2009 Peugeot 607 Dag brake
[x] Cancel search: brakePage 114 of 182
9
98
CHECKING THE LEVELS
There are two marks on
the dipstick:
A = maximum
N e v e r fi l l p a s t t h i s m a r k .
B = minimum
To maintain the reliability
of engines and emission
control systems, the use
of additives in engine oil is
prohibited.
Dipstick
Oil change
According to the information given in
the servicing booklet.
The level must always be between the
DANGER and MAXIMUM marks in the
reservoir.
If the level drops substantially, contact
a PEUGEOT dealer immediately.
Windscreen and headlamp wash level
For best quality cleaning and for your
safety, we advise that you use prod-
ucts recommended by PEUGEOT
(reservoir capacity 4 litres or 6.5 litres
with headlamp wash).
Viscosity selection
In all cases, the oil selected must meet
the manufacturer's requirements. Fluid change:
- must be carried out according
to the manufacturer's servicing
schedule.
- u s e fl u i d s r e c o m m e n d e d b y t h e m a n u f a c t u r e r , w h i c h f u l fi l D O T 4
standards.
Used oil
Prevent used oil from coming
into prolonged contact with
the skin.
B r a k e a n d c l u t c h fl u i d i s h a r m f u l t o
health and very corrosive.
Do not dispose of used oil, brake and
c l u t c h fl u i d o r c o o l a n t i n t o d r a i n s o r
onto the ground.
Power steering reservoir
Open the reservoir, with the engine
cold at ambient temperature. The
level should always be above the
MINI mark and close to the MAXI
mark.
Oil level
Check the level regularly and top
up between changes.
Carry out this check with the vehicle
level, engine cold, using the oil level
gauge on the instrument panel or the
dipstick. C h a r a c t e r i s t i c s o f t h e fl u i d
For best quality cleaning and to pre-
v e n t f r e e z i n g , t h i s fl u i d m u s t n o t b e
topped up or replaced with water.
Page 115 of 182
9
99
CHECKS Handbrake
Where the handbrake travel
is too great or there is a re-
duction in the performance of the
system, the handbrake should be ad-
justed. Have the system checked by a
PEUGEOT dealer.
Only use products recom-
mended by PEUGEOT or
products of equivalent quality
a n d s p e c i fi c a t i o n .
To ensure best performance from
components as important as the pow-
er steering and the braking system,
P E U G E O T s e l e c t s a n d o f f e r s s p e c i fi c
products.
To prevent damage to the electrical
units, high pressure washing of the en-
gine compartment is strictly prohibited .
In order to check the main levels
and certain components, in accord-
ance with the manufacturer's servi-
cing schedule, refer to the pages of
the servicing booklet which corres-
pond to your vehicle's engine. Battery
At the start of winter, have
your battery checked by a
PEUGEOT dealer.
Air filter and passenger compartment filter
H a v e t h e fi l t e r e l e m e n t s r e -
placed regularly. If you drive
in dusty conditions, change them
twice as often .
Particulate emission filter - Additive reservoir (Diesel)
Maintenance of the particulate emis-
s i o n fi l t e r a n d fi l l i n g o f t h e a d d i t i v e
reservoir must be carried out by a
PEUGEOT dealer, according to the
manufacturer's servicing schedule.
Brake pads
Brake pad wear depends on
the style of driving, in particu-
lar for vehicles which are used in town,
over short distances.
Manual gearbox
This does not need an oil change.
Have the level checked, according to
the manufacturer's servicing schedule.
Automatic gearbox
This does not need an oil change. Have
the level checked by a PEUGEOT
dealer, according to the manufacturer's
servicing schedule.
Oil filter
C h a n g e t h e fi l t e r r e g u l a r l y , i n a c c o r d -
ance with the servicing schedule.
It may be necessary to check
the thickness of the pads,
even between services.
Disc wear condition
For any information relating to check-
ing of the disc wear condition, contact
a PEUGEOT dealer.
Page 116 of 182
1010
100
Access to the spare wheel and the
jack in the boot
Detach the luggage net.
