2007 DODGE SPRINTER air conditioning

240 OperationMaintenance and servicing
4
Vehicles without steering wheel buttons
\1Press the menu button on the in-
strument cluster repeatedly until you
see the following in the display:
\49 for service A
\4´ for service B
The following are also shown, depend-
ing on the style of driving:
\4the remaining distance in miles (kilo-
meters)
\4the remaining time in daysAn increased amount of sand or dust may
collect in the air cleaner when you drive on
dusty or sandy roads.
Air cleaner in the roof in the rear compart-
ment1Cover
2RecessesFor this reason, check the air cleaner reg-
ularly for visible damage.
Removing the air cleaner element
\1Carefully pry cover1 out of
recesses2 and remove it.
\1Remove the filter mat.
Cleaning the filter mat
\1Wash the filter mat with clean water.
\1Leave the filter mat to dry.
Installing the air cleaner element
\1Insert the filter mat.
\1Attach cover1.Air cleaner for the air-conditioning
system in the rear compartment*!
CAUTION
You must clean visible dirt from the air
cleaner or replace it if necessary. The
dirt can otherwise damage the air con-
ditioning, which is not covered by war-
ranty.
!
CAUTION
The filter mat must not be cleaned or
dried in a machine.

348 Practical hintsFuses
5
Preliminary fuse box in the battery recess in
the driver’s footwell F59
The fuse box is located in the base of the
driver’s seat on the outboard side.
1Latching springs
\1To open: adjust the seat to its highest
position (\2page 69).
\1Press both latching springs1 down
and remove the cover.
\1To close: attach the cover at the bot-
tom and fold it closed.
The cover must engage.
No.
Consumer
Amp.
15
Non MB-body electrics
10 A
16
Heating, rear heating/
Tempmatic (air-conditioning
system), front/CD-player*
10 A
17
Motion detector*/con-
venience interior lighting*/
satellite radio*
10 A
18
Air conditioning in the rear*
7.5 A
No.
Consumer
Amp.
1
Pre-glow relay/secondary
air pump
80/40 A
2
Engine fan air-conditio-
ning system
80 A
3
Signal acquisition and ac-
tuation module SAM/fuse
and relay block SRB
80 A
4
Auxiliary battery* in the
engine compartment
150 A
5
T erm in al 30 f us e bo xe s, si-
gnal acquisition and actu-
ation module SAM/fuse
and relay block SRB
150 A
6
Connecting point in
driver’s seat base
Brücke
7
Heater booster (PTC)
150 A
Fuse box in the driver’s seat
N54.15-2149-31

350 Practical hints
5
No.
Consumer
Amp.
1
Mirror adjustment*
5A
2
Rear window wiper*
30 A
3
Reversing camera*/
telephone*
5A
4
Operating speed governor
(ADR)/PTO/trailer
connection unit AAG
7.5 A
5
Terminal 87 electronic
transmission control ETC,
control unit
10 A
6
Unassigned
–
7
Electronic selector level
module ESM
7.5/15 A
8
Terminal 15 body builder,
drop side/3-way tipper
10 A
9
Roof ventilator*/audio
signal equipment*
15 A
10
Terminal 30, tapping wire
body builder
25 A
11
Terminal 15, tapping wire
body builder
15 A
12
D+, tapping wire body
builder
10 A
No.
Consumer
Amp.
13
Auxiliary indication
modul 1
10 A
14
Trailer socket*
20 A
15
Trailer recognition device*
25 A
16
Tir pressure monitoring
system (TPMS)*/
Parktronic system (PTS)*
7.5 A
17
PSM control unit*
25 A
18
PSM control unit*
25 A
19
Overhead control panel*/
sliding sunroof*
5/25 A
20
Clearance lamps*
7.5 A
21
Rear window heating*
30/15 A
22
Rear window heating* 2
15 A
23
12V socket* rear left,
load/passenger compart-
ment
15 A
24
12V socket driver’s seat
base
15 A
25
12V socket rear right,
load/passenger compart-
ment/Auxiliary heating*
blower speed 1
15 A
No.
Consumer
Amp.
26
Auxiliary heating*
25 A
27
Heater booster*
25/20 A
28
Air conditioning
in the rear*
30 A
29
Unassigned
–
30
Unassigned
–
31
Blower unit, rear heating*
30 A
32
Unassigned
–
33
Electric sliding door*,
right
30 A
34
Electric sliding door*, left
30 A
35
Brake booster*
30 A
36
Unassigned
–
Fuses

