2004 JEEP WRANGLER tires

Improper alignment will not cause vehicle vibration,
which may be a result of tire and wheel out-of-balance.
Proper balancing will reduce vibration and avoid tire
cupping and spotty wear.
TIRE CHAINS
Install chains on rear tires only. Tire chains may be
installed on all models except Sahara. Follow these
recommendations to guard against damage and exces-
sive tire and chain wear:
²Use chains on P205/75R15 or P215/75R15 tires only.
P225/75R15, LT30 x 9.50R15, and LT245/75R16 tires
do not provide adequate clearance.
²Use SAE class ªSº tire chains or traction devices only.
²Chains must be the proper size for the vehicle, as
recommended by the chain manufacturer.
²Follow tire chain manufacturer's instructions for
mounting chains.
²Install chains snugly and tighten after.6 mile (1 km) of
driving.
²Do notexceed 30 mph (48 km/h).
²Drive cautiously, avoiding large bumps, potholes and
extreme driving maneuvers.
²Do notuse chains or traction devices on the Poly-spare
tire.
TIRE ROTATION RECOMMENDATIONS
Tires on the front and rear axles of vehicles operate at
different loads and perform different steering, handling,
and braking functions. For these reasons, they wear at
unequal rates, and develop irregular wear patterns.
These effects can be reduced by timely rotation of tires.
The benefits of rotation are especially worthwhile with
aggressive tread designs such as those on On/Off Road
type tires. Rotation will increase tread life, help to main-
tain mud, snow, and wet traction levels, and contribute to
a smooth, quiet ride.
196 STARTING AND OPERATING

To remove the jack from its stowage position, carefully
release the rubber strap from the bracket. Turn the thumb
screw counterclockwise to loosen jack and then remove it
from the bracket.
WARNING!
Always store the jack, lug wrench, jack handle
driver, jack extension, and spare, flat or damaged tire
securely in the proper place. Never leave them loose
in the vehicle where they could become dangerous
projectiles during a quick stop or collision.
WARNING!
The jack is designed to use as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes, unless suitable sup-
ports are placed under the vehicle as a safety mea-
sure. The vehicle should be jacked on a firm level
surface only. Avoid ice or slippery areas.
CAUTION!
Never use your vehicle jack on the bumpers, sills or
underbody of your vehicle. Damage may result.
Place your vehicle jack only under an axle and in the
positions shown for ªTire Changing Procedures.º
212 WHAT TO DO IN EMERGENCIES

Maintenance After Off-Road Driving
After extended operation in mud, sand or water, or
similar dirty conditions, have your brake drums, brake
linings, and axle joints inspected and cleaned as soon as
possible. This will prevent any abrasive material from
causing excessive wear or unpredictable braking action.
Following off-road usage, completely inspect the under-
body of your vehicle. Check tires, body structure, steer-
ing, suspension and exhaust system for damage. Check
threaded fasteners for looseness, particularly on the
chassis, drivetrain components, steering and suspension.
Retighten, if required, to torque values specified in the
Service Manual. Also check for accumulations of vegeta-
tion or brush that could become a fire hazard, or conceal
damage to fuel lines, brake hoses, axle pinion seals, and
propeller shafts. Check air conditioning drain tube on the
lower dash wall in the engine compartment for mud or
debris, and clean as required. A plugged tube will
adversely affect air conditioning performance.CAUTION!
Under frequent heavy-duty driving conditions,
change all lubricants, and lubricate body compo-
nents and steering linkage more often than in nor-
mal service to prevent excessive wear.
FUSE PANEL
Interior Fuses
The fuse panel is located behind the glove box.
254 MAINTAINING YOUR VEHICLE

²Rotate the tires at each oil change interval shown on
Schedule ªAº 6,000 miles (10 000 km) or every other
interval shown on Schedule ªBº 6,000 miles (10 000
km).²After completion of off-road operation, the underside
of the vehicle should be thoroughly inspected. Exam-
ine threaded fasteners for looseness.
264 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes...................... 177
Add-A-Trunk........................... 65
Adding Washer Fluid.................... 155
Air Cleaner, Engine..................... 234
Air Conditioner Maintenance.............. 235
Air Conditioning....................... 151
Air Conditioning Controls................ 152
Air Conditioning, Operating Tips........... 154
Air Conditioning Refrigerant.............. 236
Air Filter............................. 234
Air Pressure, Tires...................... 192
Airbag................................ 22
Airbag Deployment...................... 27
Airbag Light........................29,118
Airbag Maintenance...................... 29
Airbag On/Off Switch.................... 26
Alignment and Balance.................. 195
Alterations/Modifications, Vehicle............ 8
Antenna, Satellite Radio.................. 147
Antifreeze (Engine Coolant)............... 258
Anti-Lock Brake System.................. 179
Anti-Lock Warning Light................. 119
Appearance Care....................... 248Ashtray............................... 62
Ashtrays and Lighter..................... 62
Automatic Dimming Mirror................ 46
Automatic Transmission...............165,245
Adding Fluid........................ 246
Fluid and Filter Changes................ 245
Fluid Level Check..................... 245
Fluid Type.......................... 245
Gear Ranges......................... 166
Shifting............................ 165
Special Additives..................... 246
Torque Converter..................... 170
Auxiliary Electrical Outlet................. 63
Auxiliary Power Outlet................... 63
Battery............................... 234
Emergency Starting.................... 216
Voltmeter........................... 116
Belts, Drive........................... 231
Belts, Seat............................. 17
Body Mechanism Lubrication.............. 237
Brake System.......................... 243
Anti-Lock........................... 179
288 INDEX

