2008 CHRYSLER PT CRUISER Cluster

Loose Fuel Filler Cap Message
After fuel is added, the vehicle diagnostic system can
determine if the fuel filler cap is loose, improperly
installed, or damaged. A gASCAP message will be dis-
played in the instrument cluster. Tighten the gas cap until
a9clicking9sound is heard. This is an indication that the
gas cap is properly tightened. Press the odometer reset
button to turn the message off. If the problem persists,
the message will appear the next time the vehicle is
started. This might indicate a damaged cap. If the prob-
lem is detected twice in a row, the system will turn on the
Malfunction Indicator Light (MIL). Resolving the prob-
lem will turn the MIL light off.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle's emissions control system.
Failure to pass could prevent vehicle registration.
For states that require an Inspection and Mainte-
nance (I/M), this check verifies the Malfunction
Indicator Light (MIL) is functioning and is not on
when the engine is running, and that the OBD II system
is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system maynotbe ready if your vehicle was recently
serviced, recently had a dead battery, or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
MAINTAINING YOUR VEHICLE 381
7

Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Dry with a soft tissue.
CONVERTIBLE TOP CARE
Immediate removal of any contaminant is recommended.
Regular washing of the top will enhance its life and
appearance, and make successive cleanings easier. Do not
subject the top to excessive heat. Frequently vacuum the
top and storage compartment.
Washing
Hand washing is highly recommended. Automatic car
washing equipment can damage the top material. If you
must use an automatic car wash, soft cloth systems are
preferred.
416 MAINTAINING YOUR VEHICLE

REPLACEMENT BULBS
LIGHT BULBS Ð Inside Bulb No.
Center Console Floor Lamp................. T37
Climate Controls......................6233137
Console Gear Selector...................PC194
Dome Light (sedan)......................T579
Dome Light / Sport Bar Lights (convertible)....T904
Instrument Cluster Illumination.............. 74
Overhead Reading Light (Overhead Console). . . T1037
Overhead Reading Light (Rearview Mirror).....T192
Rear Cargo............................T906
Visor Vanity.........................6501966
All the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved and should not
be used for replacement.LIGHTS BULBS Ð Outside Bulb No.
Low Beam Headlight...................9006XS
High Beam Headlight...................9005XS
Front Park/Turn Signal/Side Marker
Light............................4157NAKX
Front Fog Light.........................9145
Center High Mounted Stop Light
(CHMSL) (Sedan)...................921±W16W
Center High Mounted Stop Light
(CHMSL) (Convertible).................... LED
Rear Tail/Stop..........................3157
Rear Turn Signal.......................3757A
Backup Light.....................3157-P27/7W
License Light........................... 168
424 MAINTAINING YOUR VEHICLE

Headlights
Bulb Replacement...................... 425
Cleaning............................ 415
High Beam........................189,234
High Beam/Low Beam Select Switch........ 189
Passing............................. 190
Switch.............................. 186
Heated Seats........................... 169
Hitches
Trailer Towing........................ 345
HomeLinkt(Garage Door Opener) Transmitter . . . 197
Hood Release.......................... 183
Hoses.............................403,404
Ignition............................... 13
Key ................................. 13
Wiring System (Spark Plug Wires).......... 388
Ignition Key Removal..................... 13
Immobilizer (Sentry Key).................15,37Infant Restraint.......................73,107
