2009 FIAT SEDICI 4WD

220
15A
15A
10A
10A
15A
15A
30A
30A
10A
15A
10A
10A
10A
20A
15A
10A
15A
10A
10A
15A
30A
15A
10A
79J093
79J011
Rear wiper
Ignition coil
Back-up light
Meter
Accessory
Accessory 2
Power window
Wiper
IG1 SIG
Air bag
Anti-lock brake system
Tail light
Stop light
Door lock
4WD light
ST SIG
Seat heater
IG 2 SIG
Rear fog light
Dome
Rear defogger
Horn / Hazard
Fiat CODE (Immobilizer) FUSES UNDER THE DASH BOARD
Main fuse / Primary fuse
(1)
(2)
(3)
(4)
(5)
(6)
(7)
(8)
(9)
(10)
(11)
(12)
(13)
(14)
(15)
(16)
(17)
(18)
(19)
(20)
(21)
(22)
(23)
183-230 SEDICI LUM FL GB 1E 19-06-2009 11:00 Pagina 220

235
2-WHEEL DRIVE (2WD)
MANUAL TRANSAXLE
Manual transaxle vehicles may be towed
using either of the following methods.
❒From the front, with the front wheels
lifted and the rear wheels on the
ground. Before towing, make sure that
the parking brake is released.
❒From the rear, with the rear wheels lift-
ed and the front wheels on the ground,
provided the steering and drivetrain are
in operational condition. Before tow-
ing, make sure that transaxle is in neu-
tral, the steering wheel is unlocked (the
ignition key should be in the “ACC” po-
sition), and the steering wheel is se-
cured with a clamping device designed
for towing service.
IMPORTANT The steering column is not
strong enough to withstand shocks trans-
mitted from the front wheels during tow-
ing. Always unlock the steering wheel be-
fore towing.
TOWING
If you need to have your vehicle towed,
contact a professional service. Your deal-
er can provide you with detailed towing
instructions.
IMPORTANT To help avoid damage to
your vehicle during towing, proper equip-
ment and towing procedures must be
used.
2- WHEEL DRIVE (2WD)
AUTOMATIC TRANSAXLE
Automatic transaxle vehicles may be
towed using either of the following meth-
ods.
❒From the front, with the front wheels
lifted and the rear wheels on the
ground. Before towing, make sure that
the parking brake is released.
❒From the rear, with the rear wheels lift-
ed and a dolly under the front wheels.
IMPORTANT Towing your vehicle with
the front wheels on the ground can result
in damage to the automatic transaxle.4-WHEEL DRIVE (4WD)
Your vehicle should be towed under one
of the following conditions:
❒With all four wheels on a flat-bed truck.
❒With the front or rear wheels lifted and
a dolly under the other wheels.
❒If you can shift the 2WD/4WD switch
to the “2WD” mode, and if the steer-
ing and drive train are in good condi-
tion and the engine can be started, the
vehicle may also be towed according to
the instructions in the “Towing Your
Vehicle (recreational towing)” section.
IMPORTANT Towing your vehicle with
front and/or rear wheels on the ground
can result in damage to the automatic
transaxle and/or the 4WD drive system.
231-238 SEDICI LUM FL GB 1E 19-06-2009 11:06 Pagina 235

247
FUEL CONSUMPTION - CO2EMISSIONS
According to European Directive in force. M/T: Manual transaxle 2WD: 2-wheel drive
A/T: Automatic transaxle 4WD: 4-wheel drive
1.6 16V2.0 Multijet
1.6 L 2WD 1.6 L 4WD 2.0 L 2WD 2.0 L 4WD
Urban (L/100km) M/T 7.9 8.2 6.4 7.0
(L/100km) A/T 9.2 – – –
Extra-urban (L/100km) M/T 5.2 5.5 4.4 4.6
(L/100km) A/T 5.9 – – –
Combined (L/100km) M/T 6.2 6.5 5.1 5.4
CO2(g/km) M/T 143 149 134 142
(L/100km) A/T 7.2 – – –
CO2(g/km) A/T 165 – – –
NOTE As these data are obtained under certain specific conditions, actual fuel consumption of your vehicle will be different from
these data.
245-248 SEDICI LUM FL GB 1E 19-06-2009 11:09 Pagina 247

250
TECHNICAL SPECIFICATIONS
NOTE Technical specifications are subject to change M/T: Manual transaxle 2WD: 2-wheel drive
without notice A/T: Automatic transaxle 4WD: 4-wheel drive
ENGINE 1.6 16V2.0 Multijet
Code - type
Number and layout of cylinders
Piston bore and stroke
Total displacement
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Fuel
FUEL FEED - IGNITION 1.6 16V2.0 Multijet
Fuel feed
Ignition
Modifications or repairs to the fuel feed system that are not carried out properly or do not take the system’s
technical specifications into account can cause malfunctions leading to the risk of fire.
WARNING
M16A (DOHC) - Euro 5
4 in line
78.0 x 83.0 mm (3.07 x 3.27 in.)
1,598 cm
3(97.5 cu. in)
10.5 : 1
88
120
6,000
156
15.9
4,400
Unleaded petrol 95 RON
(Specification EN228)D20AA - Euro 5
4 in line
83.0 x 90.4 mm (3.27 x 3.56 in.)
1,956 cm3(119.3 cu. in)
16.5 : 1
99.2
135
3,500
320
32.6
1,500
Diesel fuel for motor vehicles
(Specification EN590)
MPI electronic injection
Electronic Single SparkDirect injection with electronically
controlled Multijet Common Rail
Compression
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:10 Pagina 250

