2004 JEEP WRANGLER wipers

NDaytime Running Lights Ð Canada Only.....58
mWindshield Wipers And Washers...........58
NIntermittent Wiper System................58
NWindshield Wiper Operation..............59
NWindshield Washers....................59
NMist Feature..........................59
mTilt Steering Column.....................60
mElectronic Speed Control..................60
NTo Activate...........................61
NTo Set At A Desired Speed................61
NTo Deactivate.........................61
NTo Resume Speed......................61
NTo Vary The Speed Setting................61
NTo Accelerate For Passing................62
mCigar Lighter And Ashtrays Ð If Equipped....62
mElectrical Power Outlet...................63
NElectrical Outlet Use With Engine Off........63
mCup Holders..........................64
mStorage...............................65
NGlove Compartment....................65
NConsole Storage Compartment Ð
If Equipped..........................65
NAdd-A-TrunkŸ Ð If Equipped............65
mDual Top Ð If Equipped..................66
NRemoving The Soft Top..................66
NInstalling The Soft Top..................68
mHard Top.............................78
NHard Top Removal.....................79
NHard Top Installation...................82
44 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

Front Fog Lights Ð If Equipped
The front fog light switch is in the multi-function
control lever. To activate the front fog lights, turn
on the parking or low beam headlights and pull
out the end of the lever.
NOTE:The fog lights will only operate with the park-
ing lights or the headlights on low beam. Selecting high
beam headlights will turn off the fog lights.
Turn Signals
Move the multi-function control lever up or down and
the arrows on each side of the instrument cluster flash to
show proper operation of the front and rear turn signal
lights. You can signal a lane change by moving the lever
partially up or down without moving beyond the detent.
If either light remains on and does not flash, or there is a
very fast flash rate, check for a defective outside light
bulb. If an indicator fails to light when the lever is
moved, it would suggest that the fuse or indicator bulb is
defective.
NOTE:A tone will chime if the turn signals are left on
for more than 1 mile (2 km).
Daytime Running Lights Ð Canada Only
The headlights come on at a low intensity level after the
vehicle has been driven approximately 3 feet (1 meter).
They will turn off when the vehicle is turned off or when
the headlights are switched on.
WINDSHIELD WIPERS AND WASHERS
CAUTION!
In cold weather, always turn off the wiper switch
and allow the wipers to return to the park position
before turning off the engine. If the wiper switch is
left on and the wipers freeze to the windshield,
damage to the wiper motor may occur when the
vehicle is restarted.
Intermittent Wiper System
Use the intermittent wiper when weather conditions
make a single wiping cycle, with a variable pause be-
tween cycles, desirable. Move the lever to the DELAY
position, then select the delay interval by turning the end
58 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

of the lever. The delay can be regulated from a maximum
of approximately 18 seconds between cycles, to a cycle
every second.
Windshield Wiper Operation
Move the lever upward to the second detent for LO speed
wiper operation, or to the third detent for HI speed
operation
Windshield Washers
To use the washer, pull the lever toward you and hold
while spray is desired. If the lever is pulled while in the
delay range, the wiper will operate for two wipe cycles
after the lever is released, and then resume the intermit-
tent interval previously selected.
If the lever is pulled while in the OFF position, the wipers
will operate for as long as the lever is held plus two wipe
cycles, then turn OFF.
Mist Feature
Push down on the wiper lever to activate a single wipe to
clear off road mist or spray from a passing vehicle. As
long as the lever is held down, the wipers will continue
to operate.
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 59
3

WARNING!
Carefully follow these warnings to help protect
against personal injury:
²Do not drive your vehicle on-road with the wind-
shield down.
²Do not drive your vehicle unless the windshield is
securely fastened, either up or down.
²Eye protection, such as goggles, should be worn at
all times when the windshield is down.
²Be sure that you carefully follow the instructions
for raising the windshield. Make sure that the
folding windshield, windshield wipers, side bars,
and all associated hardware and fasteners are
correctly and tightly assembled before driving
your vehicle. Failure to follow these instructions
may prevent your vehicle from providing you and
your passengers protection in some accidents.
²If you remove the doors, store them outside the
vehicle. In the event of an accident, a loose door
may cause personal injury.
Lowering the Windshield and Removing Side
Bars
1. Lower the fabric top or remove the hard top following
the instructions in this manual.
2. Remove the sun visors, if desired. Store the sun visors.
104 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

