2010 FIAT LINEA RHD ignition

108
GLOW PLUG
WA R M I N G
(Multijet versions - amber)
GLOW PLUG
WARMING FAILURE
(Multijet versions - amber)
Glow plug warming
The warning light will go on when the key
is turned to MAR. It will go out as soon
as the glow plugs have
reached a prede-
termined temperature. Start the engine as
soon as the warning light goes out.
IMPORTANT With hot ambient temper-
ature, warning light stays on for very short
time.
Glow plug warming failure
The warning light will blink in the event
of a failure to the glow plug heating sys-
tem. Go to a Fiat Dealership as soon
as possible.
On certain
versions the dedicated message
is displayed.
WATER IN DIESEL
FUEL FILTER
(Multijet versions - amber)
Turning the ignition key to MARthe
warning light turns on, but it should go off
after few seconds.
The warning light turns on when there is
water in the diesel fuel filter.
On certain
versions the dedicated message
is displayed.
The presence of water in the
feeding circuit may cause se-
vere damage to the injection
system and irregular engine
operation. If warning light lights up
(on some versions with the message on
the display), go to a Fiat Dealership
as soon as possi bl e to hav e the
system bled. Water may have been intro-
duced in the tank if this appears imme-
diate ly afte r refu ellin g: in this case ,
stop the engine immediately and cont-
act a Fiat Dealership.
CAR PROTECTION
SYSTEM FAILURE -
FIAT CODE (amber)
Turning the key to MARthe warning light
shall flash only once and then go off.
If with the ignition key at MAR, the warn-
ing light stays on, this indicates a possible
failure (see “Fiat Code system” in section
“Dashboard and controls”).
IMPORTANT Warning lights and
will come on at the same time to indicate
a Fiat CODE system failure.
If with the engine running the warning light
flashes, this means that the car is not
protected by the engine inhibitor device
(see “Fiat Code system” in section “Dash-
board and controls”).
Contact Fiat Dealership to have all the
key stored.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 108LINEA Owner HAND BOOK RHD.pdf 1088/21/09 2:16:15 PM8/21/09 2:16:15 PM

20 70
30
40
20/30
20/30/40
30
15
10
7.5
7.5
15 7.5
10
7.5 F03 F01
F04
F05
F06
F07
F08
F10
F11
F14
F15
F17 F16
F18
F19
Fuse box in engine compartment
LOADS FUSE AMPERES
Ignition switch Dashboard CPL1
Brake valves
Brake pump
Engine cooling fan (low speed)
Engine cooling fan (high speed)
Climate control fan
Horn
Engine control system secondary loads
Right main beam headlight
Left beam headlight
Engine control system primary loads EOBD
Engine control unit
Conditioner compressor
133
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 133LINEA Owner HAND BOOK RHD.pdf 1338/21/09 2:16:21 PM8/21/09 2:16:21 PM

15
15/20
20
–
50
15 F21
F22
F23
F24
F00
F30
LOADSFUSE AMPERES
Fuel pump
Engine control system primary loads (injectors, ignition coils)
Windscreen wiper motor
Spare
Glow plug pre-heating unit
Fog lights
134
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 134LINEA Owner HAND BOOK RHD.pdf 1348/21/09 2:16:21 PM8/21/09 2:16:21 PM

The total intake of these systems (facto-
ry and after-market) must be less than 0.6
mA x Ah (of the battery) as shown in the
following table:
Battery Maximum
permissible
loadless
consumption
40 Ah 24 mA
50 Ah 30 mA
60 Ah 36 mA
If after buying the car, you want to install
electric accessories which require per-
manent electric supply (alarm, etc.) con-
tact Fiat Dealership whose qualified
personnel, in addition to suggesting the most
suitable devices, will evaluate the overall
electric absorption, checking whether the
car’s electric system is capable of with-
standing the load required, or whether it
should be integrated with a more power-
ful battery.
Since these devices continue absorbing en-
ergy even when the ignition key is off, they
gradually run down the battery. USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and length-
en its life, observe the following indica-
tions:
when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
switch off all lights inside the car: the
car is however equipped with a system
which switches all internal lights off au-
tomatically;
do not keep accessories (e.g. sound sys-
tem, hazard lights, etc.) switched on for
a long time when the engine is not run-
ning;
before performing any operation on the
electrical system, disconnect the bat-
tery negative cable;
make sure that battery terminals are al-
ways be perfectly tight.
Always wear the proper pro-
tective eyewear when work-
ing on the battery or near it.
WARNING
151
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 151LINEA Owner HAND BOOK RHD.pdf 1518/21/09 2:16:35 PM8/21/09 2:16:35 PM