Information Center, Vehicle................. 240
Inside Rearview Mirror................... 135
Instrument Cluster....................223,226
Instrument Panel and Controls.............. 222
Instrument Panel Cover................413,415
Instrument Panel Lens Cleaning............. 416
Integrated Power Module (Fuses)............ 419
Interior Appearance Care.................. 413
Intermittent Wipers (Delay Wipers)........... 192
Introduction............................. 4
Jack Location........................... 361
Jack Operation.......................360,363
Jacking Instructions...................... 363
Jump Starting.......................... 367
Key, Programming........................ 17
Key, Replacement........................ 16
INDEX 477
10

Key, Sentry (Immobilizer)................... 15
Key-In Reminder......................... 15
Keyless Entry System (Convertible)............ 30
Keyless Entry System (Sedan)................ 24
Keys................................. 13
Lane Change and Turn Signals.............. 230
Lap/Shoulder Belts.....................45,82
Latches
Hood............................... 183
Lead Free Gasoline...................... 337
Life of Tires............................ 327
Liftgate (Sedan).......................... 37
Light Bulbs.........................424,425
Lights............................. 117,184
Airbag......................70,104,116,234
Anti-Lock........................... 233
Back-Up............................. 427
Brake Warning........................ 231Center Mounted Stop................... 428
Daytime Running...................... 187
Dimmer Switch, Headlight............... 186
Engine Temperature Warning.............. 232
Fog ..........................188,233,426
Front Replacement..................... 425
Headlight Switch...................... 186
Headlights........................... 186
High Beam Indicator.................... 234
Instrument Cluster..................... 186
Lights On Reminder.................... 187
Low Fuel............................ 233
Malfunction Indicator (Check Engine)........ 229
Map Reading......................184,185
Oil Pressure.......................... 234
Rear Servicing........................ 427
Seat Belt Reminder..................... 232
Security Alarm (Theft Alarm).............. 36
Service.............................. 425
478 INDEX

Theft Alarm (Security Alarm).............. 233
Tire Pressure Monitoring (TPMS)........... 332
Traction Control....................... 312
Turn Signal..................186,189,230,426
Voltage............................. 230
Warning (Instrument Cluster Description)..... 226
Loading Vehicle......................... 342
Tires ............................... 317
Locks
Child Protection........................ 22
Door................................ 19
Power Door........................... 20
Steering Wheel......................... 18
Low Tire Pressure System.................. 332
Lubrication, Body....................... 395
Luggage Rack (Roof Rack)................. 215
Lumbar Support........................ 166
Maintenance Free Battery.................. 392Maintenance, General..................... 384
Maintenance Procedures................... 384
Maintenance Schedule
Schedule ªAº-Non Turbo................. 448
Schedule ªAº-Turbo.................... 453
Schedule ªBº......................... 437
Schedule ªBº-All Engines................ 437
Maintenance Schedules.................... 434
Malfunction Indicator Light (Check Engine) . . 229,381
Manual Override, Convertible Top.........134,373
Manual, Service......................... 465
Manual Transaxle..................292,301,410
Downshifting......................... 304
Fluid Level Check...................... 410
Frequency of Fluid Change............... 410
Lubricant Selection..................... 410
Map/Reading Lights..................184,185
