2009 DODGE CARAVAN fuel filter

To fix a Non-FFV vehicle inadvertently fueled once with
E-85 perform the following:
•drain the fuel tank (see your authorized dealer)
•change the engine oil and oil filter
•disconnect and reconnect the battery to reset the
engine controller memory
More extensive repairs will be required for prolonged
exposure to E-85 fuel.
MMT In Gasoline
MMT is a manganese containing metallic additive that is
blended into some gasoline to increase octane. Gasoline
blended with MMT provides no performance advantage
beyond gasoline of the same octane number without
MMT. Gasoline blended with MMT reduces spark plug
life and reduces emission system performance in some
vehicles. The manufacturer recommends that gasoline
without MMT be used in your vehicle. The MMT contentof gasoline may not be indicated on the gasoline pump,
therefore, you should ask your gasoline retailer whether
the gasoline contains MMT.
It is even more important to look for gasolines without
MMT in Canada, because MMT can be used at levels
higher than those allowed in the United States.
MMT is prohibited in Federal and California reformu-
lated gasolines.
Materials Added to Fuel
All gasoline sold in the United States is required to
contain effective detergent additives. Use of additional
detergents or other additives are not needed under
normal conditions and would result in additional cost.
Therefore you should not have to add anything to the
fuel.
STARTING AND OPERATING 381
5
ProCarManuals.com

The automatic transaxle fluid and filter should be
changed if you REGULARLY tow a trailer for more than
45 minutes of continuous operation. Refer to the “Main-
tenance Schedule” in Section 8 of this manual for trans-
axle fluid change intervals.
NOTE:
•Check the automatic transaxle fluid level before tow-
ing.
•The six-speed automatic transaxle is sealed and re-
quires an authorized dealer to check the transaxle
fluid.
Towing Tips — Electronic Speed Control (If
Equipped)
•
Do not use in hilly terrain or with heavy loads.
•When using the speed control, if you experience speed
drops greater than 10 mph (16 km/h), disengage until
you can get back to cruising speed.
•Use speed control in flat terrain and with light loads to
maximize fuel efficiency.
Towing Tips — Cooling System
To reduce potential for engine and transaxle overheating,
take the following actions:
•City Driving
When stopped for short periods of time, put transaxle
gear selector lever in NEUTRAL but do not increase
engine idle speed.
•Highway Driving
Reduce speed.
•Air Conditioning
Turn off temporarily.
406 STARTING AND OPERATING
ProCarManuals.com

MAINTAINING YOUR VEHICLE
CONTENTS
Engine Compartment — 3.3/3.8L.......... 433
Engine Compartment — 4.0L............. 434
Onboard Diagnostic System — OBD II....... 435
▫Loose Fuel Filler Cap Message — Gascap . . . 435
Emissions Inspection And Maintenance
Programs............................ 436
Replacement Parts..................... 437
Dealer Service........................ 438
Maintenance Procedures................. 438▫Engine Oil......................... 438
▫Engine Oil Filter..................... 441
▫Engine Air Cleaner Filter............... 441
▫Exhaust System...................... 442
▫Maintenance-Free Battery............... 444
▫Air Conditioner Maintenance............ 446
▫Steering Shaft Seal.................... 448
▫Drive Shaft Universal Joints............. 448
▫Body Lubrication..................... 448
7
ProCarManuals.com

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)20 Gallons 76 Liters
Engine Oil with Filter
3.3L and 3.8L Engine (SAE 5W-20, API Certified) 5 Quarts 4.7 Liters
4.0 Liter Engine (SAE 10W-30, API Certified) 5.5 Quarts 5.2 Liters
Cooling System *
3.3, 3.8, and 4.0 Liter Engine (MOPAREngine Coolant/
Antifreeze 5 Year/100,000 Mile Formula)13.4 Quarts 12.6 Liters
* Includes heater and coolant recovery bottle filled to MAX level. Add 2.9 Qts (2.8 L) if equipped with a rear
heater.
MAINTAINING YOUR VEHICLE 479
7
ProCarManuals.com

