2009 DODGE CARAVAN steering

CAUTION!
The A/C air filter is labeled with an arrow to indicate
airflow direction through the filter. Failure to prop-
erly install the filter will result in the need to replace
it more often.
7. Rotate the glove compartment door back into position.
Steering Shaft Seal
The steering shaft seal, at the point where the shaft passes
through the bulkhead, is lubricated when it is installed. If
the seal becomes noisy when the steering shaft is turned,
it should be lubricated with a multipurpose grease.
MOPARMulti-Purpose Lubricant is recommended.
Drive Shaft Universal Joints
Your vehicle has constant velocity universal joints. Peri-
odic lubrication of these joints is not required. However,
the joint boots should be inspected for external leakage ordamage when other maintenance is performed. If leakage
or damage is evident, the universal joint boot and grease
should be replaced immediately.
Continued operation could result in failure of the univer-
sal joint due to water and dirt contamination of the
grease. This would require complete replacement of the
joint assembly.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, door hinge pivot points and rollers, liftgate,
tailgate, sliding doors and hood hinges, should be lubri-
cated periodically with a lithium based grease such as
MOPARSpray White Lube to assure quiet, easy opera-
tion and to protect against rust and wear. Prior to the
application of any lubricant, the parts concerned should
be wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
448 MAINTAINING YOUR VEHICLE
ProCarManuals.com

FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
M15 — 20 Amp
YellowCOL MOD, IR SNS,
Heater Ventilation,
Air Conditioning/
Automatic Tempera-
ture Control (HVAC/
ATC), Rear View Mir-
ror (RR VW MIR),
Cabin Compartment
Node (CCN), Transfer
Case Switch (T-CASE
SW), RUN/ST, Multi-
Function Control
Switch (MULTIFTCN
SW), Tire Pressure
Monitor (TPM), Glow
Plug Module (GLW
PLG MOD) — Export
Diesel Only
FUSES/TIPM
CavityCartridge
FuseMini-
FuseDescription
M16 — 10 Amp
RedOccupant Restraint
Controller/Occupant
Classification Module
(ORC/OCM)
M17 — 15 Amp
BlueLeft Tail/License/
Park Lamp (LT-TAIL/
LIC/PRK LMP)
M18 — 15 Amp
BlueRight Tail/Park/Run
Lamp (RT-TAIL/
PRK/RUN LMP)
M19 — 25 Amp
NaturalAuto Shut Down
(ASD #1 and #2)
M20 — 15 Amp
BlueCabin Compartment
Node Interior Light
(CCN INT LIGHT),
Switch Bank (SW
BANK), Steering Con-
trol Module (SCM)
MAINTAINING YOUR VEHICLE 471
7
ProCarManuals.com

steering column. If you experience temporary or perma-
nent loss of these systems, see your authorized dealer for
service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than
21 days, you may want to take steps to protect your
battery. You may do the following:
•Remove the 20 Amp mini-fuse in the Totally Inte-
grated Power Module (TIPM) labeled Ignition-Off
Draw (IOD).
•Or, disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Interior Bulb Number
Center & Rear Dome Light.................. 578
Center & Rear Reading Lights............... 578
Front Door Courtesy Light.................. 578
Front Header Reading Lights — If Equipped..... 578
Instrument Cluster Lights.................PC74
Liftgate Light(s).......................... 578
Overhead Console Reading Lights..........PC579
Removable Console Light — If Equipped....... 194
Visor Vanity Lights....................6501966
NOTE:For lighted switches, see your authorized dealer
for replacement instructions.
All of the interior bulbs are glass wedge base or glass
cartridge types. Aluminum base bulbs are not approved
and should not be used for replacement.
474 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic
TransaxleMOPARATF+4 Automatic Transmission Fluid
Brake Master
CylinderMOPARDOT 3 and SAE J1703 should be used or equivalent. If DOT 3 brake fluid is not
available, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering
ReservoirMOPARPower Steering Fluid +4 or MOPARATF+4 Automatic Transmission Fluid
MAINTAINING YOUR VEHICLE 481
7
ProCarManuals.com

