2003 Hyundai H-1 (Grand Starex) ignition

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-14 The following points should be observed:
1. Both batteries must be 12V. The capacity
(Ah) of the battery supplying current should not be significantly below that of the dis-charged battery.
2. Use only heavy-duty jumper cables.
3. A discharged battery can freeze. A frozen battery must be thawed out before connect- ing the jumper cables.
4. There should be no contact between the two vehicles; otherwise current may flow whenthe positive terminal is connected.
5. The discharged battery must be correctly connected to the vehicle electrical system.
6. Run the engine of the vehicle supplying current.
7. Connect the jumper cables as follows:
(1) Connect one end of one jumper cable to the positive terminal of the flat battery, and the other end to the positive terminal of thebooster battery.
(2) Connect one end of the other jumper cable to the negative terminal of the booster bat-tery, and the other end to the engine blockof the vehicle with the flat battery at the pointfarthest from the battery.
GS40330A
E110A02P-GAG
If the engine cannot be started because the battery is weak or dead, the battery from an-other vehicle can be used with jumper cables tostart the engine.
E110A01P-GAT
EMERGENCY STARTING
EMERGENCY STARTING EMERGENCY STARTING
EMERGENCY STARTING
EMERGENCY STARTING
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
Do not attempt to start the engine by pulling
Do not attempt to start the engine by pulling Do not attempt to start the engine by pulling
Do not attempt to start the engine by pulling
Do not attempt to start the engine by pulling
or pushing the vehicle.
or pushing the vehicle. or pushing the vehicle.
or pushing the vehicle.
or pushing the vehicle.
2. Operate the hand pump slowly 6 or 7 times
in order to force the water out through thedrain plug.
3. Tighten the drain plug when water no longer comes out.
4. Loosen the air plug and bleed the air. (Refer to "Bleeding the fuel system".)
5. Check to be sure that the warning lamp illuminates when the ignition key is turned to"ON", and that it goes off when the engine isstarted.If in doubt, consult your nearest authorizedHYUNDAI dealer.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
(1)(1)
(1)(1)
(1) Do not smoke or have any other open
Do not smoke or have any other open Do not smoke or have any other open
Do not smoke or have any other open
Do not smoke or have any other open
flame near the vehicle while bleeding the
flame near the vehicle while bleeding the flame near the vehicle while bleeding the
flame near the vehicle while bleeding the
flame near the vehicle while bleeding the
fuel system.
fuel system. fuel system.
fuel system.
fuel system.
(2)(2)
(2)(2)
(2) Be sure to carefully wipe away any water
Be sure to carefully wipe away any water Be sure to carefully wipe away any water
Be sure to carefully wipe away any water
Be sure to carefully wipe away any water
drained out in this manner, because the
drained out in this manner, because the drained out in this manner, because the
drained out in this manner, because the
drained out in this manner, because the
fuel mixed in the water might be ignited
fuel mixed in the water might be ignited fuel mixed in the water might be ignited
fuel mixed in the water might be ignited
fuel mixed in the water might be ignited
and result in a fire.
and result in a fire. and result in a fire.
and result in a fire.
and result in a fire.

8-11
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I120D02P-GAT To Check the
To Check the To Check the
To Check the
To Check the T ransmission
Fluid Level
Fluid Level Fluid Level
Fluid Level
Fluid Level
D060A01P-GAG
Button
Park the vehicle on level ground with the park-
ing brake engaged. When the transmission fluid level is checked, the transmission fluidshould be at normal operating temperature andthe engine idling.
While the engine is idling, apply the brakes and
move the gear selector lever from "P" to eachof its other positions-"R", "N", "D", "2", "L"-andthen return to "N" or "P" with the engine stillidling:
I120D02P-GAG
Full mark Good
1. Open the hood, being careful to keep hands, long hair and clothing clear of any moving parts.
2. Remove the transmission dipstick, wipe it clean, reinsert the dipstick as far as it will go, then remove it again. Now check thefluid level on the dipstick. It should be in the"HOT" range on the dipstick.
3. If the transmission fluid level is low, use a funnel to add transmission fluid through thedipstick tube until the level reaches the"HOT" range. Do not overfill, otherwise thetransmission could be damaged.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
The radiator fan is controlled by engine
The radiator fan is controlled by engine The radiator fan is controlled by engine
The radiator fan is controlled by engine
The radiator fan is controlled by engine
coolant temperature and may sometimes
coolant temperature and may sometimes coolant temperature and may sometimes
coolant temperature and may sometimes
coolant temperature and may sometimes
operate even after the ignition key has even
operate even after the ignition key has even operate even after the ignition key has even
operate even after the ignition key has even
operate even after the ignition key has even
turned off. Use extreme caution when work-
turned off. Use extreme caution when work- turned off. Use extreme caution when work-
turned off. Use extreme caution when work-
turned off. Use extreme caution when work-
ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so
that you are not injured by a rotating fan
that you are not injured by a rotating fan that you are not injured by a rotating fan
that you are not injured by a rotating fan
that you are not injured by a rotating fan
blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases, blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases,
I120A01P-GAT
CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC
TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed) TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed)
Transmission fluid in the automatic transmis-
sion should be changed at those intervals speci-fied in the vehicle maintenance schedule inSection 6.
I120B01P-GATRecommended Fluid
Recommended Fluid Recommended Fluid
Recommended Fluid
Recommended Fluid
Your Hyundai automatic transmission is specially
designed to operate with " DIAMOND ATF
DEXRON II" or "DIAMOND ATF SP I" type
fluid.
I120C02P-GATAA
AA
A
utomatic
utomatic utomatic
utomatic
utomatic transmission
fluid capacity
fluid capacity fluid capacity
fluid capacity
fluid capacity
The fluid capacity of the automatic transmis-
sion will be found on page 9-4.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
The transmission fluid level should be
The transmission fluid level should be The transmission fluid level should be
The transmission fluid level should be
The transmission fluid level should be checked when the engine is at normal oper-
checked when the engine is at normal oper- checked when the engine is at normal oper-
checked when the engine is at normal oper-
checked when the engine is at normal oper-
ating temperature. This means that the en-
ating temperature. This means that the en- ating temperature. This means that the en-
ating temperature. This means that the en-
ating temperature. This means that the en-
gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very
hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself
during this procedure.
during this procedure. during this procedure.
during this procedure.
during this procedure.

VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
9-2 D4BH(TCI)

ATDC 9°
D4BF(T/C)
2,476 cc
21
ATDC 7°
750 ± 100
J040A04P-GAT
ENGINE
ENGINE ENGINE
ENGINE
ENGINE
ITEMS Engine type Total displacement Compression ratio Firing order Injection (or Ignition) timing Idle speed (RPM) D4BB(N/A)
2,607 cc
22
1 - 3 - 4 - 2
ATDC 5°
850 ± 100DIESEL
DIESEL
12V-90AH MF, *100AH MF 12V-75A/110A
12V-2.0 kw, 2.2 kw (A/TM)ITEMS Battery Generator Starter
J050A03P-GAT ELECTRICAL
ELECTRICAL ELECTRICAL
ELECTRICAL
ELECTRICAL
GASOLINE (Minibus, Van)12V-68AH MF13.5V-95A
12V-1.2 kw
* FOR USE ONLY IN COLD AREA
GASOLINE G4JS
2,351 cc 10

BTDC 5°± 2°
750 ± 100
D4CB(TCI)
2,497 cc
17.6
-
800 ± 100

INDEX
INDEX INDEX
INDEX
INDEX
10-2 EMISSION CONTROL SYSTEM
........................................................... 7-1
ENGINE ........................................................................................................ 9-2
ENGINE COOLANT .................................................................................. 8-9
ENGINE NUMBER .................................................................................... 1-2
ENGINE OIL .................................................................................... 8 - 7 ~ 8 - 8
ENGINE OVERHEATING ........................................................ 4-11 ~ 4-12
ENGINE RPM ADJUSTMENT KNOB ...............................................2-15
ENGINE WARNING LIGHT ................................................................. 2-10
EXTERIOR AND INTERIOR LAMP OPERATION .........................8-13
F FOUR-WHEEL DRIVE (4WD) ..................................................3-9 ~ 3-10
FOURTH SEAT ....................................................................................... 1-21
FRONT DOOR EDGE WARNING LIGHT .......................................2-15
FRONT DOOR WINDOW GLASS .....................................................1-17
FRONT FOG LAMP SWITCH ........................................................... 2-16
FRONT INTERIOR LIGHT ................................................................... 2-17
FRONT ROOM LAMP ........................................................................... 2-18
FRONT SEATS ....................................................................................... 1-18
FUEL FILTER WARNING LAMP-RED ................................................. 2-9
FUEL GAUGE ............................................................................................. 2-5
FUEL TANK CAPACITY .......................................................................... 9-1
FUEL, ENGINE COOLANT, OIL, AND EXHAUST GAS LEAKAGE .................................................................................... 8-13
FUSES ....................................................................................................... 4-15
G GASOLINE ENGINE ROOM .................................................................. 8-5
GOOD BRAKING PRACTICE ............................................................. 3-11H
HAZARD WARNING LIGHT SWITCH ..............................................2-16
HEADLAMP LEVELING DEVICE SYSTEM ....................................2-14
HEADREST .............................................................................................. 1-22
HEATING AND COOLING ...................................................... 2-24 ~ 2-25
HEATING CONTROLS .......................................................................... 2-25
HEIGHT ADJUSTABLE FRONT SEAT SHOULDER BELT .......1-23
HIGH-BEAM INDICATION LAMP-BLUE .............................................. 2-9
HIGH-BEAM SWITCH ........................................................................... 2-11
HINGED WINDOW .................................................................... 1-16 ~ 1-17
HINGES AND LATCHES LUBRICATION ........................................8-15
"HOLD" MODE SWITCH ......................................................................... 3-7
HOOD RELEASE .................................................................................... 1-12
HORN SWITCH ....................................................................................... 2-17
I IF A TIRE IS FLATENED ............................................................ 4 - 6 ~ 4 - 8
IF THE ENGINE OVERHEATS .............................................4-11 ~ 4-12
IGNITION SWITCH ................................................................................... 3-1
ILLUMINATED IGNITION SWITCH ...................................................... 1-8
IMMOBILIZER SYSTEM .............................................................. 1 - 5 ~ 1 - 8
INCLINOMETER ......................................................................................... 2-6
INDEX ........................................................................................................ 10-1
INDICATION AND WARNING LAMPS ..................................2-9 ~ 2-10
INSIDE REAR-VIEW MIRROR ........................................................... 2-21
INSTALLATION OF ACCESSORIES ................................................... 1-3
INSTRUMENTS .......................................................................................... 2-3
INSTRUMENTS PANEL LIGHT CONTROL (=RHEOSTAT) ......2-14