2004 Peugeot Partner VP fuel cap

22-12-2003
4THE KEYS The keys allow you to switch on the ignition and operate thepassenger air bag disarmingswitch, as well as to indepen-dently operate the locks on thedoors and the fuel filler cap. Central locking From the front doors, the keys allow you to lock and unlock thedoors and tailgate. If one of the doors or the tailgate is open, it is impossible to opera-te the central locking. The remote control performs the same functions at a distance. The remote control Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators forapproximately two seconds. Unlocking Press button Bto unlock the
vehicle. This is confirmed by rapid flashing of the direction indicators. Locating the vehicle
To locate your vehicle, previous- ly locked, in a car park:  press button A, the courtesy
lights come on and the direc- tion indicators flash for a fewseconds. STARTING
STOP position (S):
the ignition is off.
1st notch, Accessories position (A):
the ignition is off but the acces- sories can be used. 2nd notch, Running position (M): the ignition is on. Starting position (D):
operates the starter.YOUR PARTNER AT A GLANCE
63

14YOUR PARTNER AT A GLANCE
OPENING THE BONNET Inside the vehicle:Pull the
control on the left-hand side, under the fascia panel. Outside the vehicle: Lift
the control, raise the bonnet and secure thestrut to keep the bonnetopen.
FILLING WITH FUEL This operation must be carried out with
the engine switched off.
 Insert the key then turn it to the left.
 Remove the cap.
An indication shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the pump. This could cause a malfunction. The capacity of the tank is approximately 55 litres for petrol engines and 60 litres for Diesel engines. Note: the right-hand sliding side door cannot be opened while the fuel tank
cap is removed.
Low fuel level warning light From the time this light comes on, you have enough fuel left to cover approximately 30 miles (50 km) .
7271
22-12-2003

22-12-2003
PEUGEOT SERVICING25
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation1st serviceA C Intermediate
DRAIN/REFILL- Engine oil- Bleed fuel filter (diesel)- Oil filter- Petrol filter* (according to engine)REPLACE- Diesel filter or element (according to engine)- Air filter element- Spark plugs (petrol)- Engine oil (check + top-up)- Manual gearbox oil (check + top-up)- Battery (check + top-up) if cap is removableLEVEL- Screen wash (check + top-up)- Coolant (check + top-up)- Brake fluid (check + top-up)- Power steering fluid (check + top up according to specification)- Operation of lights and indicators- Condition of glass, headlamp and light lenses and mirrors- Horn- Windscreen washer jets- Condition of wiper blades- Condition and tension of the ancillary drive belts- Handbrake- Condition of hydraulic circuits (hoses and covers)CHECK- Condition of rubber boots and gaiters- Brake pads - Play in hubs, link rods, ball joints, flexible mountings- Shock absorbers- Rear drum brake lining wear- Condition and pressure of tyres (including spare wheel)- Emission control check as per current legislation (petrol)- Smoke opacity (diesel)- Passenger compartment filter (according to specification) - Visual check of the whole vehicle
SERVICE*- Courtesy vehicleROAD TEST
: All driving conditions.: Arduous conditions. * According to destination.

Seat belt not fastened warning light* When the ignition is swit-
ched on, this indicator light comes on if the driver has not fastened hisseat belt. Above 12 mph (20 kmh), this warning light flashes for two minutes accom-panied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the dri-ver fastens his seat belt.
Battery charge warning light
This indicates one of the following:
- faulty operation of the charging circuit,
- slack battery or starter terminals,
- a cut or slack alternator belt,
- an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light This comes on for a few
seconds each time the ignition is switched on. If it comes on with the engine run- ning, this indicates incorrect opera-tion of the injection, ignition or emis-
sion control system. There is a riskof damage to the catalytic converter(petrol engine only).
Consult a PEUGEOT dealer.
* According to destination. Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmed warninglight*
If the passenger air bag is disarmed, the warning light comes on whenthe ignition is switched on and itremains on.
Always consult a PEUGEOT dealer if the warning light flashes.
Low fuel levelwarning light
When this light first comes on, youhave enough fuel to drive approxi-
mately 30 miles (50 km) (The tank
capacity is approximately 55 litresfor petrol engines and 60 litres forDiesel engines). Diesel engine pre-heat warning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
INSTRUMENTS AND CONTROLS
30
Electronic stability control system(ESP/ASR) warninglight
This comes on for a few secondseach time the ignition is switched on.
Contact a PEUGEOT dealer if the ESP/ASR switch indicator lightflashes and this warning lightremains on or comes on while theengine is running and the vehicle ismoving. While the engine is running and the vehicle is moving, it flashes if thesystem is activated. It comes on permanently when it is disarmed.
22-12-2003

