2005 NISSAN X-TRAIL fuel pressure

PG-66
HARNESS

ESP BRC ESP/TCS/ABS Control System
ETC1 EC Electric Throttle Control Function
ETC2 EC Electric Throttle Control Motor Relay
ETC3 EC Electric Throttle Control Motor
F/FOG LT Front Fog Lamp
F/PUMP EC Fuel Pump
FIAR EC Fuel Injector Adjustment Resistor
FRO2 EC Front Heated Oxygen Sensor
FRO2/H EC Front Heated Oxygen Sensor Heater
FRPS EC Fuel Rail Pressure Sensor
FTP EC Fuel Transport Pump
FTS AT A/T Fluid Temperature Sensor Circuit
FTS EC Fuel Temperature Sensor
FUEL EC Fuel Injection System Function
GLORLY EC Glow Relay
GLOW EC Glow Control System
H/AIM LT Headlamp Aiming Control System
H/LAMP LT Headlamp
HEATER MTC Heater System
HLC WW Headlamp Cleaner
HO2S1 EC Heated Oxygen Sensor 1
HO2S1H EC Heated Oxygen Sensor 1 Heater
HO2S2 EC Heated Oxygen Sensor 2
HO2S2H EC Heated Oxygen Sensor 2 Heater
HORN WW Horn
HSEAT SE Heated Seat
IATS EC Intake Air Temperature Sensor
IATSEN EC Intake Air Temperature Sensor
IGNSYS EC Ignition System
ILL LT Illumination
INJ/PW EC Fuel Injector Power Supply Circuit
INJECT EC Fuel Injector
INT/L LT Map Lamp
IVC EC Intake Valve Timing Control Solenoid Valve
KS EC Knock Sensor
LOAD EC Electrical Load Signal
LPSV AT Line Pressure Solenoid Valve
MAFS EC Mass Air Flow Sensor
MAIN AT Main Power Supply and Ground Circuit
MAIN EC Main Power Supply and Ground Circuit
METER DI Speedometer, Tachometer, Temp. and Fuel Gauges
MIL/DL EC MIL & Data Link Connector
MIRROR GW Door Mirror
MULTI BL Multi-Remote Control SystemCode Section Wiring Diagram Name

MA-4
DESCRIPTION

DESCRIPTIONPFP:00000
Pre-Delivery Inspection ItemsELS000Y5
Shown below are Pre-delivery Inspection Items required for the new vehicle. It is recommended that
necessary items other than those listed here be added, paying due regard to the conditions in each
country.
Perform applicable items on each model. Consult text of this section for specifications.
Install vehicle protection kit
Fit all accessories ordered (if applicable) (e.g. towbar, audio, navigation, air conditioner, styling kit)
UNDER HOOD — engine off
Check coolant level and cooling system for leaks
Charge battery and check terminals for condition
Check drive belts tension (diesel only)
Check fuel filter for water or dust (diesel only) and fuel system for leaks
Check engine oil level and for oil leaks
Check brake and clutch fluid levels and fluid lines for leaks
Check and top up washer reservoirs
Check power steering fluid level and fluid lines for leaks (if applicable)
Check air conditioning system for gas leaks (if applicable)
ON INSIDE AND OUTSIDE
Install transit fuse if removed for vehicle storage
Check instruments, gauges, lamps, horn and accessories for operation
Check wipers and washers for operation and adjustment
Check interior and door mirrors and sun visors for operation
Set radio code and set clock
Check parking brake adjustment
Check clutch pedal adjustment
Check steering lock operation
Check seat adjusters and seat belts for operation
Check all windows for operation and alignment
Check mouldings, trim and fittings for fit and alignment
Check weatherstrips for fit and adhesion
Check hood, trunk lid, door panels and fuel lid for fit and alignment
Check latches, keys, remote key, door locks and remote trunk lid and fuel lid release for operation
Check wheel nut torques
Check tyre pressure (incl. spare tyre)
Check tool kit and jack for operation
Check automatic transmission/transaxle starter inhibitor (if applicable)
Check sunroof for operation and alignment (if applicable)
UNDER BODY
Check manual transmission/transaxle, differential and transfer box for oil level and oil leaks
Tighten bolts and nuts steering linkage and gear box, axle/suspension parts, propeller and exhaust system
Check brake and clutch lines, and oil/fluid reservoirs for leaks
Remove front suspension spacer blocks (if applicable)
Check body mounting torque (if applicable)

