2009 TOYOTA CAMRY HYBRID Warranty And Maintenance Guide

Emission Defect Warranty
Toyota warrants that your vehicle:
Was designed, built and equipped to conform at the time of sale with
applica ble federal emissions standards.
Is free from defects in materials and workmanship that may cause
the vehicle to fail to meet these standards.
Federal regulations require that this warranty be in effect for two years
or 24,000 miles from the vehicle’s in-service date, whichever occurs
first. However, under the terms of the Basic Warranty, Toyota provides
coverage of three years or 36,000 miles, whichever occurs first. Speci-
fic com ponents may have longer coverage under the terms of the
Powertrain Warranty. Additionally, components marked “8/80” in the
parts list on pages 16–17 have coverage of eight years or 80,000 miles,
whichever occurs first.
Emission Performance Warranty
Some states and localities have established vehicle inspection and
maintenance (I/M) programs to encourage proper vehicle maintenance.
If an EPA-approved I/M program is in force in your area, you are eligi-
ble for Emission Performance Warranty coverage.
Under the terms of the Emission Performance Warranty and federal
regulations, Toyota will make all necessary repairs if both of the
following occur:
Your vehicle fails to meet applicable emissions standards as
determined by an EPA-approved emissions test.
This failure results or will result in some penalty to you — such
as a fine or denial of the right to use your vehicle — under local,
state or federal law.
This warranty is in effect for two years or 24,000 miles from the vehi-
cle’s in-service date, whichever occurs first. Additionally, components
marked “8/80” in the parts list on pages 16–17 have coverage of eight
years or 80,000 miles, whichever occurs first.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail15
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 15

WHAT IS NOT COVERED WARRANTY PARTS LIST
These warranty obligations do not apply to failures or noncompliance
caused by:
The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty.
Air/Fuel Metering System

Air/fuel ratio feedback control system
Electronic fuel injection system components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
Air Induction System

Intake manifold and intake air surge tank
Catalyst System

Catalytic converter and protector (8/80)
Constricted fuel filler neck
Exhaust manifold
Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
Your Warranties in Detail16
FEDERAL EMISSION CONTROL WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 16

Evaporative Control System

Charcoal canister
Diaphragm valve
Fuel filler cap
Fuel tank
Hybrid System

Battery control module (8/80)*
Battery thermistor
Generator
Hybrid battery*
Hybrid control module (8/80)*
Inverter with converter*
Motor
System main relay and battery current sensor
Ignition System

Distributor and internal parts
Ignition coil and ignitor
Ignition wires
Spark plugs†
Positive Crankcase Ventilation (PCV) System

Oil filler cap
PCV valve or orifice
Other Parts Used in Above Systems

Data link connector (8/80)
Hoses, clamps, fittings, tubing and mounting hardware
Malfunction indicator light and bulb (8/80)
Pulleys, belts and idlers
Sealing gaskets and devices
Sensors, solenoids, switches and valves
FEDERAL EMISSION CONTROL WARRANTY
*
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
Covered under the Hybrid System Warranty for eight years or 100,000
miles, whichever occurs first.†Warranted until first required maintenance under terms of the California
Emission Control Warranty.
Your Warranties in Detail17
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 17

MAINTENANCE REPLACEMENT PARTS
You are responsible for performance of the required maintenance indi-
cated in the
Owner’s Manualand the Scheduled Maintenance Guide.
Toyota will not deny a warranty claim solely because you do not have
records to show that you maintained your vehicle. However, any failure
or noncompliance caused by lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid for by you, these services
may be performed by you or by any automotive service provider you
choose. Toyota will not deny a warranty claim solely because you
used a service provider other than a Toyota dealership for mainte-
nance and repairs.However, any failure or noncompliance caused
by improper maintenance or repairs is not covered by this warranty.To ensure optimum performance and maintain the quality built into
your vehicle’s emission control systems, Toyota recommends the use
of Genuine Toyota Parts when servicing or repairing the systems.
Warranty coverage is not dependent upon the use of any particular
brand of replacement parts and you may elect to use non-Genuine
Toyota Parts for maintenance and repairs. However, use of replace-
ment parts that are not equiva lent in quality to Genuine Toyota Parts
may impair the effectiveness of the emission control systems.
If you use replacement parts that have maintenance or replacement
schedules different from those of Genuine Toyota Parts, you must fol-
low the maintenance and replacement schedules for the parts you are
using. In addition, you should ensure that such parts are warranted
by their manufacturers to be equivalent to Genuine Toyota Parts.
Your Warranties in Detail18
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 18

If your vehicle fails an EPA-approved emissions test, you may make a
claim under the Emission Performance Warranty. To do so, take your
vehicle to an authorized Toyota dealership and present a copy of the
emissions test report. Also, take your maintenance records in case
they are needed.
If your claim qualifies for coverage, the dealership will repair your vehi-
cle within 30 days (unless a shorter period is required by law). If your
claim is denied, Toyota will notify you in writing of the reason within
the same period. If we fail to do so, we will repair your vehicle free of
charge. The only exceptions allowed are when you request or agree to
a delay, or when a delay is caused by factors beyond the control of
Toyota or the dealership.
For information on how to obtain service under the Emission Defect
Warranty, see page 31, “Obtaining Warranty Service.”If you have questions or concerns about your vehicle’s federal emission
warranty coverage, please follow the steps described under “If You
Need Assistance” on pages 4–5. In the case of the Emission
Performance Warranty, you may also request information from or
report complaints to:
U.S. Environmental Protection Agency
Vehicle Programs & Compliance Division (6405J)
Attn: Warranty Complaints
401 M Street SW
Washington, D.C. 20460
Vehicles equipped with a California Certified Emission Control
System that are registered and operated in California or any state
that adopts California emission warranty provisions are also cov-
ered by the California Emission Control Warranty (see page 21).
Currently, Connecticut, Maine, Massachusetts, New Hampshire,
New Jersey, New York, Oregon, Pennsylvania, Rhode Island,
Vermont and Washington are the other states to which the
California Emission Control Warranty applies.
IF YOUR VEHICLE FAILS AN EMISSIONS TEST IF YOU HAVE QUESTIONS
Your Warranties in Detail19
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 19