252
BRAKES
Service brakes Front
Rear
Parking brake
Vacuum brake
SUSPENSIONS
Front
Rear
STEERING
Type
Minimum steering cycleDisc (Ø 280 mm - 11 in.)
Disc (Ø 280 mm - 11 in.)
Controlled by hand lever, it works on rear brakes
10”
Mc Pherson independent wheels
Bent twisting axle
Power steering, electric
11 m (433 in.)
TRANSMISSION
Drive 4WD
Clutch
Gearbox1.6 16V M/T
1.6 16V A/T
2.0 Multijet4-wheel drive, electronic-control self-locking differential
Dry single disc, Belleville washer, hydraulic control
5 forward gears + reverse
4 forward gears + reverse
6 forward gears + reverse
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:10 Pagina 252

253
4,115 (162.0)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
270/6704,115 (162.0)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
270/6704,115 (162.0)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
270/6704,115 (162.0)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
270/670
DIMENSIONS 1.6 16V2.0 Multijet
Unit: mm (in.)
2WD 4WD 2WD 4WD
Overall length
Overall width
Overall height
Wheelbase
Track Front
Rear
Ground clearance (Standard A)
Boot volume dm3
WHEELS
Tyre size 205/60 R16
Rim size 16 x 6J
Tyre pressures Tyre inflation pressure values are specified on the label located on the driver’s door post.
When loaded up to 4 people, Eco Tire Pressure as listed below is recommended to achieve
the smallest amount of fuel consumption possible.
Front 280 kPa (2.80 kg/cm², 40 psi) - Rear 260 kPa (2.60 kg/cm², 38 psi)
NOTE If loading over 4 people, follow the specified tire pressure listed on the Tire Information
Label.
Recommended snow chains Radial/Axial thickness:
Recommended snow tire 195/65 R15, 205/60 R16
Wheel geometry Toe-in, front
Camber angle, front
2WD
4WD
Caster angle, front
2WD
4WD10 mm (0.39 in.)
1 ± 1 mm (0.0393 ± 0.0393 in.)
− 0° 23’ ± 1°
− 0° 10’ ± 1°
3° 40’ ± 2°
3° 32’ ± 2°
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:10 Pagina 253

254
2WD
4WD
2WD
4WD
M/T
A/T 1,190 (2,623)
1,250 (2,755)1,335 (2,943)
1,370 (3,020)
WEIGHTS Unit: kg (lbs) 1.6 16V2.0 Multijet
Kerb weight (including fuel, spare wheel,
tools and accessories)
185 km/h
175 km/h190 km/h
180 km/h
2WD (M/T)
2WD (A/T)
4WD (M/T)
4WD
4WD6.6 litres (11.6 Imp pt)
6.5 litres (11.4 Imp pt)
50 litres (11.0 Imp gal)
3.9 litres (6.9 Imp pt)
(replacement with oil filter)
2.5 litres (4.4 Imp pt)
5.8 litres (10.2 Imp pt)
(when overhauling)
2.5 litres (4.4 Imp pt)
0.6 litres (1.1 Imp pt)
0.8 litres (1.4 Imp pt)6.5 litres (11.4 Imp pt)
–
50 litres (11.0 Imp gal)
4.4 litres (7.7 Imp pt)
(replacement with oil filter)
2.0 litres (3.5 Imp pt)
–
2.0 litres (3.5 Imp pt)
0.6 litres (1.1 Imp pt)
0.8 litres (1.4 Imp pt)
PERFORMANCE 1.6 16V2.0 Multijet
Top admitted speed after initial vehicle use
CAPACITIES (indicative values) 1.6 16V2.0 Multijet
Coolant
(including reservoir tank)
Fuel tank
Engine oil
Transaxle oil
Transfer oil
Rear differential oil
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:10 Pagina 254

264
– Inspection ........................................ 208
– Rotation........................................... 210
– Technical data................................ 253
Vehicle cleaning.................................. 242
Vehicle identification........................... 246
Vehicle loading and towing ......... 173-174
Ventilation.................................98-101-107
Warning and indicator lights ........... 74
Weights.................................................. 254
Wheels
– Changing .......................................... 212
– Technical data................................ 253
Windows
– Electric window controls............. 24
– Manual window controls ............. 24
Windshield defroster..............98-101-107
Windshield washer
– Control ............................................ 65
– Fluid.................................................. 201
Windshield wiper
– Blades............................................... 227
– Control ............................................ 65
2WD/4WD switch.......................92-159 Suspensions ........................................... 252
Symbols (battery)................................. 4
Tachometer ........................................ 83
Tailgate................................................... 23
Technical specifications...................... 249
Theft deterrent light ........................... 95
Thermometer....................................... 88
Tilt steering lock lever........................ 67
Tools...................................................... 144
Towing the vehicle
– Frame hooks................................... 143
– Instructions..............................174-179
Trailer towing....................................... 174
Transaxle (automatic) ......................... 156
– Changing oil .................................... 197
– Fluid level check............................. 196
– Specific fluid.................................... 196
Transaxle (manual).............................. 157
– Gear oil change .............................. 196
– Gearshift lever............................... 132
– Specification.................................... 195
– Using the transaxle........................ 157
Transmission......................................... 252
Trip meter............................................. 87
Turn signal............................................. 64
– Bulb replacement........................... 223
Tires
– Compact spare tire ....................... 211
261-268 SEDICI LUM FL GB 1E 19-06-2009 11:12 Pagina 264