Master Cylinder (Brakes).................. 406
Methanol............................. 337
INDEX 479
10

Universal Transmitter..................... 197
Unleaded Gasoline....................... 337
Untwisting Procedure, Seat Belt............52,88
Upholstery Care........................ 413
Vacuum/Vapor Harnesses................. 403
Vanity Mirrors.......................... 138
Variance, Compass....................... 236
Vehicle Identification Number (VIN)............ 6
Vehicle Loading......................318,342
Vehicle Modifications/Alterations.............. 7
Vehicle Storage......................... 423
Vehicle Theft Alarm (Security Alarm).......... 36
Warning Lights (Instrument Cluster
Description)........................... 226
Warnings and Cautions..................... 6
Warranty Information..................... 464
Washer, Adding Fluid..................... 218Washer, Rear........................... 217
Washers, Windshield..................... 191
Washing Vehicle......................... 411
Wheel Alignment and Balance............... 329
Wheel and Wheel Trim.................... 413
Wheel and Wheel Trim Care................ 413
Wind Buffeting.......................44,205
Window Fogging........................ 284
Windows.............................. 42
Windshield Washers...................190,191
Windshield Wipers....................190,396
Wiper Blade Replacement.................. 396
Wiper, Rear............................ 217
Wipers, Intermittent...................... 192
YES EssentialstFabric Cleaning Procedure...... 414
INDEX 487
10

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE A WORD ABOUT YOUR KEYS
IGNITION KEY REMOVALLOCKING DOORS WITH A KEYKEY-IN-IGNITION REMINDERSENTRY KEY - IF EQUIPPED Replacement KeysSentry Key ProgrammingGeneral InformationSTEERING WHEEL LOCK - IF EQUIPPED If You Wish To Manually Lock The Steering
WheelTo Release The Steering Wheel LockAutomatic Transaxle Ignition Interlock SystemDOOR LOCKS MANUAL DOOR LOCKSPOWER DOOR LOCKS - IF EQUIPPEDCHILD PROTECTION DOOR LOCK SYSTEM - IF EQUIPPEDREMOTE KEYLESS ENTRY (SEDAN)
TO UNLOCK THE DOORS AND LIFTGATETO LOCK THE DOORS AND LIFTGATE - IF EQUIPPED WITH POWER OPTIONSPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERSGENERAL INFORMATION
TRANSMITTER BATTERY SERVICEREMOTE KEYLESS ENTRY (CONVERTIBLE) TO UNLOCK THE DOORSTO LOCK THE DOORSTO UNLATCH THE DECK LIDPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERS
GENERAL INFORMATIONTRANSMITTER BATTERY SERVICESECURITY ALARM SYSTEM - IF EQUIPPED To set the alarmTo disarm the systemSecurity System Manual OverrideLIFTGATE (SEDAN) Opening The Liftgate While the Security Alarm Is ActivatedDECK LID
(CONVERTIBLE) POWER DECK LID RELEASE (Convertible)EMERGENCY SEAT BACK RELEASE (SEDAN) EMERGENCY DECK LID RELEASE LATCH (CONVERTIBLE) POWER WINDOWS AUTO DOWN FEATUREREAR WINDOW SWITCHESWIND BUFFETING
OCCUPANT RESTRAINTS (SEDAN) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT UNTWISTING PROCEDUREADJUSTABLE UPPER SHOULDER SEAT BELT ANCHORAGESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM
(BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIRBAGCHILD RESTRAINTOCCUPANT RESTRAINTS (CONVERTIBLE) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT
UNTWISTING PROCEDURESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM (BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS)CHILD RESTRAINT
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Exhaust GasSafety Checks You Should Make Inside The VehiclePeriodic Safety Checks You Should Make Outside The VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE CONVERTIBLE TOP
OPERATION To Lower The TopTo Raise The TopConvertible Top Boot Cover Installation-If EquippedConvertible Top Boot Cover Removal and StorageCONVERTIBLE TOP MANUAL OVERRIDEMIRRORS Inside Day/Night Mirror - If EquippedOutside Mirror-Drivers Side