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluid, Lubricant, or Genuine Part
Engine CoolantMOPARAntifreeze/Coolant Five Year/100,000 Mile Formula HOAT
(Hybrid Organic Additive Technology)
Engine Oil (3.3L and 3.8L Engines)Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your oil filler cap for
correct SAE grade
Engine Oil (4.0L Engine)Use API Certified SAE 10W-30 Engine Oil, meeting the requirements
of Chrysler Material Standard MS-6395. Refer to your oil filler cap for
correct SAE grade
Oil Filter (3.3L and 3.8L Engines) MOPAR04105409 or equivalent
Oil Filter (4.0L Engine) MOPAR05281090 or equivalent
Spark Plugs (3.3L and 3.8L Engines) RE14PLP5 (Gap 0.050 in [1.27 mm])
Spark Plugs (4.0L Engine) ZFR5LP-13G (Gap 0.050 in [1.27 mm])
Fuel Selection (3.3L and 3.8L Engines) 87 Octane
Fuel Selection (4.0L Engine) 87 Octane Acceptable — 89 Recommended
480 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Adding Engine Coolant (Antifreeze).......... 452
Adding Fuel........................... 387
Adding Washer Fluid..................... 449
Additives, Fuel......................... 381
Adjustable Pedals....................... 182
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 441
Air Conditioner Maintenance............... 446
Air Conditioning........................ 301
Air Conditioning Controls................. 301
Air Conditioning Filter.................320,447
Air Conditioning, Operating Tips............ 320
Air Conditioning, Rear Zone.............308,315
Air Conditioning Refrigerant............... 446
Air Conditioning System.............301,310,446
Air Conditioning System, Zone Control........ 306
Air Pressure, Tires....................... 359
Airbag..............................65,72
Airbag Deployment....................... 73
Airbag Light...................66,71,75,94,244Airbag Maintenance....................... 74
Airbag, Side..........................70,72
Airbag, Window (Side Curtain)...........68,70,72
Alarm Light........................... 244
Alarm (Security Alarm).................... 18
Alignment and Balance................... 366
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 293
Antifreeze (Engine Coolant)...........451,452,479
Disposal............................ 454
Anti-Lock Warning Light.................. 237
Anti-Theft System........................ 18
Appearance Care........................ 460
Ashtray............................... 210
Assistance Towing....................... 129
Auto Down Power Windows................ 40
Auto Up Power Windows................41,206
Automatic Dimming Mirror................ 102
Automatic Door Locks...................34,35
512 INDEX
ProCarManuals.com

Exhaust Gas Caution..................53,382
Flooded, Starting...................... 325
Fuel Requirements..................378,479
Oil ...........................438,479,480
Oil Change Interval.................... 439
Oil Disposal.......................... 441
Oil Filler Cap......................... 440
Oil Filter Disposal...................... 441
Oil Selection.......................439,479
Oil Synthetic......................... 441
Overheating.......................... 410
Starting............................. 324
Temperature Gauge..................... 236
Enhanced Accident Response Feature.......... 72
Event Data Recorder...................... 76
Exhaust Gas Caution..............53,95,382,443
Exhaust System......................... 442
Express Down Windows................... 23
Extender, Seat Belt........................ 64Exterior Folding Mirrors................... 104
Fabric Care.........................463,464
Filler Location Fuel...................... 236
Filters
Air Cleaner.......................... 441
Air Conditioning....................320,447
Engine Oil........................441,480
Engine Oil Disposal.................... 441
Flashers
Hazard Warning....................... 410
Turn Signal.....................237,476,477
Flash-To-Pass........................... 179
Flat Tire Stowage........................ 421
Flexible Fuel Vehicles
Cruising Range........................ 386
Engine Oil........................... 386
Fuel Requirements..................383,385
Maintenance.......................... 387
INDEX 517
10
ProCarManuals.com