the airbag indicator light comes on, it
means that the re may be somet hing
wrong with the Advanced Airbag System.
It is possible that the airbag will inflate
when it is not s upposed to, or w ill not in­
flate when it should.
- Have the airbag system inspected imme­
diat ely by your Au di dealer .
PASSENGER AIR BAG OFF light
Fig. 122 Sect ion from the instr um ent pa nel: PASS EN ­
GER AIR BA G OFF light
The PASSENGER AIR BAG OFF Light is Located
in the cen ter of the instr ument panel
~ fig. 122 .
The PAS SENGE R AIR BAG OFF Light will come
on and stay on to tell you when the front Ad·
vanced A irbag on the passenger side has been
turned off by t he e lectronic control unit. Each
time you tu rn on the ig nition, the
PASSEN­
GER AIR BAG OFF
li ght will flash for a few
seconds and:
- wi ll stay on if the fron t passenger seat is not
occupied,
- will stay on if there is a small child or ch ild
rest raint on the front passenger seat, -
will go out i f the front passenge r seat is oc­
cup ied by an adult as registered by the
weight -sensing mat .
T he
PASSENGER AIR BAG OFF light mu st
come on and stay on
if the ignition is on and
- a ca r bed has been installed on the front
seat , or
- a r earward-facing child rest raint has been
installed o n the front passenger seat, or
- a forward-fac ing ch ild restra int has b een in·
stalled on the front passenger seat , o r
- the weight reg iste red on the front passen­
ger seat is equal to o r less than the com·
b in ed weight o f a typical 1 year-old restra in­
ed in one of the rear-facing or forwa rd-fac ­
ing infant restraints Listed in Federal Motor
Ve hicle Safety Standard 208 with which the
Advanced A irbag System in you r vehicle was
certified .
If the front passenger seat is not occupied,
t h e front airbag wi ll not deploy, and the
PAS­
SENGER AIR BAG OFF
Light will stay on . Nev ­
er install a rea rward -facing child restraint on
t h e front passenger seat, the safest p lace for
a chi ld in any kind of ch ild restraint is at one
of the seating posit io ns on t he rear seat
~ page 116, Child restraints on the front seat
- some important things to know
and
~ page 136, Child Safety.
If the PA SSENGER AIR BAG OFF light come s
on
when one of the cond itions Listed above is
met, be sure to check the Light regu larly to
make ce rtain tha t t he
PASSENGER AIR BAG
OFF
Light stays on con tinuously wheneve r th e
ignition is on . If the
PASSENGER AIR BAG
OFF
Light does not appear and not stay on a ll
the time, stop as soon as it is safe to do so a nd
- reactivate the system by t urning the ign ition
off and then turning it on again;
- remove and reins tall the ch ild res tra int.
Make s ure that the ch ild restra int is properly
installed and that the safety belt for the
front passenger seat has been correctly .,.

routed around the child restraint as descri­
bed in the chi ld restraint manufacturer's
instruct ions;
- make sure that the convertible locking fea­
ture on the safety belt for the front passen­ ger seat has been activated and that the
safety belt has been pulled tight. The belt must not be loose or have loops of slack so
that the sensor below the safety belt latch
on the seat can do its job
~ page 144 .
-make sure that th ings that may increase the
weight of the ch ild and child safety seat are
not being transpo rted on the front passen­
ger seat;
- make sure that the safety belt tension sen­
sor is not b locked. Shake the safety belt
latch on the front passenge r sea t back and
forth;
- If a st rap or tether is being used to tie the
child safety seat to the front passenger
seat, ma ke s ure that i t is not so tight tha t it
ca uses the weight -sensing mat to meas ure
more weight than is actually on the seat .
If the PASSENGER AIR BAG OFF light still
d oes not come o n
and does not stay on con­
tinuously (when the ignition is switched on),
- ta ke the ch ild restraint off the front passen-
ger seat and insta ll it p roperly at one of the
rear seat pos itions. Have the a irb ag system
inspected by your A udi dealer immediately.
- move the chi ld to a rea r seat posi tion and
make su re that the ch ild is p roperly res train ­
ed in a child restraint that is appropriate for
its size and age .
The
PASSENGER AIR BAG OFF light shou ld
NO T come on when the ign ition is on and an
ad ult is sitting in a proper seating position on
the front passenger seat.
