2005 MITSUBISHI LANCER EVOLUTION IX boot

EXTERIOR – FRONT BUMPER, REAR BUMPER51-4
Rear bumper
Rear bumper
Removal and fitting
Jobs to be completed before removal and after fitting
•Removal and refitting of the rear combination lamp
•Removal and refitting of the rear end trim
•Removal and refitting of the boot area side trim lid
Removal procedure
1. Screw for attaching the splash shield
2. Rear bumper bracket3. Rear bumper ASSY
4. Rear number plate bracket
Cross section
through A-A
clip
splash
shield

EXTERIOR – MARKINGS 51-6
Markings
Removal and affixing
1. Front 3-diamonds badge (Ref P.51- 3) 2. LANCER badge
3. EVOLUTION badge
Guidelines for affixing markings



A 
Affixing markings
1. Positioning
2. Guidelines for affixing
(1) Using white spirit, remove any grease from the place where the
badges will be affixed.
(2) Remove the protective paper from the back of the badges, and
affix them in the designated places.
Caution
1) Perform this job in an ambient temperature of 20~38ºC, and
in a dust free location.
2) If the job is being performed in an ambient temperature of
less than 20ºC, warm up the badges, and the area of the
body onto which they will be affixed, to a temperature of
20~38ºC.
3) Ensure that air bubbles are not trapped in the adhesive tape
when the badges are affixed.



A 



A 
2. LANCER badge 3. EVOLUTION badge
edge of boot lid

84G6 – ALTERNATOR / IGNITION SYSTEM
Alternator / Ignition System
Removal and Installation
Note :
The ignition coil boot must only be removed from the ignition coil when it is to be replaced.
If removed, always replace with a new part.
Removal sequence
1. Oil level gauge
2. O-ring
3. Oil level gauge guide
4. O-ring
5. Water pump pulley
6. Auto tensioner assembly
7. Alternator bracket8. Alternator
9. Crankshaft pulley
10. Centre cover
11. Spark plug cable
12. Ignition coil
13. Ignition coil boot
14. Spark plug
A
*

94G6 – ALTERNATOR, IGNITION SYSTEM
Removal Service Point
Removal of ignition coil boot
Note :
• If the ignition coil boot is not installed according to the
specifications, then this can lead to various problems, such
as malfunction of the ignition coil, damage to the ignition coil,
leaking of high voltage to external parts, infiltration of water
into the hole, etc.
• The spark plug coupling section of the ignition coil boot is
coated with a white powder. This coating helps to prevent the
boot from welding to the spark plug, and must not be touched
or wiped away.
1. Please check that a spring is fitted inside the new ignition coil
boot.
2. Press the new ignition coil boot firmly onto the ignition coil,
and turn the coupling section 2 or 3 times to seat it correctly
in position, ensuring that there are no gaps.
3. After installation, turn the boot until the air blow hole is
positioned as shown in the diagram.
Coupling
section
Air blow hole
White powder coating on
interior part. Do not touchAir blow hole
Upper faceA

*

1-1
Section 1
Layout Diagrams
CONTENTS
General Layout Diagram ........................1-3
Engine Compartment .............................1-4
Engine / Transmission ...........................1-6
Instrument Panel...................................1-10Floor / Roof ...........................................1-16
Door .......................................................1-18
Boot Compartment ...............................1-20

LAYOUT DIAGRAMS - BOOT COMPARTMENT1-20
F-01 (2) Boot compartment light
F-02 (2-black) High-mount stop light
F-05 (4) Rear wiper motor
F-06 (2) Rear speaker (RH)
F-07 (1) Demister (+)
F-10 (6-black) Rear combination light (RH)
F-11 (1) Boot compartment light switch
F-12 (2-grey) Licence plate light (RH)
F-13 (2-grey) Licence plate light (LH)
F-14 (2-grey) Floor harness (LH) / Bumper harness
junction
F-15 (6-black) Rear combination lamp (LH)
F-16 (2) Rear speaker (LH)F-18 (1-black) Demister (-)
F-19 (2) Windscreen washer motor
F-20 (2-green) Rear washer motor
F-21 (2-black) Electric pump
F-22 (8-grey) Floor harness (LH) / 4WD harness
junction
F-23 (2-black) Directional valve (left) (vehicle with AYC)
F-24 (2-black) Directional valve (right) (vehicle with AYC)
F-25 (3-black) Proportional valve (for ACD)
F-26 (3-black) Proportional valve (for AYC (vehicle with
AYC)
F-27 (3-black) Pressure sensor
F-28 (2) Dummy connector
BOOT COMPARTMENT
Connector Symbol
Bumper harness Demister earth
Floor harness (LH)
4WD harnessFloor harness (RH)

3-1
SECTION 3
CIRCUIT DIAGRAMS
CONTENTS
J/B ............................................................3-4
J/C ............................................................3-6
Central Junction....................................3-11
Power Supply ........................................3-18
Starting System ....................................3-23
Ignition ...................................................3-24
Charging ................................................3-26
Engine Control ......................................3-28
Cooling ..................................................3-36
Lighting
Headlights (excl. discharge type).....................3-38
Headlights (discharge type) .............................3-42
Tail lights, position lights, licence plate
lights, lighting monitor report buzzer................3-46
Cabin lights, boot compartment lights,
ignition key cylinder illumination light,
door ajar indicator light ....................................3-50
Fog lamps ........................................................3-54
Headlight levelling system ...............................3-58
Signals
Turn signal lights, hazard warning lights .........3-60
Reversing lights ...............................................3-64
Stop lights ........................................................3-65
Horn .................................................................3-66
Meters
Needle meters..................................................3-68
Remaining fuel warning light, oil pressure
warning light, brake warning light,
seatbelt warning light .......................................3-70
Door Opening / Closing Control
Power windows ................................................3-72
Central door locking
(vehicle without keyless entry) .........................3-78
Central door locking
(vehicle with keyless entry) ..............................3-80
Temperature Control
Heater ..............................................................3-86
Manual air-conditioning ....................................3-90
Fully automatic air-conditioning .......................3-96
Vision / Safety
Windscreen washer / wipers ..........................3-104
Rear washer / wiper .......................................3-108
Demister
(vehicle with heater or manual A/C) ...............3-110
Demister, door mirror heating elements
(vehicle with full auto A/C)..............................3-112
Electric stowable remote control
door mirrors ....................................................3-114
Accessories
Spare audio connectors .................................3-118
Clock ..............................................................3-120
Cigarette lighter, ashtray illumination lamp ....3-121
Cont. on next page

CIRCUIT DIAGRAMS - J/C3-7
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer•Fog lamps
•Full auto A/C
•Headlights
•Headlight
levelling
system
•Manual A/C
•Cooling
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights• Ignition key
reminder
buzzer
• Windscreen
washer / wiper
• Sunroof
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer• Power windows
• Fog lamps
• Headlight
• Rear washer /
wiper Generic spare
connector
Vehicle speed
sensor• Windscreen washer /
wiper
• Electric stowable
remote control door
mirrors
• Cabin lights, boot
compartment lights,
ignition key cylinder
illumination light, door
ajar indicator light
Diagnosis
connector• ABS
• ACD
(vehicle
w/out AYC)
• ACD, AYC Needle meters• Heater
• Full auto A/C
• Manual A/C
J/B
Sunroof
Power
windows• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights
• Rear washer /
wiperDiagnosis
connectorReversing
lights
Rear washer/
wiper• Reversing lights
• Rear washer /
wiper Generic
fuse
(
)