MA-6
GENERAL MAINTENANCE

GENERAL MAINTENANCEPFP:00000
General MaintenanceELS000AL
General maintenance includes those items which should be checked during the normal day-to-day operation
of the vehicle. They are essential if the vehicle is to continue operating properly. The owners can perform the
checks and inspections themselves or they can have their NISSAN dealers do them for a nominal charge.
OUTSIDE THE VEHICLE
The maintenance items listed here should be performed from time to time, unless otherwise specified.
INSIDE THE VEHICLE
The maintenance items listed here should be checked on a regular basis, such as when performing periodic maintenance, cleaning the
vehicle, etc.
UNDER THE HOOD AND VEHICLE
The maintenance items listed here should be checked periodically e.g. each time you check the engine oil or refuel.Item Reference page
TiresCheck the pressure with a gauge periodically when at a service station, includ-
ing the spare, and adjust to the specified pressure if necessary. Check carefully
for damage, cuts or excessive wear.—
Windshield wiper
bladesCheck for cracks or wear if not functioning correctly. —
Doors and engine
hoodCheck that all doors, the engine hood, the trunk lid and back door operate prop-
erly. Also ensure that all latches lock securely. Lubricate if necessary. Make sure
that the secondary latch keeps the hood from opening when the primary latch is
released.
When driving in areas using road salt or other corrosive materials, check for
lubrication frequently.BL-12
, BL-18
Tire rotationTires should be rotated every 10,000 km (6,000 miles) for 2WD models and
every 5,000 km (3,000 miles) for 4WD models.MA-43
Item Reference page
LampsMake sure that the headlamps, stop lamps, tail lamps, turn signal lamps, and
other lamps are all operating properly and installed securely. Also check head-
lamp aim.—
Warning lamps and
chimesMake sure that all warning lamps and buzzers/chimes are operating properly. —
Steering wheelCheck that it has the specified play.
Check for changes in the steering conditions, such as excessive free play, hard
steering or strange noises.
Free play: Less than 35 mm (1.38 in)—
Seat beltsCheck that all parts of the seat belt system (e.g. buckles, anchors, adjusters and
retractors) operate properly and smoothly, and are installed securely. Check the
belt webbing for cuts, fraying, wear or damage.MA-47
Item Reference page
Windshield washer
fluidCheck that there is adequate fluid in the tank. —
Engine coolant levelCheck the coolant level when the engine is cold.MA-20
(QR20DE,
QR25DE)
MA-30
(YD22DDTi)
Engine oil levelCheck the level after parking the vehicle on a level spot and turning off the
engine.MA-24
(QR20DE,
QR25DE)
MA-35
(YD22DDTi)
Brake and clutch fluid
levelsMake sure that the brake and clutch fluid levels are between the “MAX” and
“MIN” lines on the reservoir.MA-39
, MA-44
BatteryCheck the fluid level in each cell. It should be between the “MAX” and “MIN”
lines.—