Outside Mirror-Passengers SideElectric Remote-Control Mirrors - If EquippedIlluminated Vanity Mirrors - If EquippedSun Visor Sliding FeatureHANDS-FREE COMMUNICATION (UConnect) - IF EQUIPPED OperationsPhone Call FeaturesUConnect System Features
Advanced Phone ConnectivityThings You Should Know About Your UConnect SystemGeneral InformationSEATS FRONT SEAT ADJUSTMENTPOWER SEAT ADJUSTER -IF EQUIPPEDMANUAL LUMBAR - IF EQUIPPEDFOLDING FRONT PASSENGER SEAT - IF
EQUIPPEDDRIVERS SEAT BACK TILT - IF EQUIPPEDPASSENGER SEAT BACK TILT (EASY ENTRY SYSTEM) - CONVERTIBLEADJUSTABLE HEAD RESTRAINTSHEATED SEATS - IF EQUIPPEDFOLDING REAR SEAT (SEDAN)FOLDING REAR SEAT
(CONVERTIBLE)TUMBLING REAR SEAT (SEDAN)TUMBLING REAR SEAT (CONVERTIBLE)REAR SEAT REMOVAL (SEDAN)TO OPEN AND CLOSE THE HOOD LIGHTS Map/Reading Lights (Sedan)Map/Reading Lights (Convertible)Multi-Function Control Lever
Headlights, Parking Lights, Instrument Panel LightsDaytime Running Lights (DRL) - If EquippedLights-on ReminderFog Lights - If Equipped Turn Signals Highbeam/Lowbeam Select Switch Passing LightWINDSHIELD WIPERS AND WASHERS Windshield WashersMist
Feature Windshield Wiper OperationIntermittent Wiper SystemTILT STEERING COLUMN ELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set At A Desired SpeedTo DeactivateTo Resume SpeedTo Vary The Speed SettingManual TransaxleTo Accelerate
For PassingGARAGE DOOR OPENER - IF EQUIPPED PROGRAMMING HOMELINKGATE OPERATOR/CANADIAN PROGRAMMINGUSING HOMELINKREPROGRAMMING A SINGLE HOMELINK BUTTONSECURITYTROUBLESHOOTING TIPSGENERAL
INFORMATIONPOWER SUNROOF (SEDAN ONLY) - IF EQUIPPED Express Open FeatureWind BuffetingSunroof MaintenanceELECTRICAL POWER OUTLETS Electrical Outlet Use With Engine OffCONSOLE FEATURES STORAGE Center Console/Armrest Storage
Bin Storage PocketsREAR SHELF PANEL- IF EQUIPPED Position 1 (Top)Position 2 (Middle)Position 3 (Floor)Position 4 (Vertical)Position 5 (table)ROOF LUGGAGE RACK - IF EQUIPPED REAR WINDOW FEATURES Electric Rear Window Defroster Rear Wiper/Washer
Switch (Sedan Models Only) - If EquippedAdding Washer FluidUNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES INSTRUMENT CLUSTER-BASE INSTRUMENT CLUSTER-PREMIUM INSTRUMENT CLUSTER-TURBO INSTRUMENT
CLUSTER DESCRIPTIONS COMPASS MINI TRIP COMPUTER (CMTC) - IF EQUIPPED Compass Mini Trip Computer Reset ButtonCompass/Temperature DisplayOdometerDisplayTrip Odometer (ODO)ELECTRONIC VEHICLE INFORMATION CENTER (EVIC) - If
Equipped EVIC Functions Compass/Temperature/AudioAverage Fuel EconomyDistance To Empty (DTE)Elapsed TimeTire Pressure Monitor (TPM)PersonalSettings (Customer Programmable Features)SETTING THE ANALOG CLOCK RADIO GENERAL INFORMATION
Radio Broadcast SignalsTwo Types of SignalsElectrical DisturbancesAM ReceptionFM ReceptionSALES CODE REF - AM/FM/CD (SINGLE DISC) RADIO WITH OPTIONAL SATELLITE RADIO AND HANDS FREE PHONE CAPABILITY Operating Instructions - Radio Mode
Operating Instructions - CD ModeOperating Instructions - Auxiliary ModeOperating Instructions - Hands-Free Phone - If EquippedOperating Instructions - Satellite Radio - If EquippedSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL SATELLITE RADIO,
HANDS-FREE PHONE, AND VIDEO ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperating Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperating
Instructions - (CD Mode for MP3 Audio Play)LOAD/EJECT Button (CD Mode for MP3 Play)SATELLITE RADIO - IF EQUIPPED System ActivationElectronic SerialNumber/Sirius Identification Number (ESN/SID)Selecting Satellite Mode in REF, and RAQ, RadiosSelecting
a ChannelStoring and Selecting Pre-Set ChannelsUsing the PTY (Program Type) Button (if equipped)PTY Button SCANPTY Button SEEKSatellite AntennaReception QualityCD/DVD DISC MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE
