2006 HONDA INSIGHT maintenance schedule

Insert the dipstick all the way back
into the transmission securely as
shown in the illustration. If you
added f luid, return to step 1 to
recheck the f luid level.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your dealer. Check the f luid level with the
transmission at normal operating
temperature and the vehicle sitting
on the level ground.
Remove the black cover under the
engine.Remove the transmission f iller bolt,
and caref ully f eel inside the bolt hole
with your f inger. The f luid level
should be up to the edge of the bolt
hole. If it is not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Reinstall
the f iller bolt and tighten it securely.
To thoroughly f lush the transmission,
the technician should drain and ref ill
it with Honda CVT f luid, then drive
the vehicle f or a short distance. Do
this three times. Then drain and
ref ill the transmission a f inal time.
6.
CONT INUED
T ransmission Fluid
Manual Transmission
Maint enance
143
Correct Level

If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives, and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to check and
add f luid, contact your dealer.Check the brake f luid level in the
reservoirs monthly.
Replace the brake f luid according to
the recommendation in the
maintenance schedule.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.
Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Transmission Fluid, Brake and Clutch Fluid
Brake and Clutch Fluid
144

Beforeusinganautomaticcarwash,
remove the radio antenna so it does
not get damaged. Remove the
antenna by unscrewing it. When you
reinstall the antenna, tighten it
securely.
The dust and pollen f ilter removes
pollen and dust f rom the outside air
the climate control system brings
into the interior. It should be
replaced according to the time and
distance recommendations in the
maintenance schedule.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if airf low f rom the
climate control system becomes less
than usual. Have the dust and pollen
f ilter replaced by your dealer.Roof A ntenna
Dust and Pollen Filter
Dust and Pollen Filter, Roof A ntenna
152

If you need to park your vehicle f or
an extended period (more than 1
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors.Fill the f uel tank.
Change the engine oil and f ilter.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
Leave the parking brake off. Put
the transmission in Reverse
(manual) or Park (CVT).
Block the rear wheels. If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the vehicle is being stored
indoors).
Disconnect the 12 volt battery.
Support the f ront and rear wiper
blade arms with a f olded towel or
ragsotheydonottouchthe
windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and hatch seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and hatch seals.
If you store your vehicle f or 1 year or
longer, have your dealer perf orm the
inspections called f or in the 2 years/
30,000 miles (48,000 km)
maintenance schedule (Normal
Conditions) as soon as you take it
out of storage (see page ). The
replacements called f or in the
maintenance schedule are not
needed unless the vehicle has
actually reached that time or mileage.Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
Reconnect the 12 volt battery and
drive your vehicle every month f or
about 30 minutes. This will keep
the IMA battery charged and in
good condition.
129
Vehicle Storage
Maint enance
163

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons.
Controlling the production of NOx,
CO, and HC is important to the
environment. Under certain
conditions of sunlight and climate,
NOx and HC react to f orm
photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive crankcase ventilation valve routes
them from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
129
Emissions Cont rols
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Technical Inf ormation
199

CONT INUED
.................
Jacking up the Vehicle . 169
.......................................
Jack, Tire .167
................................
Jump Starting .175
..................................................
Keys .59
.....
Octane Requirement, Gasoline . 94
.........................................
Odometer .49
...............................
Odometer, Trip .50
Oil ........................
Change, How to .136
......................
Change, When to .129
........................
Checking Engine .97
..............
Pressure Indicator . 44,179
Selecting Proper Viscosity ......................................
Chart .136
...........
ON (Ignition Key Position) . 61
Onboard Ref ueling Vapor ....................................
Recovery .199
.........................
Opening the Hatch .63
..............................
Outside Mirrors .68
..................................
Maintenance .125
Owner’s Maintenance ...................................
Checks .128
........................................
Record .131
......................
Required Indicator .47
..........................................
Saf ety .126
....................................
Schedule .127
.......
Malf unction Indicator Lamp . 180
...................
Manual Transmission . 110
...............
Checking Fluid Level . 143
................................
Shif ting the .110
........
Manual Transmission Fluid . 143
.........................
Meters, Gauges .43, 48
..........................
Mirrors, Adjusting .68
...............
Modif ying Your Vehicle . 101...................
Neutral Gear Position . 114
....................
New Vehicle Break-in .94
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 192
.......................
Label, Certif ication .192
.................
Lane Change, Signaling . 56
....................
Lap/Shoulder Belt .14, 18
....................
Lif etime Fuel Mileage . 51
Lights ....................
Bulb Replacement .146
.....................................
Indicators .44
.........................................
Parking .56
..................................
Turn Signal .56
.....................................
Load Limit .103
......
LOCK (Ignition Key Position) . 61
Locks .......
Anti-thef t Steering Column . 61
..............................
Fuel Fill Door .95 ............................................
Hatch .63
.................................
Power Door .62
..........................
Low Coolant Level .98
.........................
Low Fuel Indicator .46
...
Lower Gear, Downshif ting to a . 110
...
Low Oil Pressure Indicator . 44,179
...
Lubricant Specif ications Chart . 194
...........
Luggage, Storing (Cargo) . 102
Index
M N
O
J
K
L
INDEX
V

Î
....................
Overheating, Engine .177
....
Owner’s Maintenance Checks . 128
...........................
Oxygenated Fuels .94
..............
Panel Brightness Control . 57
........................
Park Gear Position .114
...........................................
Parking .120
.................................
Parking Brake .69
Parking Brake and Brake .................
System Indicator . 45,182
.................................
Parking Lights .56
..
Parking Over Things that Burn . 120
............................
Playing the Radio .80
....................................
Playing a CD .85
.............................
PGM-FI System .200
..................
Power Socket Location . 70
..............................
Power Windows .67
.........
Pregnancy, Using Seat Belts . 16
.........
Protecting Adults and Teens . 12
...
Additional Safety Precautions . 17
.....
Advice f or Pregnant Women . 16
........................
Protecting Children .25
.....................
General Guidelines .25 Using Child Seats with
.....................................
Tethers .33
...........
Protecting Larger Children . 34
.............
Protecting Small Children . 29
...................
Radiator Overheating . 177
...............
Radio/CD Sound System . 80
...........................
Readiness Codes .202
..
Rear Lights, Bulb Replacement . 149
............................
Rear View Mirror .68
.................
Rear Window Def ogger . 58
....................
Rear Window Washer .55
.......................
Rear Window Wiper .55
...............
Reclining the Seat Backs . 66
.............................
Reminder Lights .44
.......................
Remote Transmitter .64
Replacement Inf ormation ..............
Dust and Pollen Filter . 152
................
Engine Oil and Filter . 136
.................................
Floor Mats .151
..........................................
Fuses .185
................................
Light Bulbs .146
....................................
Schedule .129
...................................
Seat Belts .151 ...........................................
Tires .159
.............................
Wiper Blades .153
Replacing Seat Belts Af ter a ............................................
Crash .19
Reserve Tank, Engine .................................
Coolant .98, 139
...............................
Restraint, Child .25
..................
Reverse Gear Position . 114
................................
Roof Antenna .152
................................
Rotation, Tire .159
................................
Saf ety Belts .10, 18
.........
Safety Defects, Reporting . 206
.................................
Saf ety Features .9
.........................................
Airbags .11
.....................................
Seat Belts .10
.............
Saf ety Labels, Location of . 39
...............................
Saf ety Messages . ii
Index
P
R
S
VI