IDENTIFICATION DATA ................................................. 160
ENGINE CODES - VERSIONS .......................................... 161
ENGINE .................................................................................. 162
FUEL FEED/IGNITION ....................................................... 163
TRANSMISSION .................................................................. 163
BRAKES ................................................................................... 164
SUSPENSIONS ....................................................................... 164
STEERING ............................................................................... 164
WHEELS .................................................................................. 165
DIMENSIONS......................................................................... 169
PERFORMANCE ................................................................... 170
WEIGHTS ............................................................................... 171
CAPACITIES ........................................................................... 172
FLUIDS AND LUBRICANTS .............................................. 173
TT T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
159
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 159LINEA Owner HAND BOOK RHD.pdf 1598/21/09 2:16:36 PM8/21/09 2:16:36 PM

Modifications or repairs to the fuel feed system that are not carried out properly or do not take the system’s
technical specifications into account can cause malfunctions leading to the risk of fire.
WARNING
TRANSMISSION
1.4 16v -1.3 Multijet
Gearbox Five forward gears plus reverse with synchronisers for forward gears
Clutch Self-adjusting with pedal without idle stroke
Drive Front
Fuel feedMultipoint electronic injection Multijet direct injection
“Common Rail”
FUEL FEED/IGNITION
1.4 16v1.3 Multijet
163
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 163LINEA Owner HAND BOOK RHD.pdf 1638/21/09 2:16:37 PM8/21/09 2:16:37 PM

176
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Dimensions ........................................ 169
Dipped beam headlights
- control ........................................... 51
- bulb replacement ........................ 122
Direction indicators
- control ........................................... 52
- front bulb replacement ..............
122
- rear bulb replacement ............... 123
- side bulb replacement ................
123
Doors .................................................. 64
Engine
- identification code ...................... 161
- marking ..........................................
160
- technical data ............................... 162
Engine compartment
- washing ..........................................
156
Engine coolant ...................................
147
Engine coolant temperature gauge .. 15
Engine oil
- consumption ................................ 146
- level check .................................... 146
- specifications ................................
173
EOBD system .................................... 72
External lights .................................... 51
Fiat CODE system .......................... 6
Flashing the headlights ..................... 51
Fluid levels ..........................................
146
Fluids and lubricants ........................ 173
Follow me home (device) ............... 52
Front ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Front fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Fuel
- level gauge .................................... 15
Fuel cut-off switch ............................ 59
Fuel filler cap ..................................... 76
Fuel level gauge ................................. 15
Fuses (replacement) ........................ 128
Gearbox
- using manual gearbox .................
97
Glass holder - can holder ............... 62
Glove box/oddment compartment .. 60
Handbrake ........................................ 96
Hazard lights ...................................... 57
Head restraints
- front ............................................... 33
- rear .................................................
34
Headlights
- beam adjustment ......................... 70
Heated rear window ....................... 42
Heating and ventilation ................... 37
Identification data ............................ 160
Ignition device ................................... 12
In an emergency ............................... 111
Instrument panel .............................. 13
Instruments ....................................... 14
Interior fittings .................................. 60
Interiors ............................................. 157
Jack ..................................................... 114
jacking the car ...................................
116
LINEA Owner HAND BOOK RHD.pdf 176LINEA Owner HAND BOOK RHD.pdf 1768/21/09 2:16:38 PM8/21/09 2:16:38 PM

178
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Speedometer ..................................... 14
Starting and driving ..........................
93
Starting the engine
- bump starting ...............................
113
- diesel engines ............................... 94
- emergency start-up .................... 112
- ignition switch .............................. 12
- jump starting ................................ 112
- petrol engines ..............................
93
- stopping the engine .................... 95
- warm up the engine after
just started ...................................
95
Steering .............................................. 164
Steering column lock .......................
12
Steering wheel ...................................
35
Sun visors ........................................... 63
Suspensions ....................................... 164
Symbols ............................................... 6
Tailgate .............................................. 67
Technical specifications ................... 159
Third brake light ...............................
125
Top speeds .........................................
99
Towing the car .................................. 135
Transmission ......................................
162Ty r e s
- replacing a wheel ........................ 113
- maintenance .................................
152
- reading tyre markings ................ 165
- standard tyres ..............................
167
- cold tyre inflation pressure ....... 168
Using the manual gearbox ............ 97
Warning lights and messages ...... 101
Weights .............................................. 171
Wheel .................................................
165
- replacing a wheel ........................ 113
- spare wheel .................................. 165
- wheel geometry .......................... 165
Wheel rims
- understanding rim marking .......
166
Windscreen washing ........................ 53
Window winders .............................. 65
Windscreen washer
- control ........................................... 53
- fluid level ....................................... 147
Windscreen wiper
- blades .............................................
153
- control ........................................... 53
- spray nozzles ................................
154
LINEA Owner HAND BOOK RHD.pdf 178LINEA Owner HAND BOOK RHD.pdf 1788/21/09 2:16:38 PM8/21/09 2:16:38 PM