2003 Hyundai H-1 (Grand Starex) power steering

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-8 The regulations concerning towing may differ from country to country. It is recommended thatyou may obey the regulations in your area. Ifyour vehicle is to be towed, pay careful atten-tion to the following points.
C190A01A-GATTRAILER OR VEHICLE TOWING
TRAILER OR VEHICLE TOWING TRAILER OR VEHICLE TOWING
TRAILER OR VEHICLE TOWING
TRAILER OR VEHICLE TOWING
If you are considering towing with your car, youshould first check with your Province Depart-ment of Motor Vehicles to determine their legal requirements.Since laws vary from province to province, the requirements for towing trailers, cars, othertypes of vehicles, or apparatus may differ. Askyour Hyundai dealer for further details beforetowing.
GX40250A
Rear (Minbus, Van)Towing hook
(1) Move the gearshift lever to neutral.
(2) Be sure the towing speed is within the legal limit.
(3) On vehicles with steering lock system, turn the ignition switch to "ACC" to unlock the steering wheel. If you will be using the turnsignals while being towed, turn the ignitionswitch to "ON" position.
(4) To prevent the exhaust gas from entering the towing vehicle, set the air selection leveron the heater control to the recirculationposition.
(5) Turn on the hazard warning lamps.
(6) During towing, make sure that close contact is maintained between the drivers of both vehicles, and that the vehicles travel at low speed. Avoid abrupt starting or stoppingwhich might subject the vehicles to shock.
(7) If the transmission is malfunctioning or dam- aged, tow the vehicle with the rear wheelsraised off the ground.
(8) If the vehicle is equipped with a brake boost- er system, the brake boosting power will belost and greater force will be required todepress the brake pedal.
(9) If the vehicle is equipped with a power steering system, greater force will be re-quired to operate the steering wheel.
NOTE:
NOTE: NOTE:
NOTE:
NOTE:
Your vehicle should only be used to tow
Your vehicle should only be used to tow Your vehicle should only be used to tow
Your vehicle should only be used to tow
Your vehicle should only be used to tow another vehicle if the weight of the other
another vehicle if the weight of the other another vehicle if the weight of the other
another vehicle if the weight of the other
another vehicle if the weight of the other
vehicle is less than that of your vehicle.
vehicle is less than that of your vehicle. vehicle is less than that of your vehicle.
vehicle is less than that of your vehicle.
vehicle is less than that of your vehicle.
E070A01P-GAT
TOWING
TOWING TOWING
TOWING
TOWING
GX40240A
Front (Minbus, Van)
Towing hook
Tow at the illustrated point. Using any part other than the designated towing
hooks could result in damage to vehicle body.
GY40240B
Front (Truck)
13. After the spare tire is once again replaced
by the original tire, adjust the inflation pres- sure to the correct specification.

8-1
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
1. Windshield washer fluid reservoir cap
2. Engine oil filler cap
3. Engine oil level dipstick
4. Brake booster 5. Brake fluid reservoir
6. Engine coolant reservoir
7. Radiator cap
8. Air cleaner 9. Power steering fluid reservoir
10. Battery
I000A01P-GAT
8.8.
8.8.
8.
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I010A01P-GAT DIESEL E
DIESEL E DIESEL E
DIESEL E
DIESEL E NGINE
NGINE NGINE
NGINE
NGINE R R
R R
R
OOM (F
OOM (F OOM (F
OOM (F
OOM (F
or 2.6 N/A)
or 2.6 N/A) or 2.6 N/A)
or 2.6 N/A)
or 2.6 N/A)
I010A01P-1
123
45 67
10
9
8
88
88
8

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-2
I010D01P
12 345 67
10
9
8
1. Windshield washer fluid reservoir cap
2. Engine oil filler cap
3. Engine oil level dipstick
4. Brake booster 5. Brake fluid reservoir
6. Engine coolant reservoir
7. Radiator cap
8. Air cleaner 9. Power steering fluid reservoir
10. Battery
1 1 . Fuse and relay box
I010D01P-GAT
DIESEL ENGINE ROOM (For 2.5 4D56 T/C)
DIESEL ENGINE ROOM (For 2.5 4D56 T/C) DIESEL ENGINE ROOM (For 2.5 4D56 T/C)
DIESEL ENGINE ROOM (For 2.5 4D56 T/C)
DIESEL ENGINE ROOM (For 2.5 4D56 T/C)
11

8-3
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I010B01P
1. Windshield washer fluid reservoir cap
2. Automatic transmission fluid level dipstick (A/T only)
3. Engine oil filler cap
4. Engine oil level dipstick 5. Brake booster
6. Brake fluid reservoir
7. Engine coolant reservoir
8. Air cleaner
9. Power steering fluid reservoir
10. Battery
1 1 . Fuse and relay box
12
3 456 7
8 91
011
I010B01P-GAT
DIESEL ENGINE ROOM (For 2.5 4D56 TCI)
DIESEL ENGINE ROOM (For 2.5 4D56 TCI) DIESEL ENGINE ROOM (For 2.5 4D56 TCI)
DIESEL ENGINE ROOM (For 2.5 4D56 TCI)
DIESEL ENGINE ROOM (For 2.5 4D56 TCI)

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-4
I010C01P
1. Windshield washer fluid reservoir cap
2. Engine oil filler cap
3. Brake booster 4. Brake fluid reservoir
5. Engine coolant reservoir
6. Air cleaner
12
34 5
6 79
10
I010C01P-GAT
DIESEL ENGINE ROOM (For 2.5 CRDi TCI)
DIESEL ENGINE ROOM (For 2.5 CRDi TCI) DIESEL ENGINE ROOM (For 2.5 CRDi TCI)
DIESEL ENGINE ROOM (For 2.5 CRDi TCI)
DIESEL ENGINE ROOM (For 2.5 CRDi TCI)
8
7. Power steering fluid reservoir
8. Engine oil level dipstick
9. Battery
1 0 . Fuse and relay box

