2007 Lancia Musa refuelling

MUST BE READ!
REFUELLING
Petrol engines:only refuel with unleaded petrol with octane rating (RON) not less than 95.
Multijet engines:only refuel with diesel fuel conforming to the European specification EN590.
The use of other products or mixtures may irreparably damage the engine with invalidation of the
warranty due to the damage caused.
ENGINE STARTING
petrol engines:make sure that the handbrake is engaged; set the gearshift lever to neutral; fully
depress the clutch without pressing the accelerator, then turn the ignition key to AVV and release it as
soon as the engine has started.
Multijet engines:turn the ignition key to MARand wait for the instrument panel warning light Y
andmto go out, then turn the ignition key to AV Vand release it as soon as the engine starts.
PARKING ON FLAMMABLE MATERIAL
While working, the catalyst develops a very high temperature. Do not park the car over grass, dry
leaves, pine needles or any other inflammable materials: risk of fire.
RESPECTING THE ENVIRONMENT
A system for continuously monitoring emission system components to ensure greater environmental
protection is fitted in your car.

K

AT THE FILLING STATION
PETROL ENGINES
Use only unleaded petrol.
To prevent errors, the diameter of the fuel tank
filler is too small to introduce a lead petrol pump
filler. Use petrol with a rated octane number
(R.O.N.) not lower than 95.
IMPORTANT An inefficient catalyst leads to
harmful exhaust emissions, thus contributing to air
pollution.
IMPORTANT Never use leaded petrol, even in small
amount or in an emergency, as this would damage
the catalyst beyond repair.
MULTIJET ENGINES
Operation at low temperatures
If the outside temperature is very low, the diesel
thickens due to the formation of paraffin and could
cause the malfunctioning of the fuel system.In order to avoid these problems, different types of
diesel are distributed according to the season:
summer type, winter type and arctic type (cold,
mountain areas). If refuelling with diesel fuel not
suitable for the current temperature, mix diesel fuel
with TUTELA DIESEL ART additive in the
proportions stated on the can, putting first the
antifreeze in the tank and then the diesel fuel.
If driving or parking the vehicle for a long period in
cold areas/mountains, refuel with the diesel fuel
available at local filling stations.
In this situation you are also recommended to have
in the tank an amount of fuel 50% higher than
usable capacity.
REFUELLING
To guarantee full tank filling, carry out two
refuelling operations after the first click of the fuel
delivery gun. Avoid further topping up operations
that could cause damages to the fuel system.
154
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
The car must only be filled with diesel fuel for motor vehicles, in compliance with European
Standard EN590. The use of other products or mixtures may irreparably damage the engine with
invalidation of the warranty due to the damage caused. In the event of accidentally filling with
another type of fuel, do not start the engine and empty the tank. If the engine has been run even for
only a very short time, in addition to the tank, it is also necessary to drain out the whole fuel
circuit.

FUEL FILLER CAP
Fuel flap opening is interlocked to door locking/unlocking, hence, if
doors are locked, it is necessary to push on button (D).
The fuel filler cap (C) is fitted with an anti-loss device (B) which
fastens it to the flap (A) so it cannot be mislaid. To slacken the cap
(C), turn it anti-clockwise and remove it.
While refuelling, hook the plug to the device obtained inside the flap
as shown in the figure.
ATTENTION Tank airtight closure can cause a slight pressure. A
possible hiss while unscrewing the plug, is therefore absolutely
normal.
After refuelling, it is necessary to screw on the plug clockwise until
one or more clicks are felt, then turn the key clockwise, remove it and
close the flap.
155
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
L0D0125m
Do not put naked flames or lighted cigarettes near the fuel filler hole as there is
danger of fire. Do not bend too close to the hole either so as not to breathe in
harmful vapours.
WARNING
L0D0257m

219
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
WARNING
LIGHTS AND
MESSAGES
WATER IN DIESEL FUEL FILTER (Multijet versions)
The warning light on the dial turns on (together with the message on
the display) when there is water in the diesel fuel filter.
c
amber
The presence of water in the fuel circuit may cause serious damage to the entire injection system
and cause irregular engine operation. If the warning light con the dial turns on, (or, on certain
versions, a dedicated message is shown on the reconfigurable multifunction display), contact
Lancia Dealership as soon as possible to have the system relieved. If the above indications come
on immediately after refuelling, water has probably been poured into the tank: turn the engine off
immediately and contact Lancia Dealership.
Warning
light on
dial Message on
multifunction
display

DIESEL FUEL FILTER
(“green filter”)
DRAINING THE CONDENSE (Multijet versions)
IMPORTANT The presence of water in the fuel
circuit may cause serious damage to the entire
injection system and cause irregular engine
operation. If the warning light
cturns on (or oncertain versions, a dedicated message is shown on
the multifunction display) contact a Lancia
Dealership as soon as possible to have the bleeding
operation carried out.
304
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNING
The presence of water in the fuel circuit may cause serious damage to the entire
injection system and cause irregular engine operation. If the warning light
c
turns on (or on certain versions, a dedicated message is shown on the
reconfigurable multifunction display) contact a Lancia Dealership as soon as
possible to have the bleeding operation carried out. Should the above indications
take place after refuelling, water has probably been poured into the tank: turn the
engine off immediately and contact a Lancia Dealership.