2010 FIAT LINEA RHD transmission

74
TRANSCEIVERS
AND MOBILE PHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which,
am-
plified by the resonance effects inside the
passenger compartment,
may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns EC-approved mobile phones
(GSM, GPRS, UMTS),
strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.
ACCESSORIES
PURCHASED BY THE
OWNER
If after buying the car, you decide to install
electrical accessories that require a per-
manent electric supply (alarm, satellite an-
titheft system, etc.) or accessories that in
any case burden the electric supply,
con-
tact Fiat Dealership,
whose qualified
perso nnel, beside s sugge sting the most suitable devices belonging to Linea access-
ories Fiat, will also evaluate the overall elect-
ric absorption,
checking whether the car’s
electric system is able to withstand the
load required, or whether it needs to be
integrated with a more powerful battery.
Be very careful when fitting
non-standard additional
spoilers , light alloy wheels or wheel
cups: they could reduce brake
venti-
lation and consequently brake effi-
ciency in the case of repeated, violent
braking or on long downhill roads.
Make sure that nothing obstructs the
pedal stroke (mats, etc.)
WARNING
ELECTRICAL/ELECTRONIC
DEVICE INSTALLATION
Electrical and electronic devices installed
after buying the car by after-market ser-
vice must carry the following label:
auth-
orises the installation of transceiving dev-
ices provided that they are installed accord-
ing to rules of good engineering practice
respecting the manufacturer’s indications
by a specialised centre.
IMPORTANT Traffic police may not allow
the car on the road in the event of
as-
sembly of devices which imply modifica-
tions to the features of the car. This may
also cause lapse of warranty in relation to
faults caused by the change or either di-
rectly or indirectly related to it.
shall
not be liable for damage caused by the
installation of accessories either not sup-
plied or recommended by
and/or installed
in compliance with the provided instruc-
tions.
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
Fiat Group Automobiles South Africa (Pty) Ltd
Fiat Group Automobiles South Africa (Pty) Ltd
Automobiles South Africa (Pty) Ltd
Fiat Group
LINEA Owner HAND BOOK RHD.pdf 74LINEA Owner HAND BOOK RHD.pdf 748/21/09 2:16:10 PM8/21/09 2:16:10 PM

Thousands of kilometres
Replace spark plugs
Check and Top up fluid levels (engine coolant, brake
fluid, screen washer, battery, and power steering oil,
etc, if requried) ( )
Check condition of toothed driving belt
Check operation of engine management systems
(using diagnostic socket) Replace toothed timing drive belt (*)
Change brake / clutch fluid (every 60000 kms or
24 months, whichever is earlier) Change engine oil and replace oil filter
(every 20,000 kms or 12 months, whichever is earlier)
Change pollen filter
(*) Regardless of the km covered, the timing belt shall be replaced every 3 years for particularly demanding use
(cold climates, driving in the city, idling for a long time) or in any case every 5 years
(**) Paint and or body damages must promply be rectified to prevent possible deterioration of paint and ( ) Regardless of the km covered, Air filter should be replaced earlier if operating in dusty condition
140
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
20 40 60 80 100 120 140 160 180
Check transmission oil level
( ) Change power steering oil every 24 months
formation of rust
LINEA Owner HAND BOOK RHD.pdf 140LINEA Owner HAND BOOK RHD.pdf 1408/21/09 2:16:22 PM8/21/09 2:16:22 PM

Thousands of kilometres
Replace air filter cartridge ( )
Check and Top up fluid levels (engine coolant, bra-
ke fluid screen washer, battery, and power steering
oil, etc, if requried) ( )
Check operation of engine management systems
(using diagnostic socket)
Change engine oil and replace oil filter (every
15000 kms or 12 months, whichever is earlier)
Change brake/clutch fluid (every 60000 kms or 24
months, whichever is earlier)
Change pollen filter (every 15000 kms)
Change of engine coolant (every 60000 kms or 24
months, whichever is earlier)
Change of transmission oil (every 60000 kms or
( ) Regardless of the km covered, Air filter should be replaced earlier if operating in dusty condition 24 months, whichever is earlier)
Wheel alignment
Tires rotation (Pattern : Front to Rear)
15 30 45 60 75 90 105 120 135 150 165 180Inspection
at 3000 kms
142
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL(*) Regardless of the km covered, the timing belt shall be replaced every 4 years for particularly demanding use
(cold climates, driving in the city, idling for a long time) or in any case every 5 years
( ) Change power steering oil every 24 months
LINEA Owner HAND BOOK RHD.pdf 142LINEA Owner HAND BOOK RHD.pdf 1428/21/09 2:16:22 PM8/21/09 2:16:22 PM

DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
trailer or caravan towing;
dusty roads;
short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
frequently idling engines or long dis-
tance low speed driving (e.g . taxis or
door-to-door deliveries) or in case of
a long term inactivity;
in cities;
perform the following inspections and
shown on the Service Schedule:

check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
visually inspect the accessory drive belt
conditions;
check pollen filter
check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
 engine coolant fluid level; Engine Oil level, every 3,000 km and
brake - clutch fluid level and type;
power steering fluid level;


tyre pressure and conditions;
operation of lights (headlights, direction
indicators, hazard lights, etc.);
143
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
. If the vehicle is
replacements more frequently than
check front disk brake pad conditions
and wear; frequently than required; replace engine oil and oil filter more
frequently
than required on the service replace spark plugs more
schedules, in particular contact a Fiat
Dealership if a reduction in the
vehicle engine performance is noted;used frequently in dusty or heavily
polluted environments it is
advisable to replace the filtering
elementts more frequently, in
particular it should be replaced if a
reduction of the amount of air
admitted to the passenger
compartment is noted; top up if required;
LINEA Owner HAND BOOK RHD.pdf 143LINEA Owner HAND BOOK RHD.pdf 1438/21/09 2:16:22 PM8/21/09 2:16:22 PM

IDENTIFICATION DATA ................................................. 160
ENGINE CODES - VERSIONS .......................................... 161
ENGINE .................................................................................. 162
FUEL FEED/IGNITION ....................................................... 163
TRANSMISSION .................................................................. 163
BRAKES ................................................................................... 164
SUSPENSIONS ....................................................................... 164
STEERING ............................................................................... 164
WHEELS .................................................................................. 165
DIMENSIONS......................................................................... 169
PERFORMANCE ................................................................... 170
WEIGHTS ............................................................................... 171
CAPACITIES ........................................................................... 172
FLUIDS AND LUBRICANTS .............................................. 173
TT T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
159
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 159LINEA Owner HAND BOOK RHD.pdf 1598/21/09 2:16:36 PM8/21/09 2:16:36 PM

Modifications or repairs to the fuel feed system that are not carried out properly or do not take the system’s
technical specifications into account can cause malfunctions leading to the risk of fire.
WARNING
TRANSMISSION
1.4 16v -1.3 Multijet
Gearbox Five forward gears plus reverse with synchronisers for forward gears
Clutch Self-adjusting with pedal without idle stroke
Drive Front
Fuel feedMultipoint electronic injection Multijet direct injection
“Common Rail”
FUEL FEED/IGNITION
1.4 16v1.3 Multijet
163
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 163LINEA Owner HAND BOOK RHD.pdf 1638/21/09 2:16:37 PM8/21/09 2:16:37 PM

Lubricants and
greases for trans-
missionSAE 80W EP oil exceeding API Gl4 and MIL-L-2105
specifications.
‘ATF DEXRON II D LEV’ oil
Molybdenum disulphide, lithium-soap based grease,
water resistant N.L.G.I. consistency =2
o Synthetic fluid, NHTSA n 116, DOT 4, ISO 4925,
SAE J 1703
Protective inhibited monoethylene glycol based
antifreeze compound, CUNA NC 956-16
Alcohol, water and surfactants mixture CUNA
NC 956-II
ZC 75/FF
GI/E F7
MRM 2
TUTELA TOP 4
PARAFLU UP
SC 35Manual transmissions
and differentials
Hydraulic power
steering
CV joints
Hydraulic Brake and
hydraulic clutch
commands
Use percentage:
Mixture of 40% PARAFLU-
UP & 60% demineralized
water
Use percentage:
10% of fluid SC 35
and 90% distilled
water Hydraulic
brake/clutch fluids
Radiator antifreeze
Windscreen
window washer
fluid Use Fluid and lubricant specificationsGenuine fluids and Applications
for correct car operation lubricants
174
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
SAFETY
LINEA Owner HAND BOOK RHD.pdf 174LINEA Owner HAND BOOK RHD.pdf 1748/21/09 2:16:37 PM8/21/09 2:16:37 PM

178
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Speedometer ..................................... 14
Starting and driving ..........................
93
Starting the engine
- bump starting ...............................
113
- diesel engines ............................... 94
- emergency start-up .................... 112
- ignition switch .............................. 12
- jump starting ................................ 112
- petrol engines ..............................
93
- stopping the engine .................... 95
- warm up the engine after
just started ...................................
95
Steering .............................................. 164
Steering column lock .......................
12
Steering wheel ...................................
35
Sun visors ........................................... 63
Suspensions ....................................... 164
Symbols ............................................... 6
Tailgate .............................................. 67
Technical specifications ................... 159
Third brake light ...............................
125
Top speeds .........................................
99
Towing the car .................................. 135
Transmission ......................................
162Ty r e s
- replacing a wheel ........................ 113
- maintenance .................................
152
- reading tyre markings ................ 165
- standard tyres ..............................
167
- cold tyre inflation pressure ....... 168
Using the manual gearbox ............ 97
Warning lights and messages ...... 101
Weights .............................................. 171
Wheel .................................................
165
- replacing a wheel ........................ 113
- spare wheel .................................. 165
- wheel geometry .......................... 165
Wheel rims
- understanding rim marking .......
166
Windscreen washing ........................ 53
Window winders .............................. 65
Windscreen washer
- control ........................................... 53
- fluid level ....................................... 147
Windscreen wiper
- blades .............................................
153
- control ........................................... 53
- spray nozzles ................................
154
LINEA Owner HAND BOOK RHD.pdf 178LINEA Owner HAND BOOK RHD.pdf 1788/21/09 2:16:38 PM8/21/09 2:16:38 PM