
233
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕
Replace timing belt and tension pulley
Z 16 LEL, Z 16 LER, Z 17 DTR every 10 years/150000 km
Change engine oil and replace filter xxxxx
⊕o
Drain water from fuel filter, diesel (if the air humidity is high or the fuel of lower quality)xxxxx
Replace fuel filter and drain water, diesel (grade EN590)
Z 13 DTJ, Z 17 DTH xx
Replace fuel filter, petrol (g rade EN228), outer Z 16 LEL, Z 16 LER every 4 years/60000 km
Check handbrake, adjust if necessary (unl aden wheels); carry out a visual check of
wheel suspension and suspension front and re ar, brake lines, brake pressure hose, fuel
lines and exhaust system xx
Check external bodywork / underseal, note any damage in the Service and Warranty
Booklet. xxxxx
⊕o
Carry out a visual check on the front and rear wheel brakes
2)
2)If the loss is too great or there are leaks, carry
out remedial work in agreement with the customer.
xx
Annual service check if the annual distance travelled is greater than 20000 km.
Carry out a visual check of the engine, tran smission (AT, MT), check air conditioning
compressor for leaks
2)
xxxxx
Back to overview

234 Opel Service, maintenance⊕Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mounting and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
⊕
Germany only: carry out emissions check, main inspection
First time after three years, then every 2 years
If used commercially to transport passengers, taxis, ambulances, hire cars etc. annually
Back to overview

236 Opel Service, maintenance⊕Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕
Replace timing belt and tension pulley
Z 16 LEL, Z 16 LER, Z 17 DTR every 10 years/150000 km
Change engine oil and replace filter xxxxx
⊕o
Drain water from fuel filter, diesel (if the air humidity is high or the fuel of lower quality)xxxxx
Replace fuel filter and drain water, diesel (grade EN590)
Z 13 DTJ, Z 17 DTH xx
Replace fuel filter, petrol (g rade EN228), outer Z 16 LEL, Z 16 LER every 4 years/60000 km
Check handbrake, adjust if necessary (unl aden wheels); carry out a visual check of
wheel suspension and suspension front and re ar, brake lines, brake pressure hose, fuel
lines and exhaust system xx
Check external bodywork / underseal, note any damage in the Service and Warranty
Booklet. xxxxx
⊕o
Carry out a visual check on the front and rear wheel brakes
2)
2)If the loss is too great or there are leaks, carry
out remedial work in agreement with the customer.
xx
Annual service check if the annual distance travelled is greater than 20000 km.
Carry out a visual check of the engine, tran smission (AT, MT), check air conditioning
compressor for leaks
2)
xxxxx
Back to overview

237
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
Back to overview
![OPEL CORSA 2009 Owners Manual 263
Technical Data
Table 2, added weight for different specifications 5-door passenger vehicle
Engine Z 10 XEP Z 12 XEP Z 14 XEP Z 16 LEL Z 13 DTJ Z 13 DTH Z 17 DTR
Enjoy [kg] 7 7 7 7 7 7 7
Sport [kg OPEL CORSA 2009 Owners Manual 263
Technical Data
Table 2, added weight for different specifications 5-door passenger vehicle
Engine Z 10 XEP Z 12 XEP Z 14 XEP Z 16 LEL Z 13 DTJ Z 13 DTH Z 17 DTR
Enjoy [kg] 7 7 7 7 7 7 7
Sport [kg](/manual-img/37/58224/w960_58224-268.png)
263
Technical Data
Table 2, added weight for different specifications 5-door passenger vehicle
Engine Z 10 XEP Z 12 XEP Z 14 XEP Z 16 LEL Z 13 DTJ Z 13 DTH Z 17 DTR
Enjoy [kg] 7 7 7 7 7 7 7
Sport [kg] 12 12 12 12 12 12 12
Cosmo [kg] 14 14 14 14 14 14 14
3-door passenger vehicle
Engine Z 10 XEP Z 12 XEP Z 14 XEP Z 16 LEL Z 13 DTJ Z 13 DTH Z 17 DTR
Enjoy [kg] 15 15 15 15 15 15 15
Sport [kg] 21 21 21 21 21 21 21
Cosmo [kg] 14 14 14 14 14 14 14Weights, table 3, heavy accessoriesAccessories Sun roof Towing equipment Flex-Fix system17-inch wheels
on van
Weight [kg] 20 15 23.520
Back to overview

