2003 Hyundai H-1 (Grand Starex) inflation pressure

3-15
STARTING & OPERATING
STARTING & OPERATING STARTING & OPERATING
STARTING & OPERATING
STARTING & OPERATING
D170F01P-GAT (5)(5)
(5)(5)
(5) High speed
High speed High speed
High speed
High speed The higher the vehicles speed, the more fuel consumed. Avoid driving at full speed. Evena slight release of the accelerator pedal willsave significant amount of fuel.
GS30210A
Tire pressure gauge
D170G01P-GAT
(6)(6)
(6)(6)
(6) Tire inflation pressure
Tire inflation pressure Tire inflation pressure
Tire inflation pressure
Tire inflation pressure
GS30200A
D170E01P-GAT
(4)(4)
(4)(4)
(4) Idling
Idling Idling
Idling
Idling The vehicle consumes fuel even during idling. Avoid extended idling whenever possible.
D170C01P-GAT
(2)(2)
(2)(2)
(2) Shifting
Shifting Shifting
Shifting
Shifting Shift only at an appropriate vehicle speed and engine rpm. Always use the highest gear possible.Fuel consumption depends largely on the manner in which vehicle is driven but it isalso affected by other driving conditions.
D170D01P-GAT (3)(3)
(3)(3)
(3) City traffic
City traffic City traffic
City traffic
City traffic Frequent starting and stopping increases the average fuel consumption. Use roadswith smooth traffic flow whenever possible.When driving on congested roads, avoiduse of a low gear at high engine rpm.
Check the tire inflation pressure at regularintervals. Low tire inflation pressures in-crease road resistance and fuel consump-tion. In addition, low tire pressures adverselyaffect tire wear and driving control.D170H01P-GAT
(7)(7)
(7)(7)
(7) Load
Load Load
Load
Load
GS30220A
Do not drive with unnecessary articles in the luggage compartment.Especially during city driving where frequentstarting and stopping is necessary, the in-creased weight of the vehicle will greatlyaffect fuel consumption. Also avoid driving with unnecessary lug- gage, etc., on the roof; the increased airresistance will cause more fuel consump-tion.
D170I01P-GAT (8)(8)
(8)(8)
(8) Cold engine starting
Cold engine starting Cold engine starting
Cold engine starting
Cold engine starting Starting of a cold engine consumes more fuel. Unnecessary fuel consumption is alsocaused by keeping a hot engine running.After the engine is started, begin drivingsoon.

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-6 I040A01P-GAT
Vehicle Interior
Vehicle Interior Vehicle Interior
Vehicle Interior
Vehicle Interior
The following should be checked each time when the vehicle is driven:
o Light operation
o Windshield wiper operation
o Horn operation
o Defroster, heater operation (and air condi- tioning, if equipped)
o Steering operation and condition
o Mirror condition and operation
o Turn signal operation
o Accelerator pedal operation
o Brake operation, including parking brake
o Manual transmission operation, including clutch operation
o Automatic transmission operation, including "Park" mechanism operation
o Seat control condition and operation
o Seat belt condition and operation
o Sunvisor operation
If you notice anything that does not operate correctly or appear to be functioning correctly,inspect it carefully and seek assistance fromyour Hyundai dealer if service is needed. Adequate care of your vehicle at regular inter- vals serves to preserve the value and appear-ance as long as possible. Some maintenance items can be carried out bythe owner (Consumer Information), while othershould be done only by an authorized dealer(Periodic Inspection and Maintenance). Thissection describes only those items which canbe carried out by the owner. In the event amalfunction or other problem is discovered,have it corrected by an authorized HYUNDAIdealer. This section contains information oninspection maintenance procedures that youcan do yourself, if you so desire. Follow theinstructions and cautions for each of the vari-ous procedures. When checking or servicing the inside of the engine compartment, be sure the engine isstopped and has had a chance to cool down. Ifit is necessary to do work in the engine com-partment with the engine running, be especiallycareful that your clothing, hair, etc., becomesnot caught by the fan, V-belts, or other movingparts. I050A01P-GAT
Inspection items
Inspection items Inspection items
Inspection items
Inspection items
( 1 ) Engine oil
( 2 ) Engine coolant
(3) Battery
( 4 ) Brake fluid
( 5 ) Clutch fluid (hydraulic clutch only)
( 6 ) Washer fluid
( 7 ) Wheel condition (including spare wheel)
(8) Tire inflation pressure (including spare
wheel)
I020A02P-GAT
GENERAL CHECKS
GENERAL CHECKS GENERAL CHECKS
GENERAL CHECKS
GENERAL CHECKS
Engine Compartment
Engine Compartment Engine Compartment
Engine Compartment
Engine Compartment The following should be checked regularly:
o Engine oil level and condition
o Transmission fluid level and condition
o Brake fluid level
o Clutch fluid level
o Engine coolant level
o Windshield washer fluid level
o Accessory drive belt condition
o Coolant hose condition
o Fluid leaks (on or below components)
o Power steering fluid level and condition
o Tire pressure and condition (including spare)
o Battery condition I030A02P-GAT
Vehicle Exterior
Vehicle Exterior Vehicle Exterior
Vehicle Exterior
Vehicle Exterior The following should be checked monthly:
o Overall appearance and condition
o Wheel condition and wheel nut tightness
o Air cleaner filter condition
o Exhaust system condition
o Light condition and operation
o Windshield glass condition
o Wiper blade condition
o Paint condition and corrosion
o Fluid leaks
o Door and hood lock condition

