2004 DACIA SUPERNOVA fuel pressure

83
INSTRUMENT PANEL
OIL PRESSURE WARNING LIGHT STILL ON
AFTER ENGINE STARTING
Check the oil pressure
The pressure is correct.
Replace the oil pressure switch. The pressure is not correct.
There is a failure in the oil circuit.
OIL PRESSURE WARNING LIGHT IS NOT ON
WHEN CONTACT SWITCH ON
Place the wire from the oil pressure switch to the ground.
Wa r ning light is not on.
Check if the bulb is not burnt.
Warning light is on. Replace the oil pressure
switch.
Burnt bulb. Replace it. Bulb is not burnt . Check the bulb
supply wiring and fix it.
FUEL LEVEL INDICATOR
SHOWING ALWAYS FULL
Disconnect the connection wire t o the probe.
The indicator comes back
to zero. Re place the probe. The indicator
does not come to zero.Is there
any ground short-circuit of the connection
wi re to the probe?
Yes. Fix the wiring layout. No. Replace the indicator.
83-7
DIAGNOSTIC
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 11
39HANDBRAKE INDICATOR AND BRAKING SYSTEM FAILURE S S S
40 FUEL LEVEL INDICATOR CIRCUIT S S S
41 OIL PRESSURE INDICATOR CIRCUIT S S S
42 DIAG NOSTIC SOCKET S S S
43 INSTRUMENT PANEL AE1 S
44 INSTRUMENT PANEL AE2, AE3 S S
45 WA TER TEMPERATURE INDICATOR CIRCUIT S S S
46 BRAKE PADS WEAR INDICATOR CIRCUIT S S S
47 VEHICLE SPEED S S S
48 SOUND W ARNING S S S
49 REAR WINDOW DEFROSTING S S S
50 WINDSCREEN WIPER-WASHING S S S
51 REAR FOG LAMP S S S
52 FOG HEADLIGHTS AE2, AE3 S S
53 MEETING LIGHTS S S S
54 REVERSE DRIVING LIGHTS S S S
55 PA R K I N G LIGHTS S S S
56 ROAD LIGHTS S S S
57 STOP LIGHTS AE1, AE2 S S
58 STOP LIGHTS AE2(aileron) O
59 STOP LIGH TS AE2(CA), AE3 O S
60 TURNING AND HAZARD LIGHTS AE1 S
61 TURNING AND HAZARD LIGHTS AE2, AE3 S S
Note : these electr ic diagrams are valid for vehicle manufactured until 01.06.2001; AE1
( Confort), AE2 (Rapsodie), AE3 (Clima) represent equipping levels of the vehicle.
FUNCTIONAL DIAGRAMS LIST
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 12
(until 01.06.2001)
21
101
102
103
104
105
107
113
120
121
122
123
124
125
128
137
138
139
140
141
145
146
147
149
155
156
160
163
165
168
171
172
173
175
176
177
180
181
184
185
188
189
190Right signalling anti-return diode
Electric lighter
Ashtr a y
Alternator
Anti-theft system
Acoustic alarm
Battery
Windscreen wiper timer
Injection computer (UCE)
Fog lights switch
Fog headlights switch
Door closing switch
Climate blower switch
Hazard switch
Rear window defrosting switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM s
ensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
Trunk lighting lamp
Documents compartment lighting lamp
AC compressor clutch
Right rear lamp
Left rear lamp
Left fog lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speakerRight front brake pad
Left front brake pad
Windscreen washing pump
Va l ve potentiometer
Diagnostic socket
Right headlamp
Left headlamp
Fog lamps relay
Fog headlights control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Injection water temperature sensor
Instrument panel
V ehicle speed transducer
Right front turning lamp
Left front turning lamp
Cockpit fuse and relays box
Radio
Cooling motor fan and AC
Right side signalling lamp
Left side signalling lamp
Injection air temperature sensor
Rear window defrosting timer
Climate control lighting
AC starting button
Motor fan resistance ( f or AC)
Left front ceiling lamp
Right front ceiling lamp
Canister purging valve
UCE anti-intrusion
Engine hood contact
Siren
Vo l u metric sensor
AC relay ( on board)
UCE decoder
Hatchback contact
AC compressor clutch control relay
Engine compartment fuse and relays box
Climate control blower