YOUR PARTNER IN DETAIL63
THE KEYS The keys allow you to switch on the ignition and operate the passengerair bag disarming switch as well as toindependently operate the locks onthe doors and the fuel filler cap. Central locking From the front doors, the keys allow you to lock and unlock the doors andtailgate. If one of the doors or the tailgate is open, the central locking does notwork. The remote control performs the same functions at a distance.The remote control Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators for approxi-mately two seconds. Unlocking Press button Bto unlock the vehicle.
This is confirmed by rapid flashing of the direction indicators. Note: if the vehicle is locked and
unlocking is activated inadvertently, unless the doors are opened within30 seconds, the vehicle will lock
automatically. Locating your vehicle
To locate your vehicle, if you have locked it, in a car park:  press button A, the courtesy
lights come on and the direction indicators flash for a fewseconds.
Changing the battery of the remote control The information "battery flat" is given by an audible signal accompanied by the message "Remote control
battery flat" on the screen.
To change the battery, unclip thecasing using a coin at the ring (CR 2016/3 volt battery). If the remote control does not work after the battery has been changed,re-programme the remote control. Programming the remote control  Switch off the ignition.
 Switch the ignition on again.
 Press button Aimmediately for a
few seconds.
 Switch off the ignition and remo- ve the remote control key from
the ignition lock. The remotecontrol is now working again.
22-12-2003

22-12-2003
YOUR PARTNER IN DETAIL
66
FRONT DOORS AND SLIDING SIDE DOORS Front doors Side doors Opening the doors from outside Locking / Unlocking from the inside Front doors
To lock, lower button
A.
Locking one of the front doors permits complete locking of thevehicle.
To unlock and open, lift button Aand
pull the handle towards you. The driver's door opening control permits complete unlocking of thevehicle. Sliding side doors The side door opening/closing control only controls the door concerned.
To close, press button Band slide the
door towards the front of the vehicle.
To open, press button Band slide the
door towards the rear. Note: if the fuel tank cap is removed,
the right-hand side door cannot be opened.
Side doors Opening the doors from inside The driver's door opening control permits complete unlocking of thevehicle.
Front doors

22-12-2003
YOUR PARTNER IN DETAIL
72
FILLING WITH FUEL Low fuel level
When the minimum fuel level in the tank is reached, this warninglight comes on.
You have enough fuel remainingto drive for approximately 30 miles (50 km). The engine must be switched off when filling with fuel.  Insert the key then turn it to the left.
 Remove the cap.
An indication reminds you which type of fuel to use. When you fill your tank, do not
continue after the third cut-off of the
pump. This could cause your vehicleto malfunction. The capacity of the tank is approximately 55 litres for petrolengines and 60 litres for Dieselengines. After filling the tank, lock the cap.
When the cap is removed, the right-hand sliding sidedoor cannot be opened. The key cannot be remo-
ved from the lock until the cap has been replaced on the fueltank.

TECHNICAL DATA115
PETROL
Model codes GJHFXB GJKFWB GJNFUB GJKFWC/IF GJNFUC/IF
ENGINES 1.1 litre 1.4 litre 1.6 litre 16V
Cubic capacity (cm 3
) 1124 1360 1587
Bore x stroke (mm) 72 x 69 75 x 77 78.5 x 82
EU standard maximum power (kW) 44.1 55 80
Maximum power at engine speed (rpm) 5500 5500 5800
EU standard maximum torque (Nm) 94 120 147
Maximum torque at engine speed (rpm) 2700 2800 4000Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes
GearboxManual Manual Manual
(5 speed) (5 speed) (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.2 (1) - 3.4 (2) 3 (1) - 3.25 (2) 3.2 (1) - 3.4 (2)Gearbox-Final drive 2 2 2
ENGINES AND GEARBOXES
(1) Draining by gravity - (2) Draining by suction
22-12-2003