2005 KIA Rio fuse box

Fuse Replacement
If the electrical system does not work, first check the
driver’s side fuse panel.
1. Turn the ignition switch and all other switches off.
2. Pull the suspected fuse straight out. Use the
removal tool provided on the main fuse box in the
engine compartment. Refer to the fuse panel chart
on the fuse panel cover to identify the likely
problem fuse or electrical circuit.3. Check the removed fuse; replace if it is blown.
Spare fuses are provided in the passenger
compartment fuse panel, and in the engine
compartment fuse panel cover.
4. Push in a new fuse of the same rating, and make
sure it fits tightly in the clips.
If it fits loosely, consult an Authorized Kia Dealer.
If you do not have a spare, use a fuse of the same
rating from a circuit you may not need for operating
the vehicle, such as the CIGAR or AUDIO fuse.In Case Of An Emergency6-8
WARNING -Fuse Replacement
 Never replace a fuse with anything but
another fuse of the same type and rating.
 A higher capacity fuse could cause damage
and possibly a fire.
 Never install a wire in place of the proper
fuse - even as a temporary repair. It may
cause extensive wiring damage and possibly
a fire.
 Do not use a screwdriver or any other metal
object to remove fuses because it may cause
a short circuit and damage the system.
1B3106003A
RIO ENG CNA 6.qxd 7/29/05 5:15 PM Page 8

If the headlights or other electrical components do not
work and the fuses are OK, check the fuse box in the
engine compartment. If a fuse is blown, it must be
replaced.
1. Turn the ignition switch and all other switches off.
2. Remove the fuse box cover by unhooking the tab on
one end, and tilting the cover back toward the other
end.
3. Check the fuses. If one is blown, replace it with a
new one of the same rating.
6-9
CAUTION
After checking the fuse box in the engine
compartment, make sure the cover is properly
reinstalled. An improperly installed cover could
allow water ingress and lead to electrical failures.
2FDA602
RIO ENG CNA 6.qxd 7/29/05 5:15 PM Page 9

6-13 Memory Fuse (If Equipped)
Your vehicle is equipped with a “Memory Fuse” to
prevent battery discharge if the vehicle is parked for
prolonged periods without being operated. Use the
following procedures before parking the vehicle for a
prolonged period.
1. Turn off the engine.
2. Turn off the headlights and tail lights.
3. Open the main fuse box cover in the engine compartment
and pull up the “ROOM FUSE 15A” using the fuse
puller; push the fuse to the side. This will change the
MEMORY FUSE mode to prevent battery discharge.
FUEL
PUMPFRONT
FOGA/CON
HEAD
LAMPCOOL.FANHORN
TNS MAIN
COND.F( ) ( )
( )
( )
COND.FAN
ROOM 15A
IG COIL
(ABS)(F/FOG)
HEAD 15A
15A15A
25A
20A
* REFER TO OWNER'S MANUAL FOR FUSE AND RELAY SERVICE.
* ( ) : OPTION
RIOMEMORY
CAUTION
•If the memory fuse is pulled up from the fuse
box housing, the radio and dome light will not
operate. After reinstalling the “Memory Fuse”,
the radio “anti-theft”code (Optional) must be
entered again and the preset radio stations
must be reselected.
Even though the memory fuse is pulled up, the
battery can still be discharged by operation of
the headlights or other electrical devices.
RIO ENG CNA 6.qxd 7/29/05 5:15 PM Page 13

Engine Compartment
7-13
Engine coolant reservoir Radiator cap Engine oil fill capAir cleanerAuto transaxle fluid
dipstick (if equipped)Brake/clutch
fluid reservoir
Engine oil dipstick Windshield
washer
fluid
reservoir Power steering
fluid reservoir
(if equipped)Fuse box
Battery
2FDA604
RIO ENG CNA 7-1.qxd 7/29/05 5:16 PM Page 13