IDX-5
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
Fork rod (M/T) ....................................... MT-25, MT-43
Freeze frame data EC-56, EC-566, EC-999, EC-1373
FRO2 - Wiring diagram ...................... EC-847, EC-862
Front bumper ....................................................... EI-14
Front disc brake ................................................. BR-27
Front door ........................................................... BL-18
Front Door Trim ................................................... EI-32
Front fog lamp .................................................. LT-108
Front passenger air bag .................................. SRS-35
Front seat .......................................................... SE-24
Front seat belt ...................................................... SB-3
Front seat belt pre-tensioner .... SB-2, SRS-3, SRS-40
Front side air bag ............................................. SRS-37
Front suspension ............................................... FSU-5
Front washer ...................................................... WW-4
Front wiper ......................................................... WW-4
FRPS - Wiring diagram .................. EC-1111, EC-1467
FTS - Wiring diagram .................... EC-1107, EC-1463
FUEL - Wiring diagram ...................... EC-221, EC-227
Fuel check valve ................................ EC-522, EC-962
Fuel cut control (at no load high engine speed) EC-38,
EC-551
, EC-988, EC-1364
Fuel filler lid ...................................................... BL-103
Fuel filter .......................................... EC-994, EC-1370
Fuel filter replacement(QR20DE-QR25DE) .......... FL-4
Fuel filter replacement(YD22DDTi) ....... FL-17, MA-34
Fuel gauge ............................................................ DI-4
Fuel injection control system ........... EC-986, EC-1362
Fuel injection system ......................... EC-219, EC-225
Fuel injector adjustment resistor .... EC-1251, EC-1590
Fuel injector and fuel tube(QR20DE-QR25DE) . EM-34
Fuel injector and fuel tube(YD22DDTi) ............ EM-167
Fuel line inspection(QR20DE-QR25DE) . FL-3, MA-24
Fuel line inspection(YD22DDTi) ............ FL-16, MA-34
Fuel pressure check ............................ EC-49, EC-562
Fuel pressure release .......................... EC-49, EC-562
Fuel pump .......... EC-466, EC-906, EC-994, EC-1263,
EC-1602
Fuel pump and gauge(QR20DE-QR25DE) .......... FL-4
Fuel rail pressure sensor ............... EC-1110, EC-1466
Fuel system(QR20DE-QR25DE) .......................... FL-3
Fuel system(YD22DDTi) ..................................... FL-16
Fuel tank(QR20DE-QR25DE) ............................ FL-11
Fuel tank(YD22DDTi) ......................................... FL-23
Fuel temperature sensor ............... EC-1106, EC-1462
Fuse ................................................................... PG-12
Fuse and fusible link box ................................... PG-80
Fusible link ......................................................... PG-12
G
Gauges ................................................................. DI-4
Gear components (M/T) ....................... MT-23, MT-41
Generator .......................................................... SC-13
Generator - See Alternator ................................ SC-13
Generic scan tool (GST) .................. EC-113, EC-1040
Glass .................................................. GW-80, GW-83
GLOW - Wiring diagram EC-1183, EC-1306, EC-1644
Glow plug ....................................... EC-1305, EC-1643
Glow plug(YD22DDTi) .................................... EM-162
Glow relay ..................... EC-1182, EC-1305, EC-1643
Grille - See Exterior ............................................ EI-19
Ground distribution ............................................ PG-13
H
H/LAMP - Wiring diagram ......................... LT-9
, LT-28
H/MIRROR - Wiring diagram ............................ GW-21
Harness connector ............................................. PG-74
Harness layout ................................................... PG-32
Headlamp ............................................................. LT-5
Headlamp aiming control .................................... LT-66
Headlamp washer ............................................ WW-20
Headlining - See Roof trim .................................. EI-39
Heated oxygen sensor 1 .... EC-179, EC-186, EC-196,
EC-322
, EC-328, EC-666, EC-673, EC-861
Heated oxygen sensor 1 heater ......... EC-139, EC-846
Heated oxygen sensor 2 .... EC-204, EC-211, EC-334,
EC-342
, EC-867
Heated oxygen sensor 2 heater ......... EC-145, EC-851
Heated seat ........................................... SE-18, SE-21
HEATER - Wiring diagram ................................ MTC-6
Heater and cooling unit (Heater core) ............ ATC-131
Heater mirror ..................................................... GW-21
Heater system - Wiring diagram ....................... MTC-6
Heater unit (heater core) .. ATC-136, MTC-27, MTC-30
HFC134a (R134a) system precaution ............... ATC-4
HFC134a (R134a) system service procedure ATC-141
HFC134a (R134a) system service tools .......... ATC-15
HFC134a system service equipment precaution ..........
ATC-10
HO2S1 - Wiring diaram ...... EC-181, EC-189, EC-199,
EC-668
, EC-675
HO2S1H - Wiring diagram ............................... EC-141
HO2S2 - Wiring diagram .... EC-206, EC-214, EC-337,
EC-345
HO2S2H - Wiring diagram ............................... EC-147
Hood .................................................................. BL-12
Horn ................................................................. WW-27
HORN - Wiring diagram ................................... WW-27
How to erase DTC ........................... EC-566, EC-1372
How to erase DTC for OBD system ..... EC-63, EC-999
I
IATS - Wiring diagram .... EC-161
, EC-1089, EC-1445
IATSEN - Wiring diagram ................................ EC-857
Identification ...................................... ATC-12, ATC-13
Idle air volume learning ........................ EC-47, EC-560
Idle speed ........... EC-79, EC-578, EC-1012, EC-1382
Ignition coil ......................................... EC-440, EC-873
Ignition coil(QR20DE-QR25DE) ....................... EM-31
Ignition control system ....................... EC-440, EC-873
Ignition timing ....................................... EC-79, EC-578
IGNSYS - Wiring diagram .................. EC-441, EC-874
ILL - Wiring diagram ......................................... LT-122
Illumination ........................................................ LT-122
In vehicle sensor ........... ATC-111, ATC-113, ATC-122

