2004 Peugeot Partner VU Dag belt

7YOUR PARTNER AT A GLANCE
22-12-2003
AIR BAGS The air bag system has been designed to maximise the safetyof the occupants in the event ofserious collisions. It works in con-junction with the pretensioningseat belts. Front air bags These are folded in the centre of the steering wheel for the driverand in the fascia for the front
passenger. They are deployed
simultaneously, except in caseswhere the passenger air bag isdisarmed. Precautions regarding the passenger air bag disarm the air bag if you install a rear-facing child seat,
 activate the air bag for an
adult passenger. Disarming the passenger air bag* 
With the ignition off, insert the ignition key into the passen-ger air bag slot 1 and turn it to
the "OFF" position.
As soon as you remove the childseat, turn the air bag switch to the"ON" position to activate the air
bag again. Operating check
With the ignition switchedon (2nd notch), illumina-tion of this warning lightindicates that the pas-senger air bag is dis-
armed (slot in the "OFF" posi-
tion). The warning light remains on throughout the disarming process.
Side air bags* Side air bags are incorporated into the front seat back frame, onthe door side. They are deployed independently
of each other, on whichever sidethe collision occurs. *
According to destination.8283

PEUGEOT SERVICING19
22-12-2003
SPECIAL FEATURES Some of your vehicle's vital components have specific servicing schedules. The
brake fluid must be replaced every 36,000/40,000 miles (60 000 km) or every 2 years.
The passenger compartment filter must be checked at each visitto the PEUGEOT dealer (intermediate visits and regu-
lar services).The timing belt : consult your PEUGEOT dealer.
Arduous conditions of use If the vehicle is used in certain particularly arduous conditions:
¥ Continuous door-to-door use.
¥ Town use (e.g. taxi).¥ Repeated short journeys, with the engine cold in low temperatures.
Or in long stays in the following conditions: ¥ Hot countries with temperatures often above 30 ¡C.¥ Cold countries with temperatures often below minus 15 ¡C.¥ Countries with a dusty atmosphere.¥ Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous Conditions" servicing schedule, which includes special operations and shorterservice intervals: ¥ Every 12,000 miles (20 000 km) or every year for petrol engine vehicles.¥ Every 10,000 miles (15 000 km) or every year for Direct Injection Diesel engine vehicles.¥ Every 6,000 miles (10 000 km) or every year for Indirect Injection Diesel engine vehicles.

PEUGEOT SERVICING19
22-12-2003
SPECIAL FEATURES Some of your vehicle's vital components have specific servicing schedules. The
brake fluid must be replaced every 36,000/40,000 miles (60 000 km) or every 2 years.
The passenger compartment filter must be checked at each visitto the PEUGEOT dealer (intermediate visits and regu-
lar services).The timing belt : consult your PEUGEOT dealer.
Arduous conditions of use If the vehicle is used in certain particularly arduous conditions:
¥ Continuous door-to-door use.
¥ Town use (e.g. taxi).¥ Repeated short journeys, with the engine cold in low temperatures.
Or in long stays in the following conditions: ¥ Hot countries with temperatures often above 30 ¡C.¥ Cold countries with temperatures often below minus 15 ¡C.¥ Countries with a dusty atmosphere.¥ Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous Conditions" servicing schedule, which includes special operations and shorterservice intervals: ¥ Every 12,000 miles (20 000 km) or every year for petrol engine vehicles.¥ Every 10,000 miles (15 000 km) or every year for Direct Injection Diesel engine vehicles.¥ Every 6,000 miles (10 000 km) or every year for Indirect Injection Diesel engine vehicles.

PEUGEOT SERVICING25
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILLÐ Engine oilÐ Bleed fuel filter (diesel)Ð Oil filterÐ Petrol filter (according to engine)REPLACEÐ Diesel filter or element (according to engine)Ð Air filter elementÐ Spark plugs (petrol)Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if cap is removableLEVELÐ Screen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen washer jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers)CHECKÐ Condition of rubber boots and gaitersÐ Brake pads Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbersÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare wheel)Ð Emission control check as per current legislation (petrol)Ð Smoke opacity (diesel)Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.

INSTRUMENTS AND CONTROLS
28
22-12-2003
1.
Seat belt not fastened warning light*
2. Passenger air bag disarmingwarning light*
3. Front and side air bags warninglight
4. Front fog lamps indicator light
5. Anti-lock braking system (ABS)warning light
6. Rear fog lamp indicator light
7. Diesel pre-heat warning light
8. Left hand direction indicator
9. Total distance recorder, serviceindicator and engine oil levelindicator 10.
Right hand direction indicator
11 . Engine diagnostics warning light
12. Main beam headlamps indicator light
13. Handbrake, low brake fluid leveland electronic brake forcedistribution warning light
14. Dipped beam headlampsindicator light
15. Battery charge warning light
16. Engine oil pressure andtemperature warning light
17. Water in diesel filter warning light
18. Low coolant level warning light 19.
Coolant temperature indicator
20. Total distance recorder button
21. Central (STOP) warning light
22. Speedometer
23. Rev counter
24. Lighting rheostat button
25. Fuel level indicator
26. Low fuel level warning light
* According to destination.
INSTRUMENT PANEL: PETROL-DIESEL MANUAL GEARBOX

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

YOUR PARTNER IN DETAIL
56
22-12-2003
GENERAL POINTS RELATING TO CHILD SEATS Although one of PEUGEOT's main criteria when designing your vehicle, the safety of your children also depends on you.
For maximum safety, please follow these precautions:
Ð Since 1992,
all children under the age of 10 must travel in approved child
seats* suited to their weight , on seats fitted with a seat belt.
Ð A child weighing less than 9 kg must travel in the rearwards facing position both in the front and in the rear. PEUGEOT recommends that children should travel in the "rearwards facing" position up to the age of two.
Ð Statistically, the safest seats in your vehicle for the transportation of chil- dren are the rear seats. PEUGEOT recommends that children travel in the rear even when a "rearwards facing" child seat is used.
Ð If a child is travelling on a booster seat, check that the lap section of the seat belt passes over the child's thighs correctly. The chest section of the seat beltmust be positioned on the child's shoulder without touching the neck. PEUGEOTrecommends that you use a booster seat with a back, fitted with a seat beltguide at shoulder level.
Ð Remember to fasten the seat belt or the child seat harness keeping the slack
in relation to the child's body to a minimum , even for short journeys.
* According to current legislation in the country.
** Consult the relevant administration in your country for information regarding the rules for transporting children on the front passenger seat.Rules for transporting children on the front passenger seat** Children under the age of 10 must not travel in the forwards facing position, unless the rear seats arealready occupied by other childrenor the rear seats cannot be used(absent or folded). In this case,adjust the front passenger seat tothe intermediate position and leavethe passenger air bag armed. The transportation of children in the rearwards facing position is permit-
ted. In this position, it is essential to
disarm the passenger air bag.Otherwise, the child would risk beingkilled or seriously injured if the airbag were to inflate.