2007 SKODA OCTAVIA TOUR fuel pump

45
CONTROLS AND EQUIPMENT

Avoid high revs and running the engine
at full load until the engine has reached its
normal operating temperature.

Do not allow the engine to idle for a
lengthy period. If the engine is running
when the car is stationary, there is not al-
ways an adequate flow of air through the
radiator. In certain circumstances, this can
result in the engine overheating and also
in engine damage.

On vehicles with a catalytic converter
the engine must not be started by tow-
ing the vehicle more than 50 m. Other-
wise, unburnt fuel can pass into the
catalytic converter and cause damage.

Before trying to start engine by tow-
ing, use the battery from another vehi-
cle for jump-starting if possible - see
page 177.
Petrol enginesThese engines are equipped with a petrol
injection system that automatically supplies
the correct fuel/air mixture at all ambient
temperatures.
The information for starting these engines
therefore applies irrespective of the outside
temperature and is the same whether the
engine is cold or at normal operating
temperature :

Do not operate throttle before and
when starting the engine.

If the engine does not start immediately,
do not operate the starter for more than 10
seconds and wait about 30 seconds before
repeating the attempt to start the engine.

If the engine is very hot, it may be nec-
essary to depress the throttle slightly after
the engine starts.

If the engine still does not start, the fuse
for the electric fuel pump may have blown -
see page 167.
Contact your Škoda Dealer in this case.
Diesel enginesGlow plug system
After switching on the Drive position (igni-
tion on), the glow warning light comes on.
Start the engine immediately after the warn-
ing light goes out.
Starting a cold engine
Ambient temperature above +5 °C:
The engine can be started immediately
without preglow. Do not operate throttle
when starting engine.
Ambient temperature below +5 °C:

Turn the key in ignition lock to position
„2“ (see page 43) - the glow warning light
comes on. It goes out after the ignition tem-
perature is reached (see page 57).
While the glow plugs are working, do not
switch on any other major electrical
components as this would place an un-
necessary load on the battery.

When the warning lamp goes out, start
the engine immediately.

127
GENERAL MAINTENANCE
Filling the tankThe fuel filler neck is inserted into the rear
right body panel.
The fuel tank holds about 55 litres.
Notes
The fuel filler flap can be opened from the
driver’s seat* - see page 65.
On this version the fuel cap cannot be
locked separately.
A sticker with data is affixed to the fuel filler
flap - see page 181.When refuelling, the filler cap can be in-
serted at the flap.
After refuelling, fit on the filler cap tight until
it is heard to click. After this, close the filler
flap.
If your car is not fitted with a remote re-
lease for the fuel filler flap at the driv-
er’s seat*, the following instructions
apply:
Use the car key to unlock the filler cap of
the fuel filler neck by turning it to the left
and unscrew it.
When refuelling, the filler cap can be in-
serted at the flap.
After refuelling, screw the filler cap tight until
it is heard to click. Lock the filler cap by
turning the key of the car to the right, with-
draw the key and close the fuel filler flap.
As soon as the petrol pump at the
filling station switches off automati-
cally for the first time after being prop- erly used, the fuel tank is „full“. Do notfill in any more petrol otherwise the ex-pansion chamber in the tank will be filled
and fuel might flow out when it warms up.
Note
Never run the fuel tank completely empty
on models fitted with a catalytic con-
verter. The irregular fuel supply may re-
sult in misfiring and uncombusted fuel
may get into the exhaust system. This
can cause overheating and damage to
the catalytic converter.
Warning
Observe any statutory regulations
when carrying a reserve canister of
fuel. For safety reasons, it is recom-
mended that you do not carry a re-
serve canister in the car. In the event
of an accident, the canister could be
damaged and fuel spillage could oc-
cur.

