2007 ISUZU KB P190 oil capacity

7B-2 MSG MODEL
MAIN DATA AND SPECIFICATIONS
Transmission type Fully synchronized 5-forward gears with a constant
mesh type reverse gear.

Transmission Control Direct control with the gear shift lever on the floor.

Gear ratio MSG5K
1st : 4.122
2nd : 2.493
3rd : 1.504
4th : 1.000
5th : 0.855
Rev : 3.720

Oil capacity lit. (US gal.) 1.55(0.41)

W eight ; approx. kg(lbs) 33.3(73.8)




BACK TO CHAPTER INDEX
TO MODEL INDEX
ISUZU KB P190 2007

MANUAL TRANSMISSION 7B1-47
Main Data and Specifications
General Specifications
MUA 5G MUA 5H MUA 5S
Transmission type Fully synchronized forward and reverse gears
Control method Remote control with the gear shift lever on the floor.
Gear ratio: Transmission 1st 4.008 4.008 4.357
2nd 2.301 2.301 2.502
3rd 1.427 1.427 1.501
4th 1.000 1.000 1.000
5th 0.828 0.744 0.809
Rev. 3.651 3.651 3.970
Transmission oil capacity 2.95 lit. (3.12 US qt)
Type of lubricant Engine oil: Refer to the chart in "SECTION 0"


BACK TO CHAPTER INDEX
TO MODEL INDEX
ISUZU KB P190 2007

MANUAL TRANSMISSION 7B1-101
Main Data and Specifications
General Specifications

MUA5G MUA5H MUA5S
Transmission type Fully synchronized forward and reverse gears
Control method Remote control with the gear shift lever on the floor.
Gear ratio: Transmission 1st 4.008 4.008 4.357
2nd 2.301 2.301 2.502
3rd 1.427 1.427 1.501
4th 1.000 1.000 1.000
5th 0.828 0.744 0.809
Rev. 3.651 3.651 3.970
Transmission oil capacity 2.95 lit. (3.12 US qt)
Type of lubricant Engine oil: Refer to the chart in "SECTION 0"


BACK TO CHAPTER INDEX
TO MODEL INDEX
ISUZU KB P190 2007

Manual Transmission (MUX) 7B1-5
Main Specifications
Walking or Jumping Out of Gear Change lever sliding portion wornand excessive playReplace worn parts
Shift rod and/or quadrant box
sliding faces worn Replace worn parts
Shift arm and synchronizer sleeve
groove worn Replace worn parts
Collar and/or gear thrust faces worn
(Input shaft and counter shaft thrust
play) Replace worn parts
Bearing worn or broken (Input shaft,
counter shaft, and individual gears) Replace bearing(s)
Input shaft spline, output shaft
spline, and synchronizer clutch hub
splines worn Replace input shaft, output shaft,
and synchronizer clutch hub
Synchronizer parts worn or broken Replace worn or broken parts
Taper bolt slack Replace taper bolt
Oil Leakage Oil level too high Drain oil to correct level Improper lubricant Replace lubricant
Drain plug and/or filler plug loose Tighten plug and replenish lubricant
Defective or improperly installed
gasket (s) Replace gasket(s)
Front oil seal worn or scratched Replace oil seal
Rear oil seal worn or scratched Replace oil seal
Model MUX5S
Transmission Type Fully synchronized forward and reverse gears
Control method Remote control with the gear shift lever on the floor
Gear ratio 1st 4.326
2nd 2.557
3rd 1.490
4th 1.000
5th 0.790
Revese 3.942
Transmission oil capacity 3.0 lit. (3.17 US qt)
Type of lubricant BESCO TRANS AXLE OIL (5W-30 SF)
Condition
Possible Cause Correction

BACK TO CHAPTER INDEX
TO MODEL INDEX
ISUZU KB P190 2007

TRANSFER CASE 7D-41
Main Data and Specifications
General Specifications
Type Synchronized type gears shifting between the 2 and 4 wheel drive mode.
Planetary type gears shifting between “low" and “high".
Control method Remote control with the button switch on the instrument panel for gears
shifting among “2H", “4H" and “4L".
Gear ratio High; 1.000
Low; 2.482
Oil capacity 1.3 lit. (1.37 US qt)
Type of lubricant BESCO GEAR OIL TRANSAXLE (5W -30)
Refer to Section 0B

Torque Specifications
N⋅m (kgf ⋅m/lb ⋅ft)



RTW 67DLF000201


BACK TO CHAPTER INDEX
TO MODEL INDEX
ISUZU KB P190 2007

ELECTRICAL-BODY AND CHASSIS 8A-33
FUSE LOCATION


RHD/LHD

FUSE
NO. Capacity Indication on label NO. Capacity Indication on label
C 1 10A STARTER C 1110A AUDIO
C2
  C
12 20A CIGAR/ACC SOCKET
10A TRAILER *3 C 13 15A AUDIO (+B)
C3 10A ELEC IG C 14 10A METER
C4 10A TURN C 15 15A STOP
C5 10A ABS/4WD C 16
 
C6 10A ENGINE C 17 10A ROOM
10A ECU *4 C19 10A METER (+B)
C7 15A TCM/IG COIL/ C2 120A DOOR LOCK
10A GLOW ENGINE *4 C22
 
C8 10A SRS 10A ANTI THEFT *5
C9 20A FRT WIPER
C10 15A BACKUP

SLOW BLOW FUSE
NO. Capacity Indication on label
C 18 20A RR DEF
C20 30A POWER WINDOW

FUSE BOX
*3 … HFV6 (AUSTRALIA)
*4 … HFV6
*5 … 4JJ 1-TC (EUROPE)



BACK TO CHAPTER INDEX
TO MODEL INDEXISUZU KB P190 2007