If the PASSENGER
AIR B AG O FF
light comes on and stays on or
flashes for about 5 seconds while dr iv ing, un­
der these circumstances, make sure that:
- the ad ult on the front passenger seat is
properly seated on the center of the seat
c u shi on with h is or her back up against the
backrest and the backrest is not reclined
A irbag system 127
~ page 99, Proper occupant seating posi ­
tions,
- the adult is not tak ing we ight off the seat by
holding on to the passenger assist handle
above the front passenger door or support­
ing their weight on the armrest,
- the safety be lt is being properly worn and
that there is not a lot of s lack in the safety
be lt webbing,
- accessory seat covers or cushions or other
things that may cause an incorrect reading
or impression on the weight-sensing mat
under the upho lstery of the seat have been
removed from the front passenger seat,
- a safety belt extender has not been left in
the safety belt latch for the front passenger
seat .
In add ition to the
PA SSEN GER AIR BAG O FF
light in the center of the instrument panel,
the message
PASS ENGE R AIR BAG O FF or
PASSENGER AIR BAG ON w ill briefly appear
i n the instrument cluster d isp lay . This is to in­
form the dr iver of the current front passenge r
a irbag sta tus.
Important safety instructions on
monitoring the Advanced Airbag System
A WARNING
An ai rbag system that is not functioning
p roperly cannot provide supplemental pro­
tection in a frontal crash.
- If the airbag ind icator light comes on, it
means that there may be something
wrong wi th the Advanced Airbag Sys tem.
It is poss ible that the ai rbag w ill inflate
when it is not supposed to, or will not in ­
f late when it sho uld .
- Have the airbag system inspected imme­
diate ly by yo ur Audi dealer.
A WARNING
If the front airbag inflates, a child without
a child restraint, in a rearward -facing child
safety seat or in a forward-facing child re­
straint that has not been proper ly installed
-
will be ser ious ly injured and can be killed. ~
•
•

128 Airbag system
-Even though your vehicle is equipped
with an Advanced Airbag System, make
certain that all children, especially 12
years and younger, always ride on the
back seat properly restrained for their
age and size.
- If you must install a rearward-facing
child safety seat on the front passenger
seat because of exceptional circumstan­
ces and the
PASSENGER AIR BAG OFF
light does not appear and stay on, imme­
diately install the rear-facing child safety
seat in a rear seating position and have the airbag system inspected by your Audi
dealer.
- A tight tether or other strap on a rear­
ward-facing child restraint attached to
the front passenger seat can put too
much pressure on the weight-sensing
mat in the seat and register more weight
than is actually on the seat. The heavier
weight registered can make the system
work as though an adult were on the seat
and deploy the Advanced Airbag when it
must be suppressed causing serious or
even fatal injury to the child.
- If, in exceptional circumstances, you
must install a forward-facing child re­
straint on the front passenger seat, al­
ways move the seat into its rearmost po­
sition in the seat's fore and aft adjust­
ment range, as far away from the airbag
as possible. The backrest must be adjust­
ed to an upright position . Make sure that
the
PASSENGER AIR BAG OFF light
comes on and stays on all the time when­
ever the ignition is switched on.
A WARNING
- If the PASSENGER AIR BAG OFF light
does not go out when an adult is sitting
on the front passenger seat after taking
the steps described above, have the air­
bag system inspected by your Audi deal­
er before transporting anyone on the
front passenger seat.
-
(!) Tips
If the weight-sensing mat in the front pas­
senger seat detects an empty seat, the
front airbag on the passenger side will be
turned
off, and PASSENGER AIR BAG OFF
will stay on.
Repair , care and disposal of the airbags
Parts of the airbag system are installed at
many different places on your Audi. Installing,
removing, servicing or repairing a part in an
area of the vehicle can damage a part of an
airbag system and prevent that system from
working properly in a collision.
There are some important things you have to
know to make sure that the effectiveness of
the system will not be impaired and that dis­
carded components do not cause injury or pol­
lute the environment.
A WARNING
-Improper care, servicing and repair proce-
dures can increase the risk of personal in­
jury and death by preventing an airbag from deploying when needed or deploying
an airbag unexpectedly:
- Never cover, obstruct, or change the
steering wheel horn pad or airbag cover
or the instrument panel or modify them
in any way.
- Never attach any objects such as cup
holders or telephone mountings to the
surfaces covering the airbag units.
- For cleaning the horn pad or instrument
panel, use only a soft, dry cloth or one
moistened with plain water. Solvents or
cleaners could damage the airbag cover
or change the stiffness or strength of the material so that the airbag cannot de­
ploy and protect properly.
- Never repair, adjust, or change any parts
of the airbag system.
- All work on the steering wheel, instru­
ment panel, front seats or electrical sys-
tem (including the installation of audio
II),

equipment, cellular telephones and CB
radios, etc.) must be performed by a
qualified technician who has the training
and special equipment necessary.