STOP-S3 l amp
St ep-by-step engine
Anti-starting bushing
216
217
221
222
225
226
227
230
231
234
236
238
244
247
250
255
256
260
261
262
267
268
272
294
298
319
321
328
329
371
427
438
442
454
474
503
560
584
597
600
639
649
654
CODE COMPONENT DENOMINATIONCODE COMPONENT DENOMINATION
ELECTRIC COMPONENTS INDEX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 13
191
192
193
194
195
196
199
205
209
210
212Cooling blower low speed control relay
Ignition coil
FLASH relay
Hatchback contact separation diode
Upstream oxygen sensor
C
hock sensor
Anti-intrusion indicator LED
Braking system ICP
AC pressure sensor (pressure controller)
Front ashtray lighting
Climate control blower control relay
700
778
857
871
887
927
993
109 1
120 2
133 5
142 8Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel level transmitter and electric pump
Oil pressure contact
Lights, turning lights and horn switch
Electronic clock
Windscreen wiper motor
ELECTRIC COMPONENTS INDEX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 16
Windscreen wiper timer
FLASH relay
Climate control lighting
AC starting button
AC relay ( on board)
Right front door actuator
Right rear door actuator
Right front door loud speaker
Right rear loudspeaker
Fuel level transmitt er and electric pump
Trunk lighting la mp
Left rear loud speaker
Left rear door actuator
Left fron t door actuator
Left fr ont door loud speaker
Right front door contact
Right volumetric sensor
Left vo lumetric sensor
Right front ceiling lamp
Hatchb ack contacts
Handbrake contact
Anti-starting bushing
Le ft front ceiling lamp
Anti-intrusion indicator LED
Left fron t door contact
UCE d ecoder
Siren
Vehicle speed transducer
Engine hood contact
Doors closing switch
UCE anti-intrusion
( until 01.06.2001)
Inje ctor 1
Inje ctor 2
Inje ctor 3
Inje ctor 4
Atmospheric pressure sensor
Detonation sensor
Starter
In jection air temperature sensor
Valve potentiometer
Step-by step engine
Alternator
Ignition c oil
Canister purging valve
AC pressure sensor(pressure controller)
Diagnostic socket
AC compressor clutch
Upstream oxygen sensor
Cooling blower and AC
Blower resistance for AC
Oil pressure contact
Injec tion computer
RPM sensor
Reverse driving contact
AC compressor clutch control relay (E)
Water temperature sensor
Blower lower speed control relay (B)
E ngine compartment fuse and relays box
Motor fan control relay ( C)
Fog headlamps control relay(A)
Fuel pump control relay (H)
Actuators relay(D)
Chock sensor
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32 33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
LOCATION OF ELECTRIC COUPLING ON THE VEHICLE
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 28
ENGINE WIRINGB4101
Pos . Sectioning Destination
12,0 3CW CONTROL - CYLINDERS 2-3 IGNITIO N COIL
32,0 MMASS
40 ,6 3BB CANISTE R PURGING VA LVE CONTRO L
80 ,6 3JN CONTROL - BLOWER RELAY
90 ,35 31A CONTROL - WATER TEMPERATURE INDICA TOR
12 0, 63BU IDLE RUNNI NG REGULATOR CONTROL 1
13 0, 63CS IGNAL + WATER TEMPERA TURE SENSOR
15 0, 353GN ATMOSPHERIC PRESSURE SENSOR M AS S
16 0, 353F ATMOSPHERIC PRESSURE SENSOR SIGNAL
19 0, 5 T B1 DETONATION SENSOR SCREENING
20 0, 53SS IGNAL + DETONATION SENSOR
24 0, 63BL SIGNAL - ENGINE RPM > RPM SENSOR
26 0, 35HL DIAGNOSIS SIGNAL - LINE L
28 2, 0 M M A S S
29 0, 35AP29 + AFTER PROTECTED CONTACT > FUSE OUTLET F03
30 0, 6 BP37 + PROTECTED BATTERY > FUSE OUTLET F04
32 2, 03CV CONTROL - CYLINDERS 1-4 IGNITIO N COIL
33 2, 0 M M A S S
34 0, 353F H CONTROL – INJECTION FAILURE INDICA TOR
39 0, 63GT ACTUATORS RELAY CONTROL
41 0, 63BV IDLE RUNNI NG REGULATOR CONTROL 2
42 0, 6 3BW IDLE RUNNI NG REGULATOR CONTROL 3