DEALER CERTIFICATE
We (the dealership) want you to know that at the time your new Toyota
vehicle is being delivered:
1) On the basis of written notification furnished by Toyota, we have
knowledge that the vehicle is covered by an EPA Certificate of
Conformity.
2) We have visually inspected those emission control devices or por-
tions thereof that are visible without removing or adjusting any
components or systems, emissions-related or otherwise. On the
basis of this inspec tion, there are no apparent deficiencies in the
installation of emission control devices by Toyota. (For purposes
of this certificate, “emission control devices” is limited to devices
installed on a vehicle for the sole or primary purpose of controlling
emissions and which were not in general use before 1968.)
3) We have performed all emission control system preparations
required by Toyota prior to the sale of the vehicle as set forth in
Toyota’s current pre-delivery service manual.
4) Except as may be provided in Paragraph 5, if this vehicle fails an
EPA-approved emissions test within three months or 4,000 miles
(whichever comes first) of delivery to the ultimate purchaser, and
the vehicle has been main tained and used in accordance with thewritten instructions for proper mainte nance and use, Toyota will
remedy the nonconformity free of charge under the terms of the
Emission Performance Warranty.
5) If vehicle was used as a company car or demonstrator, check box
and complete the following:
The vehicle with which this statement is delivered was placed
into service as a company car or demonstrator prior to delivery.
The Emission Performance Warranty period commenced on the
date the vehicle was first placed into service, which was:
Month Day Year
Note: The dealership makes no representation or warranty that the
emission control system or any part thereof is without defect or that
the system will perform properly. The Emission Performance Warranty
referred to in Paragraph 4 and furnished with the vehicle is solely that
of the manufacturer.
This statement is required by section 207 of the Clean Air Act (42 U.S.C.
7541) and the EPA regulations issued thereunder.
Dealership Name
Your Warranties in Detail20
FEDERAL EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 20

Vehicles equipped with a California Certified Emission Control
System that are registered and operated in California or any state
that adopts California emission warranty provisions are covered by
this warranty. Currently, Connecticut, Maine, Massachusetts, New
Hampshire, New Jersey, New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington are the other states to which this
warranty applies. Vehicles covered by this warranty are also cov-
ered by the Federal Emission Control Warranty (see page 15).The California Air Resources Board (CARB) and Toyota are pleased to
explain the emission control system warranty for your 2009 vehicle.
In California, new motor vehicles must be designed, built and equipped
to meet the state’s stringent anti-smog standards. CARB regulations
require that Toyota must warrant the emission control system on your
vehicle for the time periods indicated on the next page, provided there
has been no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injec-
tion system, ignition system, catalytic converter and engine computer.
Also included may be hoses, belts, connectors and other emissions-
related assemblies.
Where a warrantable condition exists, Toyota will repair your vehicle at
no cost to you, including diagnosis, parts and labor.
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
Your Warranties in Detail21
CALIFORNIA EMISSION CONTROL WARRANTY
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 21

MANUFACTURER’S WARRANTY COVERAGE
Selected States1
For 15 years or 150,000 miles, whichever occurs first:2
If your vehicle fails a smog-check test, all necessary repairs and
adjust ments will be made by Toyota to ensure that your vehicle
passes the test. This is your Emission Control System PERFOR-
MANCE WARRANTY.
Subject to the specific terms pertaining to maintenance described
on the following pages, if any emissions-related part is defective,
the part will be repaired or replaced by Toyota. This is your Emission
Control System DEFECT WARRANTY.
Pennsylvania and Washington Vehicles Only3
1) For three years or 50,000 miles, whichever occurs first:
If your vehicle fails a smog-check test, all necessary repairs and
adjust ments will be made by Toyota to ensure that your vehicle
passes the test. This is your Emission Control System PERFOR-
MANCE WARRANTY.
If an emissions-related part listed on pages 16–17 is defective,
the part will be repaired or replaced by Toyota. This is your
SHORT-TERM Emission Control System DEFECT WARRANTY.
Specific com ponents may have longer coverage under the terms
of the Powertrain Warranty.
2) For seven years or 70,000 miles, whichever occurs first:
If an emissions-related part listed on page 23 is defective,
the part will be repaired or replaced by Toyota. This is your
LONG-TERM Emission Control System DEFECT WARRANTY.
Your Warranties in Detail22
CALIFORNIA EMISSION CONTROL WARRANTY
1Applies to California, Connecticut, Maine, Massachusetts, New Hampshire, New Jersey,
New York, Oregon, Rhode Island and Vermont vehicles equipped with a California
Certified Emission Control System.
2Warranty coverage for the hybrid battery is 10 years or 150,000 miles, whichever
occurs first.3Applies to Pennsylvania and Washington vehicles equipped with a California Certified
Emission Control Warranty.
17365.Guts.qxd:62791_Toyota_text 7/22/10 11:39 PM Page 22