Lift the boot carpet using the lifting
hook. Secure this hook behind the
boot seal.
CHANGING A WHEEL
Tools available
The following tools are located in the
polystyrene holder in the centre of the
spare wheel:
1. Wheelbrace.
2. Centralising tool.
3. Wheelbrace extension.
4. Jack.
5. Removable towing eye.
6. Alloy wheel trim remover.
7. Trim cover tool. Removal
F o r v e h i c l e s w i t h a l l o y w h e e l s fi t t e d
with wheel trims, pull the centre trim
by using tool 6 in one of the holes.
Loosen the wheel bolts.
Take the jack 4 from the tool kit .
Place the jack in one of the four
locations A underneath the vehicle
(the nearest one to the wheel to be
changed).
Extend the jack using wheelbrace 1
and the extension 3 .
Remove a wheel bolt at the top
a n d fi t t h e c e n t r a l i s i n g t o o l 2 in its
place.
Unscrew the other bolts and remove
the wheel.
Park the vehicle so that it does
n o t o b s t r u c t t r a f fi c : t h e g r o u n d
must be level, stable and non-
slippery.
Apply the handbrake, switch off the igni-
t i o n a n d e n g a g e fi r s t o r r e v e r s e g e a r ( p o -
sition P for the automatic gearbox).
It is imperative to ensure that the occu-
pants get out of the vehicle and wait in
a safe location.
Never go underneath a vehicle which is
supported only by a jack; use a ramp.
T h e j a c k a n d a l l o f t h e t o o l s a r e s p e c i fi c
to your vehicle. Do not use them for other
purposes.
Page 120 of 182
1010
104
Integrated direction indicator
repeaters Amber coloured bulbs, such
as the direction indicators and
side repeaters, must be re-
placed with bulbs of identical
s p e c i fi c a t i o n a n d c o l o u r . Rear lights
R e m o v e t h e t w o b u t t e r fl y n u t s s e -
curing the light.
Remove the eyelet.
Take out the lamp.
Unclip the bulb holder.
Change the faulty bulb.
Clip the bulb holder.
W h e n r e fi t t i n g i t , e n s u r e t h a t t h e l a m p
is correctly positioned and secured.
1. D i r e c t i o n i n d i c a t o r s : H p 1 6 .
2. Brake lights/side lights: Hp16.
Detach the luggage net.
Lift the boot carpet with the lifting
hook. Secure this hook behind the
boot seal.
Unclip the lower part of the sill trim,
then dislodge it by pulling upwards.
Remove the plastic retainer clip
s e c u r i n g t h e s i d e t r i m t o t h e fl o o r .
Unclip the side trim.
Push the repeater forwards and re-
lease it.
Remove the repeater and change it.
This can be obtained from a PEUGEOT
dealer. Rear wing lights
Page 121 of 182
1010
104
Integrated direction indicator
repeaters Amber coloured bulbs, such
as the direction indicators and
side repeaters, must be re-
placed with bulbs of identical
s p e c i fi c a t i o n a n d c o l o u r . Rear lights
R e m o v e t h e t w o b u t t e r fl y n u t s s e -
curing the light.
Remove the eyelet.
Take out the lamp.
Unclip the bulb holder.
Change the faulty bulb.
Clip the bulb holder.
W h e n r e fi t t i n g i t , e n s u r e t h a t t h e l a m p
is correctly positioned and secured.
1. D i r e c t i o n i n d i c a t o r s : H p 1 6 .
2. Brake lights/side lights: Hp16.
Detach the luggage net.
Lift the boot carpet with the lifting
hook. Secure this hook behind the
boot seal.
Unclip the lower part of the sill trim,
then dislodge it by pulling upwards.
Remove the plastic retainer clip
s e c u r i n g t h e s i d e t r i m t o t h e fl o o r .
Unclip the side trim.
Push the repeater forwards and re-
lease it.
Remove the repeater and change it.