5. To safely store the side bars in your vehicle, use four of
the cinch straps, found in the glove box. Attach the straps
through the footman loops located in the floor behind the
folded rear seat on each side of the vehicle.
WARNING!
You or others could be injured if you carry the side
bars loose in your vehicle. Remove the bars from the
vehicle or securely store them as described or they
may cause personal injury if an accident occurs. See
your authorized dealer for replacement if the cinch
straps are not found in the glove box.
6. Remove the windshield wipers by first pulling the
wiper away from the windshield and out to the ªlockº
position. Then, using a small flat tool such as a screw
driver, release the retaining clip. Lift the wipers off and
store in center console or securely behind the rear seat.
106 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

9. Secure the windshield by passing the remaining cinch
strap, found in the glove box, through the footman hoop
on the center of the hood and on the center of the
windshield frame. Tighten the strap to secure the wind-
shield in place.Raising The Windshield And Replacing Side Bars
To raise the windshield, install the windshield wipers,
and install the side bars use these same steps in reverse.
WARNING!
To help protect against personal injury, always in-
stall the side bars when raising the windshield on
your vehicle. If you do not raise the windshield and
install the side bars, you lose the protection these
structural elements provide in some accidents.
108 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Recommended Fluids, Lubricants, and
Genuine Parts for correct fluid type.
Driveline And Steering Component Lubrication
U-joints (cardan joints) are sealed and do not require
lubrication. Prop shafts, yokes, ball joints and other
driveline and steering components may be provided with
grease fittings for lubrication. Lubrication of these com-
ponents at the intervals specified in the appropriate
ªMaintenance Scheduleº in Section 8 is very important,
particularly if your vehicle is subjected to off-road or
other heavy-duty use. See your authorized dealer for
complete service information.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors, tailgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particularattention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth and a
mild non-abrasive cleaner. This will remove accumula-
tions of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield. Avoid using the wiper blades to
remove frost or ice from the windshield. Keep the blade
rubber out of contact with petroleum products such as
engine oil, gasoline, etc.
MAINTAINING YOUR VEHICLE 237
7

Coolant Level........................ 241
Disposal of Used Coolant............... 240
Drain, Flush, and Refill................. 239
Inspection........................... 239
Points to Remember................... 242
Pressure Cap........................ 241
Selection of Coolant................240,258
Temperature Gauge.................... 118
Corrosion Protection.................... 248
Crankcase Emission Control System......... 234
Cruise Control.......................... 60
Cruise Light........................... 116
Cup Holder............................ 64
Customer Assistance.................... 280
Daytime Running Lights.................. 58
Dealer Service......................... 227
Defroster, Rear Window.................. 154
Defroster, Windshield.................151,153
Delay Wipers........................... 58
Deploying, Airbag....................... 27
Diagnostic System, Onboard............... 225
Dimmer Switch, Headlight................. 57Dipsticks
Oil (Engine)......................... 228
Disabled Vehicle Towing................. 219
Disposal
Engine Oil.......................... 231
Used Coolant........................ 240
Door Locks............................ 15
Doors................................ 15
Drive Belts............................ 231
Driving.............................. 181
Off-Pavement........................ 181
Off-Road........................... 181
On Hills............................ 182
On Slippery Surfaces.................. 181
When to Use Low Range............... 181
Dual Top.............................. 66
Electrical Outlet, Auxiliary................. 63
Electrical Power Outlets................... 63
Electronic Speed Control.................. 60
Emergency Brake....................... 175
Emergency, In Case of
Brake Warning Light................... 119
290 INDEX