IDX-6
ALPHABETICAL INDEX
INJE/PW - Wiring diagram ............. EC-1294, EC-1632
INJECT - Wiring diagram . EC-452, EC-892, EC-1120,
EC-1259
, EC-1298, EC-1476, EC-1598, EC-1636
Injection nozzle(YD22DDTi) ........................... EM-167
Injector ............................................... EC-451, EC-891
Input shaft (FF M/T) .............................. MT-23, MT-41
Intake air temperature sensor ........... EC-159, EC-856,
EC-1088
, EC-1443
Intake door control linkage adjustment ............ ATC-81
Intake door motor ATC-79, ATC-128, MTC-11, MTC-26
Intake manifold(QR20DE-QR25DE) ................. EM-18
Intake manifold(YD22DDTi) ............................ EM-146
Intake sensor ................................................. ATC-117
Intake valve timing control ................. EC-136, EC-636
Intake valve timing control solenoid valve ....... EC-290
Interior ....................... EI-32, EI-34, EI-35, EI-38, EI-39
Interior lamp ...................................................... LT-132
Interior lamp on-off control .................. LT-132, LT-133
ISO 15031-5 Mode 1 - 9 ...................... EC-52, EC-996
IVC - Wiring diagram ....................................... EC-291
J
Joint connector (J/C) .......................................... PG-79
K
Keyless entry system - See Multi-remote control system
BL-74
Knock sensor (KS) ............................. EC-245, EC-688
KS - Wiring diagram ........................... EC-246, EC-689
L
LAN system circuit ........................................... ATC-69
License lamp ..................................................... LT-103
Line pressure test (A/T) ....................... AT-68, AT-260
Liquid gasket application ......................... LU-3, LU-17
Liquid gasket application(QR20DE-QR25DE) ... EM-6,
CO-3
Liquid gasket application(YD22DDTi) . EM-131, CO-26
LOAD - Wiring diagram ...................... EC-481, EC-921
Location of electrical units ................................. PG-69
Lock, door ............................................... BL-91, BL-95
Lubricant (R134a) A/C ........................ ATC-5, ATC-24
Lubrication circuit (engine)(QR20DE-QR25DE) .. LU-5
Lubrication circuit (engine)(YD22DDTi) ............. LU-19
Lubrication oil A/C .......................................... ATC-164
Lubrication-locks, hinges and hood latches ...... MA-46
M
M/T major overhaul ............................... MT-22
, MT-40
M/T removal and installation .............................. MT-19
MAFS - Wiring diagram ... EC-153, EC-646, EC-1077,
EC-1084
, EC-1439
Magnet clutch ................................. ATC-88, ATC-146
MAIN - Wiring diagram .... EC-125, EC-625, EC-1046,
EC-1415
Mainshaft (M/T) ..................................... MT-23, MT-41
Maintenance (engine)(YD22DDTi) ................... MA-29
Major overhaul (Transfer) .................................. TF-59
Malfunction indicator (MI) .. EC-64, EC-568, EC-1001,
EC-1373
Mass air flow sensor (MAFS) ........... EC-151, EC-644,
EC-1075
, EC-1083, EC-1438
Master cylinder (brake) ...................................... BR-14
Master cylinder (clutch) ........................................ CL-9
Meter ..................................................................... DI-4
METER - Wiring diagram ......................... DI-16, DI-19
MIL/DL - Wiring diagram ............... EC-1348, EC-1699
MIRROR - Wiring diagram ............................... GW-87
Mirror defogger ................................................ GW-21
Mirror, door ...................................................... GW-86
Mirror, out side ................................................. GW-86
Misfire .............................................................. EC-239
Mode door control linkage adjustment ........... ATC-75,
ATC-134
, MTC-9, MTC-31
Mode door motor ............................ ATC-73, ATC-134
Molding - See Exterior ................... EI-22, EI-24, EI-25
Mud guard - See Exterior .................................... EI-24
MULTI - Wiring diagram ..................................... BL-77
Multiport fuel injection (MFI) system ... EC-35, EC-548
Multiport fuel injection precautions ....................... GI-6
Multi-remote control system ............................... BL-74
N
NATS - Wiring diagram .................................... BL-111
NATS (Nissan anti-theft system) ..................... BL-108
NATS (Nissan anti-theft system) precautions ....... GI-3
NVH troubleshooting (BR) ................................... BR-5
NVH troubleshooting (Transfer) ........................... TF-9
O
Oil cooler (engine)(QR20DE-QR25DE) ............. LU-11
Oil cooler (engine)(YD22DDTi) .......................... LU-28
Oil filter(QR20DE-QR25DE) .............................. LU-10
Oil filter(YD22DDTi) ........................................... LU-23
Oil pan (engine)(QR20DE-QR25DE) ................ EM-27
Oil pan (engine)(YD22DDTi) ........................... EM-157
Oil pressure (engine)(QR20DE-QR25DE) ........... LU-7
Oil pressure (engine)(YD22DDTi) ...................... LU-20
Oil pump (engine)(QR20DE-QR25DE) .............. LU-13
Oil pump (engine)(YD22DDTi) ........................... LU-30
Oil seal replacement (engine)(QR20DE-QR25DE) .......
EM-46
, EM-70, EM-89
On board diagnostic system . EC-52, EC-565, EC-996
Operating cylinder (clutch) ................................. CL-12
Out side mirror ................................................. GW-86
Overdrive control switch .................... AT-240, AT-327
Overheat ........... EC-352, EC-755, EC-1124, EC-1480
Oversize piston(QR20DE-QR25DE) ............... EM-112
Oversize piston(YD22DDTi) ........................... EM-250