2009 DODGE CARAVAN tow

A/C Air Filter — If Equipped
Refer to the “Maintenance Schedule” in Section 8 for the
proper maintenance intervals.
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C air filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter:
1. Open the glove compartment and remove all contents.
2. Push in on the sides of the glove compartment and
lower the door.
3. Pivot the glove compartment downward.
4. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing, and remove the cover.5. Remove the A/C air filter by pulling it straight out of
the housing.
6. Install the A/C air filter with the arrow on the filter
pointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
A/C Air Filter Replacement
MAINTAINING YOUR VEHICLE 447
7
ProCarManuals.com

WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
YES EssentialsFabric Cleaning Procedure – If
Equipped
YES Essentialsseats may be cleaned in the following
manner:
•Remove as much of the stain as possible by blotting
with a clean, dry towel.
•Blot any remaining stain with a clean, damp towel.
•For tough stains, apply MOPARTotal Clean or a mild
soap solution to a clean, damp cloth and remove stain.
Use a fresh, damp towel to remove soap residue.
•For grease stains, apply MOPARMulti-Purpose
Cleaner to a clean, damp cloth and remove stain. Use
a fresh, damp towel to remove soap residue.
•Do not use any solvents or protectants on Yes Essen-
tialsproducts.
Cleaning High Gloss Front Door and Pillar
Appliques
When cleaning the front door B-Pillar appliques, care
must be taken to avoid scratching the plastic.
1. Remove all dirt with a wet soft rag. A mild soap
solution may be used. Do not use high alcohol content or
abrasive cleaners. Glass cleaners are not recommended. If
soap is used, wipe clean with a clean damp rag.
2. To maintain the high gloss shine, apply a scratch and
swirl remover onto a damp cloth and apply to the door
464 MAINTAINING YOUR VEHICLE
ProCarManuals.com

applique. Rub the applique with firm pressure then buff
lightly with a clean cotton cloth until a high gloss shine is
achieved.
Cleaning Headlights
Your vehicle has plastic headlights that are lightweight
and less susceptible to stone breakage than glass head-
lights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPARGlass Cleaner or any commercial
household-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments that may
scratch the elements.
When cleaning the rearview mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
MAINTAINING YOUR VEHICLE 465
7
ProCarManuals.com

FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
J18 20 Amp
Yellow— Powertrain Control
Module (PCM) Trans
Range
J19 60 Amp
Yellow— Radiator Fan
J20 30 Amp
Pink— Front Wiper LO/HI
J21 20 Amp
Yellow— Front/Rear Washer
J22 25 Amp
Natural— Sunroof Module
M1 — 15 Amp
BlueCenter High Mounted
Stop Light (CHMSL)/
Brake Switch
M2 — 20 Amp
YellowTrailer Lighting
M3 — 20 Amp
Yellow—
FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
M4 — 10 Amp
RedTrailer Tow
M5 — 25 Amp
NaturalInverter
M6 — 20 Amp
Yellow—
M7 — 20 Amp
YellowPower Outlet #2
(BATT/ACC SELECT)
M8 — 20 Amp
YellowFront Heated Seat (If
Equipped)
M9 — 20 Amp
YellowRear Heated Seat (If
Equipped)
MAINTAINING YOUR VEHICLE 469
7
ProCarManuals.com

FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
M10 — 20 Amp
YellowIgnition Off Draw —
Vehicle Entertainment
System (IOD-VES),
Satellite Digital Audio
Receiver (SDARS),
DVD, Hands-Free
Module (HFM), Uni-
versal Garage Door
Opener (UGDO), Van-
ity Lamp (VANITY
LP)
M11 — 10 Amp
Red(Ignition Off Draw)
IOD-HVAC/ATC,
MW SENSR, Under-
hood Lamp (UH
LMP)
M12 — 30 Amp
GreenAmplifier (AMP)
FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
M13 — 20 Amp
YellowIgnition Off Draw—
Cabin Compartment
Node (IOD-CCN),
Wireless Control
Module (WCM), SI-
REN, Clock Module
(CLK MOD), Multi-
Function Control
Switch (MULTIFCTN
SW)
M14 — 20 Amp
YellowTrailer Tow (Export
Only)
470 MAINTAINING YOUR VEHICLE
ProCarManuals.com

60,000 Miles (100,000 km) or
60 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏Rotate tires.
❏Replace the engine air cleaner filter.
❏Replace the air conditioning filter.
❏Inspect the brake linings, replace if
necessary.
❏Change the automatic transaxle fluid &
filter if using your vehicle for any of the
following: police, taxi, fleet or frequent
trailer towing.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
66,000 Miles (110,000 km) or
66 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏Rotate tires.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 491
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
ProCarManuals.com

Adding Engine Coolant (Antifreeze).......... 452
Adding Fuel........................... 387
Adding Washer Fluid..................... 449
Additives, Fuel......................... 381
Adjustable Pedals....................... 182
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 441
Air Conditioner Maintenance............... 446
Air Conditioning........................ 301
Air Conditioning Controls................. 301
Air Conditioning Filter.................320,447
Air Conditioning, Operating Tips............ 320
Air Conditioning, Rear Zone.............308,315
Air Conditioning Refrigerant............... 446
Air Conditioning System.............301,310,446
Air Conditioning System, Zone Control........ 306
Air Pressure, Tires....................... 359
Airbag..............................65,72
Airbag Deployment....................... 73
Airbag Light...................66,71,75,94,244Airbag Maintenance....................... 74
Airbag, Side..........................70,72
Airbag, Window (Side Curtain)...........68,70,72
Alarm Light........................... 244
Alarm (Security Alarm).................... 18
Alignment and Balance................... 366
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 293
Antifreeze (Engine Coolant)...........451,452,479
Disposal............................ 454
Anti-Lock Warning Light.................. 237
Anti-Theft System........................ 18
Appearance Care........................ 460
Ashtray............................... 210
Assistance Towing....................... 129
Auto Down Power Windows................ 40
Auto Up Power Windows................41,206
Automatic Dimming Mirror................ 102
Automatic Door Locks...................34,35
512 INDEX
ProCarManuals.com

Computer, Trip/Travel.................... 255
Connector
UCI ................................ 286
Universal Consumer Interface (UCI)......... 286
Console.............................. 217
Console, Floor.......................... 217
Console, Overhead....................... 194
Console, Removable...................... 222
Contract, Service........................ 505
Coolant Pressure Cap (Radiator Cap).......... 453
Cooling System......................... 450
Adding Coolant (Antifreeze).............. 452
Coolant Capacity...................... 479
Coolant Level......................451,454
Disposal of Used Coolant................ 454
Drain, Flush, and Refill.................. 451
Inspection........................... 454
Points to Remember.................... 455
Pressure Cap......................... 453Radiator Cap......................... 453
Selection of Coolant (Antifreeze)......451,479,480
Cruise Control (Speed Control).............. 183
Cup Holder.........................209,466
Customer Assistance..................... 503
Data Recorder, Event...................... 76
Daytime Running Lights................... 176
Dealer Service.......................... 438
Defroster, Rear Window................... 223
Defroster, Windshield................94,304,314
Diagnostic System, Onboard................ 435
Dimmer Control........................ 174
Dipsticks
Automatic Transaxle.................... 459
Automatic Transmission................. 459
Oil (Engine).......................... 438
Power Steering........................ 338
Disabled Vehicle Towing................... 427
INDEX 515
10
ProCarManuals.com