CONTROLS Climate ControlsOperating Tips STARTING AND OPERATING STARTING PROCEDURES AUTOMATIC TRANSAXLEMANUAL TRANSAXLENORMAL STARTINGEXTREMELY COLD WEATHER (BELOW -20 degrees F or -29 degrees C)IF THE ENGINE FAILS
TO STARTAFTER STARTINGTURBOCHARGER COOL-DOWN AUTOMATIC TRANSAXLE - IF EQUIPPED BRAKE/TRANSMISSION INTERLOCK SYSTEMAUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEMFOUR-SPEED AUTOMATIC TRANSAXLERESET
MODEGEAR RANGES FOR THE FOUR-SPEED AUTOMATIC TRANSAXLEAUTOSTICK - IF EQUIPPED AUTOSTICK OperationAUTOSTICK General InformationMANUAL TRANSAXLE OPERATION - IF EQUIPPED 2.4 LITER TURBO - IF EQUIPPED MANUAL
TRANSAXLE - RECOMMENDED SHIFT SPEEDSDownshiftingPARKING BRAKE BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (ABS) - IF EQUIPPEDPOWER STEERING TRACTION CONTROL SYSTEM - IF EQUIPPED TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresRadial Ply TiresCompact Spare Tire - If EquippedLimited-Use Spare - If EquippedTire SpinningTread Wear IndicatorsLife of Tire
Replacement TiresAlignment and BalanceTIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED BASESYSTEM - IF EQUIPPEDGENERAL INFORMATIONFUEL REQUIREMENTS -
GASOLINE ENGINES 2.4L AND 2.4L STANDARD TURBO ENGINESREFORMULATED GASOLINEGASOLINE/OXYGENATE BLENDSMMT IN GASOLINEMATERIALS ADDED TO FUELFUELSYSTEM CAUTIONSCARBON MONOXIDE WARNINGSADDING FUEL Fuel
Filler Cap (Gas Cap)Loose Fuel Filler Cap MessageVEHICLE LOADING TRAILER TOWING COMMON TOWING DEFINITIONSTRAILER HITCH CLASSIFICATIONTRAILER TOWING WEIGHTS (MAXIMUM TRAILER WEIGHT RATINGS)TRAILER AND TONGUE WEIGHT
TOWING REQUIREMENTSTOWING TIPSRECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Towing This Vehicle Behind Another Vehicle (Flat towing with all fourwheels on the ground)WHAT TO DO IN EMERGENCIES HAZARD WARNING FLASHER IF YOUR
ENGINE OVERHEATS JACKING AND TIRE CHANGING JACK LOCATIONSPARE TIRE STOWAGEPREPARATIONS FOR JACKINGJACKING INSTRUCTIONS JUMP-STARTING PROCEDURES DUE TO A LOW BATTERY DRIVING ON SLIPPERY SURFACES ACCELERATIONTRACTIONFREEING A STUCK VEHICLE TOWING A DISABLED VEHICLE With Ignition KeyWithout The Ignition KeyCONVERTIBLE TOP MANUAL OVERRIDE MAINTAINING YOUR VEHICLE 2.4L TURBO ENGINE COMPARTMENT 2.4L ENGINE
COMPARTMENT ONBOARD DIAGNOSTIC SYSTEM - OBD II Loose Fuel Filler Cap MessageEMISSIONS INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS AUTHORIZED DEALER SERVICE MAINTENANCE PROCEDURES ENGINE OILDRIVE
BELTS - CHECK CONDITION AND TENSIONSPARK PLUGSIGNITION WIRING SYSTEMCATALYTIC CONVERTERENGINE TIMING BELTCRANKCASE EMISSION CONTROL SYSTEMFUEL FILTERAIR CLEANER ELEMENT (AIR FILTER)MAINTENANCE-FREE
BATTERYAIR CONDITIONER MAINTENANCEPOWER STEERING - FLUID CHECKFRONT SUSPENSION BALL JOINTSSTEERING LINKAGEBODY LUBRICATIONWINDSHIELD WIPER BLADESWINDSHIELD WASHER RESERVOIREXHAUST SYSTEMCOOLING
SYSTEMHOSES AND VACUUM/VAPOR HARNESSESFUEL SYSTEM CONNECTIONSBRAKE SYSTEMAUTOMATIC TRANSAXLEMANUAL TRANSAXLEAPPEARANCE CARE AND PROTECTIONFROM CORROSIONCONVERTIBLE TOP CARE WashingGeneral
CleaningCloth Top Additional Cleaning ProcedureCloth Top ProtectionWeather Strip CareINTEGRATED POWER MODULE (IPM) VEHICLE STORAGE REPLACEMENT BULBS BULB REPLACEMENT HeadlightsFront Park/Turn Signal/Side Marker LightsFront Fog Lights
- If EquippedTail/Stop, and Rear Turn Signal LightsBack Up Lights Center High Mounted Stop LightFLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS ENGINECHASSISMAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM
MAINTENANCE MAINTENANCE SCHEDULE SCHEDULE B-ALL ENGINESSCHEDULE A-NON TURBOSCHEDULE A-TURBOIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For The Appointment
Prepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE DaimlerChrysler Motors Corporation Customer CenterDaimlerChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service
ContractWARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY
GRADES TreadwearTraction GradesTemperature GradesINDEX