•Check the fluid levels of the coolant reservoir, the
brake master cylinder, the power steering and the
transaxle and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
486 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
ProCarManuals.com

Camera, Rear........................... 192
Capacities, Fluid........................ 479
Caps, Filler
Fuel................................ 387
Oil (Engine).......................... 440
Power Steering........................ 338
Radiator (Coolant Pressure)............... 453
Car Washes............................ 461
Carbon Monoxide Warning................. 382
Cargo Compartment
Luggage Carrier....................... 225
Cargo (Vehicle Loading)................... 216
Caution, Exhaust Gas.................53,95,382
Cellular Phone....................... 115,301
Center High Mounted Stop Light............ 478
Chains, Tire............................ 367
Changing A Flat Tire..................... 412
Chart, Tire Sizing........................ 350Check Engine Light
(Malfunction Indicator Light).............242,436
Child Restraint........................81,83
Child Restraint Tether Anchors............... 86
Child Safety Locks........................ 47
Child Seat.............................. 89
Clean Air Gasoline....................... 379
Cleaning
Wheels............................. 462
Climate Control......................... 301
Clock...........................263,267,276
Coat Hook............................ 216
Coin Holder........................... 217
Cold Weather Operation................... 325
Compact Disc (CD) Maintenance............. 300
Compact Spare Tire...................... 361
Compass........................248,251,257
Compass Calibration..................251,257
Compass Variance....................250,258
514 INDEX
ProCarManuals.com

Computer, Trip/Travel.................... 255
Connector
UCI ................................ 286
Universal Consumer Interface (UCI)......... 286
Console.............................. 217
Console, Floor.......................... 217
Console, Overhead....................... 194
Console, Removable...................... 222
Contract, Service........................ 505
Coolant Pressure Cap (Radiator Cap).......... 453
Cooling System......................... 450
Adding Coolant (Antifreeze).............. 452
Coolant Capacity...................... 479
Coolant Level......................451,454
Disposal of Used Coolant................ 454
Drain, Flush, and Refill.................. 451
Inspection........................... 454
Points to Remember.................... 455
Pressure Cap......................... 453Radiator Cap......................... 453
Selection of Coolant (Antifreeze)......451,479,480
Cruise Control (Speed Control).............. 183
Cup Holder.........................209,466
Customer Assistance..................... 503
Data Recorder, Event...................... 76
Daytime Running Lights................... 176
Dealer Service.......................... 438
Defroster, Rear Window................... 223
Defroster, Windshield................94,304,314
Diagnostic System, Onboard................ 435
Dimmer Control........................ 174
Dipsticks
Automatic Transaxle.................... 459
Automatic Transmission................. 459
Oil (Engine).......................... 438
Power Steering........................ 338
Disabled Vehicle Towing................... 427
INDEX 515
10
ProCarManuals.com

Replacement Parts..................... 386
Starting............................. 385
Flooded Engine Starting................... 325
Floor Console.......................... 217
Fluid Capacities......................... 479
Fluid Leaks............................. 95
Fluid Level Checks
Automatic Transaxle.................... 459
Automatic Transmission................. 459
Brake............................... 456
Power Steering........................ 338
Fluids................................ 480
Fluids, Lubricants and Genuine Parts.......... 480
Fog Light Service........................ 476
Fog Lights.......................177,244,476
Fold in Floor (Stow n Go) Seating........... 149
Freeing A Stuck Vehicle................... 427
Fuel................................. 378
Adding............................. 387Additives............................ 381
Clean Air............................ 379
Filler Cap (Gas Cap).................236,387
Filler Door (Gas Cap)................... 236
Gasoline............................ 378
Gauge.............................. 236
Light............................... 245
Octane Rating........................ 480
Requirements......................378,479
Tank Capacity........................ 479
Fuel, Flexible.............See Flexible Fuel Vehicles
Fuel System Caution..................... 382
Fueling............................... 387
Fuses................................ 467
Garage Door Opener (HomeLink) ........... 197
Gas Cap (Fuel Filler Cap)...............387,388
Gasoline, Clean Air...................... 379
Gasoline (Fuel)......................... 378
518 INDEX
ProCarManuals.com