This can be obtained from a PEUGEOT
dealer. Rear wing lights
Page 123 of 182
1010
106
C H A N G I N G A F U S E
The fuse boxes are placed in the lower
part of the fascia (driver's side), in the
engine compartment (left-hand side)
and in the left boot trim.
R e p l a c i n g a f u s e
Before replacing a fuse, the cause of
the incident must be found and recti-
fi e d . T h e f u s e n u m b e r s a r e i n d i c a t e d
on the fuse box.
Correct Incorrect
F u s e N ° Rating F u n c t i o n s
F31 5 A Right-hand brake light.
F32 5 A Left-hand brake light.
F33 5 A Third brake light.
F34 - Not used.
F35 5 A
T y r e u n d e r - i n fl a t i o n d e t e c t i o n c o n t r o l u n i t , C D c h a n g e r .
F36 30 A Passenger seat relay.
F37 30 A Passenger and rear right heated seats.
F38 30 A Driver's and rear left heated seats.
F39 30 A Driver's seat relay.
F40 5 A Diagnostics socket.
Always replace a faulty fuse
with a fuse of the same rating
(same colour).
Use the special pliers located
on the support next to the fuse box,
this support also contains the replace-
ment fuses.
F a s c i a f u s e s
To access the fuses, open the cover
of the storage compartment on the
driver's side. Tilt the fuse box down-
wards.
Page 124 of 182
1010
106
C H A N G I N G A F U S E
The fuse boxes are placed in the lower
part of the fascia (driver's side), in the
engine compartment (left-hand side)
and in the left boot trim.
R e p l a c i n g a f u s e
Before replacing a fuse, the cause of
the incident must be found and recti-
fi e d . T h e f u s e n u m b e r s a r e i n d i c a t e d
on the fuse box.
Correct Incorrect
F u s e N ° Rating F u n c t i o n s
F31 5 A Right-hand brake light.
F32 5 A Left-hand brake light.
F33 5 A Third brake light.
F34 - Not used.
F35 5 A
T y r e u n d e r - i n fl a t i o n d e t e c t i o n c o n t r o l u n i t , C D c h a n g e r .
F36 30 A Passenger seat relay.
F37 30 A Passenger and rear right heated seats.
F38 30 A Driver's and rear left heated seats.
F39 30 A Driver's seat relay.
F40 5 A Diagnostics socket.
Always replace a faulty fuse
with a fuse of the same rating
(same colour).
Use the special pliers located
on the support next to the fuse box,
this support also contains the replace-
ment fuses.
F a s c i a f u s e s
To access the fuses, open the cover
of the storage compartment on the
driver's side. Tilt the fuse box down-
wards.
Page 125 of 182
1010
107
F u s e N ° Rating
F u n c t i o n s
F1 15 A F r o n t w a s h - w i p e p u m p a n d w a s h - w i p e fl u i d l e v e l s e n s o r .
F2 30 A Locking and deadlocking earth.
F3 5 A Air bags.
F4 10 A Clutch switch, brake dual-function switch, diagnostic connector
, ESP sensor,
electrochromatic mirror.
F5 30 A Front electric windows and sunroof supply.
F6 30 A Rear electric windows supply.
F7 5 A Glove box switch, courtesy lights, map reading lights, courtesy mirrors.
F8 20 A Multifunction display supply, steering wheel control, alarm si
ren, trailer fusebox supply,
PC Com, electric mirror and front and rear electric window controls.
F9 30 A Front and rear lighters (100 W max.).
F10 15 A Additive reservoir control unit supply.
F11 15 A Automatic gearbox control unit, automatic gearbo x positions selection switch, ignition switch.
F12 15 A Trailer fusebox supply, hands-free kit, seats relay, seat memory un
it, rain and brightness
sensor.
F13 5 A Engine fusebox supply.
F14 15 A Parking assistance control unit supply, instrument panel, air co
nditioning, air bags and
pre-tensioners unit.
F15 30 A Locking and deadlocking supply.
F17 40 A H i - F i a m p l i fi e r , h e a t e d m i r r o r s .