264 Technical DataTyres Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3168. Wheels Wheel bolt tightening torque: 110 Nm. Winter tyres
3
Tyres of size 195/60 R 15, 215/45 R 17
and 225/35 R 18 must not be used as
winter tyres.
Tyres of size 185/60 R 15 are only approved
as winter tyres.
Tyres of size 185/65 R 15 are only
a p p r o v e d a s w i n te r t y r e s o n ve h i c l e s w i t h a
sports chassis. We recommend that you
contact your Opel partner in order to find
out whether your vehicle is equipped with a
sports chassis. If you use winter tyres, the spare wheel
3
m a y s t i l l b e f i t t e d w i t h a s u m m e r t y r e . I f y o u
use the spare wheel the vehicle’s handling
may be altered. Obtain a replacement for
the faulty tyre as soon as possible, and
have the wheel balanced and fitted to the
vehicle.
Further information 3 172.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on tyre sizes
195/60 R 15, 215/45 R 17 and 225/35 R 18.
Tyre chains are only approved on tyres of
size 185/60 R 15 on vehicles with a sports
chassis. We recommend that you contact
your Opel partner in order to find out
whether your vehicle is equipped with a
sports chassis.
Further information 3172. Spare wheel
3
Depending on the version, the spare wheel
will be in the form of a temporary spare
wheel 3. The vehicle may handle
differently if a spare wheel has been fitted. Replace defective tyre as soon as possible,
balance wheel and fit to vehicle.
Please pay attention to the notes on this
page and on pages 173, 196.
On vehicles with alloy wheels
3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1) and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure) The specified tyre pressures are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressures specified on
the following pages apply to both summer
and winter tyres.
Always inflate the spare wheel 3 to the tyre
pressure for full load – see tables on the
following pages.
Temporary spare wheel tyre pressure 3 –
see tables on the following pages.
Further information 3168 to 3172.1)Country-specific version: The spare wheel is
only to be used as a temporary spare wheel.
Back to overview
![OPEL CORSA 2009 Owners Manual 265
Technical Data
Tyre pressure (overpressure) Passenger vehicle, van Suspension behaviour when
loaded with up to 3 people
[kPa/bar] ECO
1) when loaded with up
to 3 people [kPa/bar]
1)To achieve t OPEL CORSA 2009 Owners Manual 265
Technical Data
Tyre pressure (overpressure) Passenger vehicle, van Suspension behaviour when
loaded with up to 3 people
[kPa/bar] ECO
1) when loaded with up
to 3 people [kPa/bar]
1)To achieve t](/manual-img/37/58224/w960_58224-270.png)
265
Technical Data
Tyre pressure (overpressure) Passenger vehicle, van Suspension behaviour when
loaded with up to 3 people
[kPa/bar] ECO
1) when loaded with up
to 3 people [kPa/bar]
1)To achieve the smallest amount of fuel consumption possible. Not for use with run-flat tyres.
Tyre pressure when fully laden
[kPa/bar]
Engine Tyres Front Rear Front Rear Front Rear
Z 10 XEP 185/70 R14, 185/60 R 15
2),
185/65 R 15,
195/55 R16,
195/55 RF 163),
195/60 R 15
2)Only approved as winter tyres. 3)Only for vehicles with a specific rear axle application. We recommend your Opel Partner.
200/2.0 180/1.8 270/2.7 250/2.5 260/2.6 320/3.2
Z 12 XEP,
Z 14 XEP 185/70 R14,
185/60 R15
2),
185/65 R 15,
195/55 R16,
195/55 RF 16,
195/60 R 15,
215/45 R 17 200/2.0 180/1.8 270/2.7 250/2.5 260/2.6
320/3.2
Z16LEL,
Z16LER
OPC 195/55 R164),
205/50 R 16,
215/45 R 17
4)Only permitted for use as a winter tyre. Wheel chains not permitted.
240/2.4 240/2.4 270/2.7 250/2.5 260/2.6 320/3.2
225/35 ZR 18
5)
5)Not vehicles with Z 16 LEL engine.
260/2.6 240/2.4 – –280/2.8 320/3.2
Back to overview
![OPEL CORSA 2009 Owners Manual 268 Technical DataDimensions
5-door passenger vehicle 3-door passenger vehicle Corsa OPC, OPC Line
Overall length [mm] 39993999 4040
Width [mm] 17371713 1713
Width with two exterior mirrors [mm] 1944 OPEL CORSA 2009 Owners Manual 268 Technical DataDimensions
5-door passenger vehicle 3-door passenger vehicle Corsa OPC, OPC Line
Overall length [mm] 39993999 4040
Width [mm] 17371713 1713
Width with two exterior mirrors [mm] 1944](/manual-img/37/58224/w960_58224-273.png)
268 Technical DataDimensions
5-door passenger vehicle 3-door passenger vehicle Corsa OPC, OPC Line
Overall length [mm] 39993999 4040
Width [mm] 17371713 1713
Width with two exterior mirrors [mm] 19441944 1924
Overall height [mm] 14881488 1488
Length of luggage compartment floor
[mm] 703
703 703
Luggage compartment width [mm] 944944 944
Height of luggage compartment opening
[mm] 538
538 538
Wheelbase [mm] 25112511 2511
Turning circle diameter [m] 10.2010.20 10.20
Back to overview