- For any work on the airbag system, we
strongly recommend that you see your authorized Audi dealer or qualified work­
shop.
- Never modify the front bumper or parts
of the vehicle body .
- Always make sure that the side airbag
can inflate without interference:
- Never install seat covers or replace­
ment upholstery over the front seat­
backs that have not been specifically
approved by Audi.
- Never use additional seat cushions that cover the areas where the side airbags inflate.
- Damage to the original seat covers or
to the seam in the area of the side air­
bag module must always be repaired
immediately by an authorized Audi
dealer.
- The airbag system can be activated only once. After an airbag has inflated, it
must be replaced by an authorized Audi
dealer or qualified technician who has
the technical information, training and special equipment necessary.
- The airbag system can be deployed only
once. After an airbag has been deployed,
it must be replaced with new replace­
ment parts designed and approved espe­
cially for your Audi model version. Re­
placement of complete airbag systems
or airbag components must be per­
formed by qualified workshops only .
Make sure that any airbag service action
is entered in your Audi Warranty
& Main­
tenance booklet under
AIRBAG REPLACE ­
MENT RECORD.
-For safety reasons in severe accidents,
the alternator and starter are separated
from the vehicle battery with a pyrotech­ nic circuit interrupter.
Airbag system 129
-Work on the pyrotechnic circuit inter­
rupter must only be performed by a
qualified dealer - risk of an accident!
- If the vehicle or the circuit interrupter
is scrapped, all applicable safety pre­
cautions must be followed.
Other things that can affect Advanced
Airbag performance
Changing the vehicle's suspension system can
change the way that the Advanced Airbag Sys­
tem performs in a crash. For example, using
tire-rim combinations not approved by Audi,
lowering the vehicle, changing the stiffness of
the suspension, including the springs, suspen­
sion struts, shock absorbers etc. can change
the forces that are measu red by the airbag
sensors and sent to the electronic control unit. Some suspension changes can, for exam­
ple, increase the force levels measured by the
sensors and make the airbag system deploy in
crashes in which it would not deploy if the
changes had not been made. Other kinds of
changes may reduce the force levels meas­
ured by the sensors and prevent the airbag
from deploying when it should .
The sensors in the safety belt buckle for the
driver and front passenger seat tell the elec­
tronic control module if the safety belt is
latched or not. If the safety belt is being used,
the front airbag will deploy at a slightly high-
er rate of vehicle deceleration than if the safe-
ty belt is not being used . Therefore, in a par ­
ticular collision, it is possible that an airbag
will not deploy at a seating position where the
safety belt is being used but will inflate at the
position where the safety belt is not being
used.
It is important that nothing interfere
with the safety belt buckles so that the sen-
sors can send the correct information about
safety belt use to the electronic control unit. ..,.
•
•

The safety belt buckle for the driver and front
seat passenger have switches that tell the air­
bag control mod ule if the safety belt is being
used or not. If the safety belt is being used,
the knee airbag will deploy at a slightly higher
rate of deceleration than if the belt is not be­
i ng used. Therefo re, i n a pa rtic ular collision, it
is poss ible that an airbag will not deploy at a
seating position whe re the safety belt is being
used but will inflate at the position whe re the
safety be lt is not being used .
R emembe r too, airbags will deploy only once
and on ly in ce rtain kinds of accidents -your
safety be lts are a lways there to offer pro te c­
t ion in those acc idents in which airbags are
not supposed to deploy or when they have a l­
ready deployed, fo r example when your vehi­
cle strikes or is struck by another after the
f irst coll is ion.
This is just one o f th e reasons why an ai rbag is
not a substitute for the safety belt . The airbag
system works most effective ly when used with
the safety belts. Therefore, always wear your
safety belts correctly .
It is important to remember that while the
supp lemental airbag system is designed to re­
duce the likelihood of serio us inj uries, other
in juries, for example, swel ling, bruising, and
minor abrasions can also be associated with
a ir bags .
The knee airbag sy stem ba sically consist s
of:
- The electronic control modu le
- Two inflatable airbags (airbag and gas gen-
erator), one for the driver and one for the
front passenger
- The airbag indicator light in the instrument
panel
The knee airbag sy stem will not deploy :
-when the ignition is turned off
- in fron t-end col lisions w hen the dece lerat ion
measured by the control unit is too low
- in s ide collisions
- i n rear-end colli sions
- in ro llovers
A irbag system 131
- in the event of a system mal function (warn ­
ing/indicator light illuminated)
r=>poge 16.