Hood Release.......................... 55
Hoses............................242,243
Hydraulic Clutch Fluid.................. 246
Ignition
Key ................................ 11
Illuminated Entry....................... 15
Infant Restraint.......................29,30
Inflation Pressure Tires................... 192
Inside Rearview Mirror................... 46
Instrument Cluster...................... 115
Instrument Panel and Controls............. 114
Interior Appearance Care................. 252
Interior Fuses.......................... 254
Interior Lights.......................... 56
Intermittent Wipers...................... 58
Introduction............................ 4
Jack Location.......................... 211
Jack Operation......................... 214
Jacking Instructions..................... 214
Jump Starting......................... 216Key, Programming....................... 13
Key Release Button...................... 11
Key, Replacement....................... 13
Key, Sentry............................ 12
Key-In Reminder........................ 12
Keys................................. 11
Lane Change and Turn Signals............. 116
Lap Belts.............................. 17
Lap/Shoulder Belts...................... 17
LATCH (Lower Anchors and Tether
for CHildren)........................... 33
Lead Free Gasoline...................... 197
Lighter, Cigar.......................... 62
Lights................................ 56
Airbag...........................29,118
Anti-Lock........................... 119
Anti-Lock Warning.................... 119
Brake Warning....................... 119
Check Engine........................ 118
Check Gauges........................ 118
Cruise.............................. 116
INDEX 293
10

Daytime Running...................... 58
Dimmer Switch, Headlight............... 57
Fog ................................ 58
Headlight Switch...................... 57
High Beam.......................... 117
High Beam Indicator................... 117
Instrument Cluster..................... 57
Interior.............................. 56
Lights On Reminder.................... 57
Low Fuel........................... 120
Passing............................. 57
Seat Belt Reminder.................... 117
Sentry Key.......................... 116
Turn Signal........................58,116
Upshift Indicator...................... 117
Warning (Instrument Cluster Description) . . . 116
Loading Vehicle
Tires ............................... 188
Locks................................ 15
Door............................... 15
Steering Wheel........................ 14
Lower Anchors and Tether for
CHildren (LATCH)...................... 33Lubrication, Body....................... 237
Lug Nuts............................. 215
Maintenance, Airbag..................... 29
Maintenance Free Battery................. 234
Maintenance Procedures.................. 228
Maintenance Schedule................... 262
Schedule9A9......................... 274
Schedule9B9......................... 265
Maintenance Schedules.................. 262
Malfunction Indicator Light............ 118,226
Manual, Service........................ 285
Manual Transmission.................163,246
Fluid Level Check..................... 247
Lubricant Selection.................... 246
Shift Speeds......................... 164
Master Cylinder........................ 244
Mirrors............................... 46
Automatic Dimming.................... 46
Compass/Temperature.................. 46
Outside............................. 49
Rearview............................ 46
Modifications/Alterations, Vehicle............ 8
294 INDEX

Mopar Parts........................227,284
Multi-Function Control Lever............... 56
New Vehicle Break-In Period............... 39
Occupant Restraints...................... 16
Octane Rating, Gasoline.................. 197
Odometer............................. 119
Trip ............................... 119
Off-Pavement Driving................... 181
Off-Road Driving....................... 181
Oil, Engine........................... 228
Capacity............................ 258
Dipstick............................ 228
Filter.............................. 231
Identification Logo.................... 230
Materials Added to.................... 231
Recommendation..................230,258
Viscosity............................ 258
Onboard Diagnostic System............225,226
Outside Rearview Mirrors................. 49
Overheating, Engine..................... 210
Owner's Manual....................... 285Paint Care............................ 248
Paint Damage......................... 248
Parking Brake......................... 175
Passenger Airbag On/Off Switch............ 26
Passing Light........................... 57
PCV Valve............................ 234
Pets.................................. 39
Pets, Transporting....................... 39
Placard, Tire and Loading Information....... 188
Polishing and Waxing................... 249
Power
Distribution Center.................... 256
Steering............................ 236
Pregnant Women and Seat Belts............. 21
Preparation for Jacking................... 213
Pressure Gauge, Oil..................... 117
Radial Ply Tires........................ 193
Radio.......................122,130,135,140
Radio Broadcast Signals.................. 121
Radio Operation..................130,135,149
Radio, Satellite......................... 145
Rear Axle............................. 248
INDEX 295
10