43 0, 6 3AJ SIGNAL +VALVE POSITION POTENTIOMETER
45 0, 63GK UPSTREAM OXYGEN SENSOR SIGNAL
49 0, 63BS IGNAL +AIR TEM PERATURE SENSOR
53 0, 3547F VEHICLE SPEED SIGNAL
54 0, 63BG SIGNAL - ENGINE RPM > RPM SENSOR
56 0, 35HK DIAGNOSIS SIGNAL - LINE K
58 0, 35H17I NJECTION CODED SIGNAL > ANTI-STARTER
59 1, 03CR CONTROL – INJECTOR 1
60 1, 03CT CONTROL – INJECTOR 3
63 1, 03GF CONTROL - UPSTREAM OXYGEN SENSOR HEATING
66 1, 03NR + INJECTORS > ACTUATORS RELAY OUTLE T
68 0, 6 3AC CONTROL - FUEL PUMP RELAY
70 0, 35H7 RPM-METER SIGNAL > INJECTION COMPUTER
72 0, 63BX IDLE RUNNI NG REGULATOR CONTROL 4
73 0, 63JK - WATER TEMPERA TURE
74 0, 6 3AQ SIGNAL + VAL VE POTENTIOMETER
75 0, 63JL - VALVE POTENTIOMETE R
77 0, 63JQ - AIR TEMPERA TURE SENSOR
78 0, 353D ATMOSPHERIC PRESSURE SENSOR > SUPPLY +
79 0, 53DQ - DETONATION SENSOR
80 0, 63GH UPSTREAM OXYGEN SENSOR MASS
89 1, 03CU CONTROL - INJECTOR 4
90 1, 03CS CONTROL – INJECTOR 2
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 30
Pos . SectioningDestination
12,0 3CW CONTROL - CYLIN DERS 2 -3 IGNITIO N COIL
32,0M M ASS
40 ,6 3BB CANISTER PURGIN G VALVE CO NTROL
80,63JN CONTROL - BLOWER RELAY
90 ,35 3 1 A CO N TROL - W AT E R T E MPERAT U RE IN D ICATOR
1 0 0 ,5 3 8 K AIR CO NDITIO NIN G SY STEM ST OPPIN G CO NTROL > IN J ECTIO N CO MPU TER
1 2 0 ,6 3 BU IDLE RU NNING REGULATOR CO NTROL 1
1 3 0 ,6 3C SIGNAL + WATER TEMPERATURE SENSOR
1 5 0 ,35 3 G N ATMOSPH ERIC PRESSURE SENSOR MASS
1 6 0 ,35 3 F ATMOSPH ERIC PRESSURE SENSOR SIGNAL
1 8 0 ,6 3 8 X FREON PRESSURE SENSOR SIGNAL
1 9 0 ,5 T B1 DETONATION SE NSOR SCREENIN G
2 0 0 ,5 3S SIGNAL + DETONATION SE NSOR
2 4 0 ,6 3BL SIGNAL - ENGIN E RPM > RPM SENSOR
2 6 0 ,35 H L DIAGNOSIS SIG NAL - LIN E L
2 8 2 ,0 M MA SS
2 9 0 ,35 A P2 9 + AFTER PRO TECTED CO NTACT > FUSE OUTLET F0 3
3 0 0 ,6 BP3 7 + PROTECTED BATTERY > FUSE O UTLET F0 4
3 2 2 ,0 3CV CONTROL - CYLIN DERS 1 -4 IGNITIO N COIL
3 3 2 ,0 M MA SS
3 4 0 ,35 3 FH CO N TROL – IN J ECTION FA IL URE INDICATOR
3 8 0 ,6 3 J P CONTROL – BLOWER RELAY TR.2
3 9 0 ,6 3 G T A CT UATORS RE LAY CO N TROL
4 1 0 ,6 3BV IDLE RU NNING REGULATOR CO NTROL 2
4 2 0 ,6 3BW IDLE RU NNING REGULATOR CO NTROL 3
4 3 0 ,6 3 A J SIGNAL +VALVE POSIT ION PO TENTIOMETER
4 5 0 ,6 3 G K UPSTREAM OXYGEN SENSOR SIGNAL
4 6 0 ,5 38AS AIR CO NDITIO NIN G COMPRESSOR CONNECTIO N SIGNAL
4 9 0 ,6 3B SIGNAL +AIR TEMPERATURE SE NSOR
5 3 0 ,35 4 7 F VEHICLE SPEED SIGNAL
5 4 0 ,6 3 BG SIGNAL - ENGIN E RPM > RPM SENSOR
5 6 0 ,35 H K DIAGNOSIS SIG NAL - LIN E K
5 8 0 ,35 H 1 7 INJECTIO N CODED SIG NAL > ANTI-ST ARTER
5 9 1 ,0 3CR CONTROL – INJECTOR 1
6 0 1 ,0 3 CT CONTROL – INJECTOR 3
6 3 1 ,0 3 G F CONTROL - UPSTREAM OXYGEN SENSOR H EATING
6 6 1 ,0 3 N R +INJECTORS > ACTUATORS RE LAY OUTLET
6 8 0 ,6 3 A C CONTROL - FUEL PUMP RELAY
7 0 0 ,35 H 7 RPM-ME T ER SIG N AL > IN J ECTIO N CO MPU TER
7 2 0 ,6 3 BX IDLE RU NNING REGULATOR CO NTROL 4
7 3 0 ,6 3 J K - W AT E R T E MPERAT U RE
7 4 0 ,6 3 A Q SIGNAL + VALVE POTENTIOMETER
7 5 0 ,6 3 J L - VALVE POTENTIO METER
7 7 0 ,6 3 J Q - AIR TEMPERATURE SE NSOR
7 8 0 ,35 3 D ATMOSPH ERIC PRESSURE SENSOR > SUPPLY +
ENGINE WIRINGB41 01
CO NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 40
ENGINE WIRINGB4101
CHOKE SENSOR
11 ,40 3NA1 + FUEL PUMP > CHOKE SENSOR
31,40 3NA + IGNITION COIL, CHOKE SENSOR > FUEL PUMP
RELAY
Pos . Sectioning Destination
AT M O S P HERIC PRESSURE SENSOR
Pos .Sectioning Destination
A
0,35 3GN Atmospheric pressure sensor mass
B 0,35 3F Atmospheric pressure sensor signal
C 0,35 3D Atmospheric pressure sensor > Supply +
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su