8-5
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
1. Washer tank cap
2. Engine oil filler cap
3. Engine oil level gauge
4. Brake booster 5. Brake fluid reservoir
6. Radiator cap
7. Air cleaner
8. Power steering oil tank
9. Battery
10. Fuse box
123456
78910
I011A01P-2
I011A02P-GAT
GASOLINE ENGINE ROOM
GASOLINE ENGINE ROOM GASOLINE ENGINE ROOM
GASOLINE ENGINE ROOM
GASOLINE ENGINE ROOM

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-6 I040A01P-GAT
Vehicle Interior
Vehicle Interior Vehicle Interior
Vehicle Interior
Vehicle Interior
The following should be checked each time when the vehicle is driven:
o Light operation
o Windshield wiper operation
o Horn operation
o Defroster, heater operation (and air condi- tioning, if equipped)
o Steering operation and condition
o Mirror condition and operation
o Turn signal operation
o Accelerator pedal operation
o Brake operation, including parking brake
o Manual transmission operation, including clutch operation
o Automatic transmission operation, including "Park" mechanism operation
o Seat control condition and operation
o Seat belt condition and operation
o Sunvisor operation
If you notice anything that does not operate correctly or appear to be functioning correctly,inspect it carefully and seek assistance fromyour Hyundai dealer if service is needed. Adequate care of your vehicle at regular inter- vals serves to preserve the value and appear-ance as long as possible. Some maintenance items can be carried out bythe owner (Consumer Information), while othershould be done only by an authorized dealer(Periodic Inspection and Maintenance). Thissection describes only those items which canbe carried out by the owner. In the event amalfunction or other problem is discovered,have it corrected by an authorized HYUNDAIdealer. This section contains information oninspection maintenance procedures that youcan do yourself, if you so desire. Follow theinstructions and cautions for each of the vari-ous procedures. When checking or servicing the inside of the engine compartment, be sure the engine isstopped and has had a chance to cool down. Ifit is necessary to do work in the engine com-partment with the engine running, be especiallycareful that your clothing, hair, etc., becomesnot caught by the fan, V-belts, or other movingparts. I050A01P-GAT
Inspection items
Inspection items Inspection items
Inspection items
Inspection items
( 1 ) Engine oil
( 2 ) Engine coolant
(3) Battery
( 4 ) Brake fluid
( 5 ) Clutch fluid (hydraulic clutch only)
( 6 ) Washer fluid
( 7 ) Wheel condition (including spare wheel)
(8) Tire inflation pressure (including spare
wheel)
I020A02P-GAT
GENERAL CHECKS
GENERAL CHECKS GENERAL CHECKS
GENERAL CHECKS
GENERAL CHECKS
Engine Compartment
Engine Compartment Engine Compartment
Engine Compartment
Engine Compartment The following should be checked regularly:
o Engine oil level and condition
o Transmission fluid level and condition
o Brake fluid level
o Clutch fluid level
o Engine coolant level
o Windshield washer fluid level
o Accessory drive belt condition
o Coolant hose condition
o Fluid leaks (on or below components)
o Power steering fluid level and condition
o Tire pressure and condition (including spare)
o Battery condition I030A02P-GAT
Vehicle Exterior
Vehicle Exterior Vehicle Exterior
Vehicle Exterior
Vehicle Exterior The following should be checked monthly:
o Overall appearance and condition
o Wheel condition and wheel nut tightness
o Air cleaner filter condition
o Exhaust system condition
o Light condition and operation
o Windshield glass condition
o Wiper blade condition
o Paint condition and corrosion
o Fluid leaks
o Door and hood lock condition

VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
9-4 Quantity (liter)
Minibus, Van : 1.3 0.8
Minibus : 13, Van : 10, Truck : 7.2 As required As required
Minibus, Van : 2.6, Truck : 1.7
As required Diesel
2.6 N/A(long Van) : 8.5 2.6 N/A : 72.5 4D56 T/C : 8.52.5 4D56 TCI(3Van, 11/12Minibuss) : 8.52.5 4D56 TCI EURO III(3Van, 11/12Minibuss) : 7.53
2.5 4D56 TCI EURO III(6Van, 7/9Minibuss) : 7.53
2.5 4D56 TCI(4WD) : 9.832.5 CRDi TCI(2WD) : 8.32.5 CRDi TCI(4WD) : 11.7
Recommended in field
HYUNDAI GENUINE PARTS MTF 75W/90 (API GL-4) DIAMOND ATF DEXRON II, DIAMOND ATF SP I
DIAMOND ATF SP II
PSF-3 HIGH QUALITY ETHYLENE GLYCOL BASE FOR ALUMINUM RADIATORSAE J 1703 EQUIVALENTSAE J310a, MULTI-PURPOSE GREASE NLGI-2 OREQUIVALENT.
API GL-4 (MS517-15) : SAE 90, 140
API GL-5 (MS517-15) : SAE 80
Items
MANUAL TRANSMISSION OIL AUTOMATIC TRANSMISSION OIL TRANSFER CASE OIL POWER STEERING OIL COOLANT CLUTCH & BRAKE FLUIDFRONT, REAR WHEEL BEARING REAR AXLE STEERING GEAR BOX
Gasoline 2.0 Diesel
2.6 N/A : 2.0 2.5 4D56 T/C or TCI : 2.42.5 CRDi TCI : 3.2
Gasoline
7.53
J060A05P-GATLUBRCATION CHART
LUBRCATION CHART LUBRCATION CHART
LUBRCATION CHART
LUBRCATION CHART