362 *Technical dataService products and capacities
6
Coolants, lubricants, etc.
Service
interval
Product name/product number
MB
sheet
MS-
No.
1
Air conditioning
The air conditioning system of your vehicle contains R-134a, a refrigerant that does not deplete the ozone layer in the upper atmo-
sphere.Refrigerant R-134a
—
Refrigerant R-134a
361.0
Automatic transmissionAutomatic transmission fluid
10 years
60,000 mi
(96,000 km)
MOPAR
® 05127382AB
Shell ATF 3403
Shell ATF 3353
236.10
236.12
BrakesUse brake fluid approved for DaimlerChrysler standard MB 331.0 and/or DaimlerChrysler material standard MS-9971, brake fluid certified
to DOT 4 Plus standards, that also maintains a minimum dry boiling point (ERBP) of 500 °F (260°C), a minimum wet boiling point (WERBP)
of 356 °F (180 °C) and a maximum viscosity of 1500 mm
2/s, conforming to FMVSS 116 and ISO 4925.
Brake fluid
2 years
2
Intac B026E Dry boiling point: 500°F (260°C)
Wet boiling point: 356°F (180°C)
MOPAR
® MS-9971 Part No. 04549625AC or equivalent
331.0
9971
1 DaimlerChrysler Material Standard-No.
2 Over the course of a brake fluid’s service life, its boiling point falls due to the continuous absorption of moisture from the atmosphere. If the boiling point of the
brake fluid is too low, vapor pockets may form in the brake system when the brakes are applied hard (e.g. when driving on long downhill stretches). This has a det-
rimental effect on braking efficiency, which could increase the stopping distance. This increases the risk of an accident. Have the brake fluid renewed every 2 years.

377
Numerics
12 V socket
. . . . . . . . . . . . . . . . . . . 170
A
ABS
see Antilock Brake System
Acceleration skid control (ASR)
. . . 44
activating/deactivating
. . . . . . . . . . 45
display message
. . . . . . . . . . . . . . 291
indicator lamp
. . . . . . . . . . . . 268
–270
malfunction
. . . . . . . . . . . . . . . . . . 270
warning lamp . . . . . . . . . . . . . . 44
, 268
Accessory weight
. . . . . . . . . . . . . . 228
Accident
. . . . . . . . . . . . . . . . . . . . . . 251
Additional turn signal lamp
. . . . . . 307
ADR
see Operating speed governor
Air conditioning in the rear . . . . . . 136
Air conditioning, regulated
refrigerant
. . . . . . . . . . . . . . . . . . . 362
Air pressure
see Tire inflation pressure
Air vents
air distribution
. . . . . . . . . . . . . . . . 133
in the rear
. . . . . . . . . . . . . . . . . . . 137
Airbag
co-driver's . . . . . . . . . . . . . . . . . . . . 33driver's
. . . . . . . . . . . . . . . . . . . . . . . 33
safety notes
. . . . . . . . . . . . . . . . . . . 31
thorax sidebag . . . . . . . . . . . . . . . . . 34
windowbag
. . . . . . . . . . . . . . . . . . . . 35
Air-conditioning system
see Tempmatic
Air-conditioning system in the rear
compartment
air cleaner . . . . . . . . . . . . . . . . . . . 240
Air-recirculation mode
air conditioning in the rear
. . . . . . . 136
rear heating
. . . . . . . . . . . . . . . . . . 136
Tempmatic . . . . . . . . . . . . . . . . . . . 133
Alarm
audible
. . . . . . . . . . . . . . . . . . . . . . 250
Anticorrosion/antifreeze fluid
. . . 363
Antilock Brake System (ABS)
. . . . . 42
display message
. . . . . . . . . . . . . . 285
indicator lamp
. . . . . . . 268
, 269
, 271
malfunction
. . . . . . . . . . . . . . . . . . 271
Anti-theft alarm system (ATA)
. . . . . 47
malfunction
. . . . . . . . . . . . . . . . . . 250
switching off the alarm
. . . . . . . . . . 47
Anti-theft system
immobilizer
. . . . . . . . . . . . . . . . . . . 47
see Anti-theft alarm
system (ATA)
Aquaplaning
see HydroplaningArmrest
. . . . . . . . . . . . . . . . . . . . . . . 72
Ashtray . . . . . . . . . . . . . . . . . . . . . . . 168
Aspect ratio
. . . . . . . . . . . . . . . . . . . 228
ASR
see Acceleration skid control
ASSYST
. . . . . . . . . . . . . . . . . . . . . . . 238
calling up the due date
vehicles with steering wheel
buttons
. . . . . . . . . . . . . . . . . . . . 239
vehicles without steering wheel but-
tons
. . . . . . . . . . . . . . . . . . . . . . 240
Attaching lashing straps
. . . . . . . . 158
Attaching locking rods
. . . . . . . . . . 158
Audible alarm
. . . . . . . . . . . . . . . . . 250
Automatic car wash
. . . . . . . . . . . . 242
headlamps
. . . . . . . . . . . . . . . . . . . 193
windshield . . . . . . . . . . . . . . . . . . . 193
Automatic headlamp control
. . . . . . 78
Automatic locking
. . . . . . . . . . . . . . . 64
entire vehicle
. . . . . . . . . . . . . . . . . . 65
rear doors
. . . . . . . . . . . . . . . . . . . . 65
Automatic transmission
. . . . . . . . . 121
accelerator pedal position . . . . . . . 123
changing gear yourself
. . . . . . . . . . 122
driving tips
. . . . . . . . . . . . . . . . . . . 123
fluid
. . . . . . . . . . . . . . . . . . . . . . . . 362
gearshift pattern
. . . . . . . . . . . . . . 121
kickdown
. . . . . . . . . . . . . . . . . . . . 123
malfunctions
. . . . . . . . . . . . . . . . . 256
Index
A