Page 4 of 100
2
Introduction
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning
lights .................................. 7-8
Hazard warning flashers ........ 9
Ignition switch and steering
lock ................................ 10-11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Clock .................................. 14
Display, ambient temperature.. 15
Cruise control ................ 16-19
Adjusting footrest
plate ............................... 20-21
Seat ............................... 22-23
Adjusting windscreen .......... 24
System case .................. 25-27Safety check
Checklist ........................ 28-29
Engine oil ....................... 30-31
Fuel ................................ 32-33
Handlebar levers ............ 34-35
Brake system
- general ........................ 36-37
Brake system - with
BMW Integral ABS ......... 38-41
Coolant level .................. 42-43
Clutch ................................. 44
Spring preload .................... 45
Shock-absorber
adjustment .......................... 46
Wheels ........................... 47-48
Accessories and tyres......... 49
Loads............................. 50-51
Lights ............................. 52-55
Contents
10k41bkg3.book Seite 2 Donnerstag, 27. Mai 2004 5:30 17
Page 32 of 100
30
Safety check
2
Engine oil
Checking oil levelCheck the oil level at regular
intervals.
Always check the oil level when
the engine is at operating tem-
perature, because the differ-
ence between the oil level
indicated when the engine is at
operating temperature and the
oil level indicated when the
engine is very cold due to
extremely low outdoor temper-
atures (-10 °C/14 °F) can be as
much as 10 mm (0.4 in).
After switching off the engine at
operating temperature, wait at
least 5 minutes for the oil to
drain back into the sump.Checking the oil level after the
engine has been run only briefly
or when it is not properly warm
will falsify the reading and could
lead to the engine being oper-
ated with the wrong quantity of
oil, because cold oil is viscous
and takes longer to drain back
into the sump.
Attention:
To avoid damage to the engine: – Never exceed the maximum
oil level.
– Always keep the level above
the minimum mark.
Always check the oil level with
the motorcycle upright.
• Check the oil level with the engine at its regular operating
temperature
• Check the oil level after the engine has been stopped for
at least 5 minutes
• Make sure that the motorcy-
cle is upright
– Make sure the ground is level and firm
10k41bkg3.book Seite 30 Donnerstag, 27. Mai 2004 5:30 17
Page 92 of 100
90
Index
i
AABSFault, 80
ABS - anti-lock brake system, 76
Adjusting footrest plate, 21
Adjusting headlight beam throw,
52, 53, 54
Adjusting headlight for opposite rule of the road, 53
Adjusting headlight for RHD/LHD traffic, 53
Anti-lock Brake System Notes, 76, 77, 78, 79, 80, 81
Anti-lock brake system, 74
BBMW Integral ABS, 74, 75, 76, 77, 78, 79, 80, 81
ABS - Anti-lock Brake System,
76
Brake booster, 76
Brake-fluid reservoir, 5
Changing brake fluid, 38
Checking brake fluid level, 38
RESIDUAL BRAKING
FUNCTION, 77
Safety reserves, 75
Self-diagnosis with pull-away
test, 78
Sensitive electronic control, 74
Troubleshooting chart, 81
Brake booster, 76
Brake fluid level Check Front brake, 40
Rear brake, 41
Brake system with BMW Integral ABS, 38,
39, 40
Brake system,
general, 36, 37
Brake system, checking, 36
CCapacity, 33
Case, 25
Catalytic convertor Safety instructions, 59
Checking brake pads, 37
Checking oil level, 30
Clock, 7, 14
Closing the system case, 26
Clutch lever, adjusting, 34
Cockpit Overview, 6
Cockpit instruments, 6
Coolant level Check, 42, 43
Coolant temperature, 68
Coolant temperature gauge, 6
Cruise control, 16, 17
Cruise-control system Notes, 16
Operation, 18, 19
A - C
10k41bkg3.book Seite 90 Donnerstag, 27. Mai 2004 5:30 17
Page 93 of 100
91
Index
i
DDisplay, ambient temperature, 7, 15
EEmergency off (kill) switch for ignition, 13
Engine oil, 31 Oil filler neck, 31
Engine oil pressure telltale light, 68
Engine speed, 70
FFront brake Brake fluid level, 40
Handbrake lever, 35
Fuel
Octane number, 33
Fuel filler cap, 4, 32
Fuel gauge, 6
Fuel tank capacity, 68
Fuse box, 4
GGear indicator, 7
Gearshift lever, 21
Gearshifts, 70, 71
General view, Left side, 4
Right side, 5
HHandlebar fitting
Left, 12
Right, 13
Handlebar lever Handbrake lever, 35
Hazard warning flashers, 9
Headlight basic setting, 55
Headlight switch, 12
Heated handlebar grips, 13
High-beam/low-beam headlight switch, 12
Horn, 12
Horn push, 12
IIgnition switch and steering lock, 6, 10
Function, 11
Installing system case, 27
Integral brake function, 76
KKeys, 10
LLHD traffic Headlight setting, 53
Lifting handle, 4
Light switch, 13
Lights, 52, 54, 55 Beam throw, 42, 53
Notes, 42
Loading, 49
D - L
10k41bkg3.book Seite 91 Donnerstag, 27. Mai 2004 5:30 17
Page 95 of 100
93
Index
i
TTank cap, 4
Telltale and warning lightsABS, 7, 68
Battery charge current, 8
Battery charge light, 69
Coolant temperature, 8, 69
Cruise control, 7
Engine oil pressure, 8, 68
High-beam headlight, 8
Low fuel level, 8, 68
Neutral, 7
Turn indicator, right, 7
Telltale lights Turn indicator, left, 7
Tools, 22
Tread depth, tyres, 47, 48
Troubleshooting ABS, 81
Troubleshooting chart, 81
Turn indicator switch, left, 12
Turn-indicator cancel switch, 13
Tyres Inflation pressure, 48
Running in, 65
WWarning lightsABS, 68
Battery charge light, 69
Coolant temperature, 69
Engine oil pressure, 68
General, 68
Low fuel level, 68
Warnings, braking, 72
T - Z
10k41bkg3.book Seite 93 Donnerstag, 27. Mai 2004 5:30 17