A WARNING
-Safety belts and the airbag system can
only provide pr otection w hen occupants
are in the proper seating position
r=>poge 124.
-If the ai rbag ind icator light comes when
the vehicle is be ing used, have the sys­
tem inspected immediate ly by yo ur au­
thori zed A udi deal er. The airbag may not
wo rk p roperly when the vehicle a ccele ra­
tion in a side col lision i s high enough to
dep loy the airbag. See also
c=:> page 16.
How knee airbags work
The risk of injury to the leg area is reduced by
fully deployed knee airbags.
Fig. 1 24 In flated a irbags protec ting in a fronta l coll i­
sio n
The knee airbag system has been designed so
that the a irbags for the driver and front pas­
senger are dep loyed in certa in but not a ll
fron tal coll is io ns.
If the front a irbags dep loy, the knee a irbags
also dep loy in fronta l co llisions above ace r­
ta in seve rity .
When the system is dep loyed, the a irbags
start to fill w ith a propellant gas, and inflate
betwee n the lower pa rt of the instrument
panel and the driver and the lowe r part of the
in strume nt pa nel and the fron t passenger
r=> page 124 , fig . 12 1.
Although they are not a soft p illow , they can
"c ushion" the impact and in th is way they can
Ill>

The side airbags are located in the sides of the
fro nt seat backrests ¢
fig. 125 facing the
doors. They are identified by the word "AIR ­
BAG".
The side airbag system basically consists of:
-the e lectronic control module and external
s ide impact senso rs
- the two side airbags located in the sides of
the front backrests
- the a irbag warning light in the instrument
cluster.
The airbag system is monitored electron ically
to make certain that it is functioning properly
at all times . Each time you turn on the igni­
tion, t he a irbag system indicator light will
come on for a few seconds (self diagnos tics) .
The s ide a irbag system supplements the safe­
ty belts and can help to reduce the risk of in­
jury to the driver's and front passenge r's up­
per torso on the side of the vehicle that is
struck in a side collision. The airbag deploys in
side impacts and only when the vehicle acce l­
eration registered by the control unit is hig h
enough. If this rate is below the reference val ­
ue programmed into the control un it, the side
airbags w ill not be triggered, even though the
car may be badly damaged as a result of the
coll is ion . It is not poss ible to define an airbag
triggering range that will cover every possible
angle of impact, since the circumstances w ill
va ry considerably between one collis ion and
another. Important factors include, for exam­
ple, the nature (hard or soft) of the impacting
object, the angle of impact, vehicle speed,
etc.
c> page 134, Important safety instruc­
tions on the side airbag system.
Aside from their normal safety function, safe­
ty belts work to he lp keep the driver or front
passenger in posit ion in the event of a side
coll is ion so that the side a irbags can provide
protection.
The airbag system is
not a substitute for your
safety belt. Rather, it is part of the overall oc ­
cupant restraint system in your veh icle. Al­
ways remember that the side airbag system
can only help to protect you if you are wear ing
Airbag system 133
your safety be lt and wearing it properly. This
is another reason why you should always wear
your safety be lts, not just because the law re­
quires you to do soc;,
page 107, General
notes.
It is important to remember that wh ile the
supplementa l side airbag system is designed
to reduce the likelihood of ser ious injuries,
other injur ies, for example, swelling, bru is ing,
and minor abrasions can also be associated
with deployed s ide airbags. Remember too,
s ide airbags wi ll dep loy only once and only in
certain kinds of accidents -your safety belts
a re always there to offer protection.
Vehicle damage, repair costs or even the lack
of veh icle damage are not necessarily an indi­
cation of over-sensitive or failed airbag activa­
tion. In some collision s, both front and side
airbags may inflate. Remember too, that air­
bags will deploy only once and only in certain
kinds of collisions -your safety belts are al­
ways there to offer protection in those acci­
dents in which airbags are not supposed to
deploy or when they have already deployed .
The side airbag system will not deploy:
-when the ignition is turned off
- in side collisions when the acceleration
meas ured by the sensor is too low
- in rea r-end co llision s
- in rollove rs.
In some types of accidents the front airbags
and s ide a irbags may be triggered together .
A WARNING
-Safety belts and the airbag system will
only provide protection when occupants
are in th e proper seating position
c;,page 134.
- If the airbag indicator light comes on
when the vehicle is being used, have the
system inspected immediately by your
authorized Audi dealer. The airbag may
not work properly when the vehicle ac­
celeration in a side coll is ion is high
enough to activate the a irbag. •
•