168DO-IT-YOURSELFFuse assignment
No. Electrical component A
1 - Mirror and spray nozzle heater,relay for cigarette lighter
el. seats ........................................ 10
2 - Turn signal lights .......................... 10
3 - Stowage compartment light ............ 5
4 - Licence plate lights ......................... 5
5 - Seat heaters, Climatronic, Navi- gation system, recirculated air
flap, multifunction steering
wheel, exterior mirror heaters ..... 7.5
6 - Central locking control unit ............. 5
7 - Reversing lights, parking aid ........ 10
8 - Mobile phone .................................. 5
9 - ABS/ESP ......................................... 5
10 - Petrol engine: control unit ............ 20
Diesel engine: control unit .............. 5No. Electrical component A
11 - Dash panel insert, selector lever
lock solenoid (automatic
gearbox) .......................................... 5
12 - Power supply for diagnosis, mobile phone ............................... 7.5
13 - Brake lights ................................... 10
14 - Interior light, central locking ......... 10
Interior light (without central
locking) ......................................... 10
15 - Instrument cluster, automatic gearbox, steering lock angle
sensor, rear-view mirrors ................ 5
16 - Air conditioning, electric water pump ............................................. 10
17 - Police .............................................. 5
18 - Right main beam .......................... 10
19 - Left main beam ............................. 10
20 - Right low beam, headlight range control ................................. 15
21 - Left low beam ............................... 15
22 - Right parking light ........................... 5
23 - Left parking light ............................. 5
24 - Wiper system, washer pump ........ 20
25 - Heater fan ..................................... 25
26 - Rear window heater ...................... 25
27 - Rear window wiper ....................... 15
28 - Fuel pump ..................................... 15
29 - Petrol engine - engine electronics, ignition ....................... 15
Diesel engine - engine
electronics .................................... 10 No. Electrical component A
30 - Power sliding/tilting roof
............... 20
31 - Automatic gearbox ........................ 20
Haldex coupling .............................. 5
32 - Petrol engine - injectors ............... 10
Diesel engine - injection pump,
control unit .................................... 30
33 - Headlight cleaning system ........... 20
34 - Petrol engine - engine electronics .................................... 10
Diesel engine - engine
electronics .................................... 10
35 - Trailer socket, socket in luggage compartment ............... 30
36 - Fog lights ...................................... 15
37 - S contact
1)................................... 10
38 - Luggage compartment light, central locking, remote fuel
filler flap release ........................... 15
39 - Hazard warning signals ................ 15
40 - Horn .............................................. 20
41 - Cigarette lighter ............................ 15
42 - Radio ............................................. 15
43 - Petrol engine: engine electronics .................................... 10
Diesel engine: engine
electronics .................................... 10
44 - Seat heaters ................................. 15
1)For electrical components which can be oper-
ated after switching off the ignition provided the
ignition key is not withdrawn, e.g. radio.

180DO-IT-YOURSELFAdditional points for the driver of the to-
wed vehicle to note during tow-starting:

Before starting to tow the car, engage
3rd or 4th gear, depress clutch pedal and
hold. The ignition should be switched on.

Once both vehicles are moving, release
the clutch pedal.

As soon as the engine has started, de-
press clutch pedal and take the car out of
gear to avoid running into the towing vehi-
cle.

If your car is fitted with a catalytic con-
verter, the engine must not be started by
towing the car over a distance of more
than 50 m (150 ft) if the catalytic con-
verter is warm otherwise uncombusted
fuel may get into the catalytic converter
and cause damage. Pay attention to the following points if
towing a car fitted with an automatic
gearbox:


Move the shift lever into position „N“.

The maximum towing speed is 50 km/h
(30 mph).

The maximum towing distance is 50 km
(30 miles)!

If the car has to be towed over a greater
distance, the front wheels should be raised
clear of the ground.
The gear oil pump does not operate when
the engine is not running; consequently, the
gearbox is not sufficiently lubricated when
running at high speeds and over lengthy
distances.

If the car is towed by a tow truck, the front
wheels should always be raised clear of the
ground.
If the rear wheels are raised clear of the
ground, the drive shafts will rotate in the
opposite direction. As a result, the gears in
the automatic gearbox will run at such high
speeds that the gearbox could suffer se-
vere damage within a short time.