8-13
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I200A01P-GAG


30 mm (1.2 in.)
I200A01P-GAT
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
Check by moving the steering wheel left and
right. The free play at the circumference should not
exceed the standard value.
Free play 30 mm (1.2 in.) If the steering wheel free play exceeds the
standard value, have the steering wheel ad- justed at an authorized HYUNDAI dealer.
I170A01P-GAT
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
Look under the body of your vehicle to check
for fuel, engine coolant, oil, and exhaust gasleaks. If leaks are evident, take your vehicle to an
authorized HYUNDAI dealer for inspection.
I160A02P-GAT
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
Check the tire inflation pressure of all the tires
while they are cold; if insufficient or excessive,adjust to the specified value.
After the tire inflation pressure has been ad-
justed, check the tires for damage and airleaks.
Be sure to put rubber caps on the valves.
kg/cm² (PSI)
Mini- Bus Tire size
195R 14C-6PR 205/70R 15 215/80R 15
205/70R 15C-6PR Rear
2.8(40)2.8(40)2.2(32) 2.8(40) Front
2.8(40) 2.8(40)2.2(32)2.8(40)
Up to 3 persons Up to
MAX. load
Rear
3.5(50)2.8(40)2.2(32)3.5(50)
Front
2.8(40) 2.8(40) 2.2(32)2.8(40)
Veh- icle
kg/cm² (PSI)
Vehicle
VAN
TRUCK Tire size
195R 14C-8PR 195R 14C-6PR195R 13C-8PR Rear
4.5(65) -
3.5(50)
Front
2.8(40)2.8(40)
-
I180A01P-GATEXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP- EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
ERATION
ERATION ERATION
ERATION
ERATION
Operate the light switch and combination switch
to confirm that all lamps are functioning prop- erly.
If the lamps do not go on, the probable cause
is a blown fuse or defective lamp bulb. Checkthe fuses first. If there is no blown fuse, checkthe lamp bulbs.
For information regarding the inspection and
replacement of the fuses and the lamp bulbs,refer to the section entitled "In case of emer-gency" If the fuses and bulbs are all OK, take the
vehicle to an authorized HYUNDAI dealer forinspection.
I190A01P-GATMETER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/ METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
WARNING LAMP OPERATION
WARNING LAMP OPERATION WARNING LAMP OPERATION
WARNING LAMP OPERATION
WARNING LAMP OPERATION
Run the engine to check the operation of all
meters, gauge, and indication/ warning lamps.If there is anything wrong, take the vehicle toan authorized HYUNDAI dealer for inspection.

INDEX
INDEX INDEX
INDEX
INDEX
10-4 SPARE TIRE ANTI-THEFT DEVICE
.................................................... 4-5
SPARE WHEEL ............................................................................. 4 - 4 ~ 4 - 5
SPEEDOMETER ........................................................................................ 2-5
SRS AIRBAG SYSTEM ........................................................... 1-29 ~ 1-32
SRS (Airbag) SERVICE REMINDER INDICATOR ........................2-10
STARTING THE ENGINE ....................................................................... 3-2
STARTING AND STOPPING THE ENGINE FOR TURBO CHARGER OR TURBO CHARGER INTERCOOLER .................. 3-3
STEERING WHEEL FREE PLAY ......................................................8-13
STEERING WHEEL TILT LEVER ......................................................1-29
STEREO RADIO AND CASSETTE TAPE PLAYER OPERATION (K220) .............................................................. 2-33 ~ 2-36
STEREO RADIO AND CASSETTE TAPE PLAYER OPERATION (H240, K240) ..................................................2-37 ~ 2-40
STEREO RADIO AND CASSETTE TAPE AND COMPACT DISC
PLAYER OPERATION (H280) ............................................2-48 ~ 2-54
STEREO RADIO AND COMPACT DISC PLAYER
OPERATION (H260) .............................................................. 2-41 ~ 2-47
SUNROOF ................................................................................... 2-19 ~ 2-20
SUN SHADE ............................................................................................ 2-19
SUN VISOR .............................................................................................. 2-20
T TACHOMETER ........................................................................................... 2-5
TAILGATE WINDOW WASHER FLUID LEVEL .............................8-12
TAILGATE WIPER AND WASHER SWITCH .................................2-13
TAILGATE .................................................................................................... 1-9
THEFT-ALARM SYSTEM ........................................................ 1-10 ~ 1-11THERMOMETER
....................................................................................... 2-7
THIRD SEAT ............................................................................... 1-20 ~ 1-21
TIRE INFLATION PRESSURE ............................................................ 8-13
TOOLS AND JACK ................................................................................... 4-1
TOWING ....................................................................................................... 4-8
TRAILER OR VEHICLE TOWING ..........................................4-8 ~ 4-11
TRANSAXLE FLUID .................................................................................. 9-4
TURN-SIGNAL INDICATION LAMPS-GREEN .................................. 2-9
TURN-SIGNAL SWITCH ....................................................................... 2-11
TWIN SWING DOOR ............................................................................ 1-14
V VENTILATION .......................................................................................... 2-25
VEHICLE IDENTIFICATION NUMBER (VIN) ..................................... 1-2
W WATER TEMPERATURE GAUGE ....................................................... 2-6
WHEEL CONDITION ............................................................................. 8-12
WHEEL ROTATION ............................................................................... 8-15
WINDSHIELD WASHER FLUID LEVEL ...........................................8-12
WINDSHIELD WASHER ....................................................................... 2-12
WINDSHIELD WIPER AND WASHER SWITCH ...........................2-12