2003 DAEWOO MATIZ tailgate

9D –8 WIPERS/WASHER SYSTEMS
DAEWOO M-150 BL2
D109D526
Installation Procedure
1. Install the wiper motor to the engine room with the
bolts.
a. Wiper motor assembly bolt.
2. Connect the electrical connector.
D109D527
3. Install the wiper linkage to the wiper motor linkage
ball.
b. Wiper linkage ball.
D109D528
4. Install the cowl vent grille. Refer to Section 9R, Body
Front End.
5. Install the windshield wiper arm. Refer to “Windshield
Wiper Arm” in this section.
6. Connect the negative battery cable.
D19D529A
REAR WINDOW WIPER MOTOR
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the wiper arm from the tailgate. Refer to
“Windshield Wiper Arm” in this section.
3. Remove the tailgate inside trim. Refer to Section 9G,
Interior Trim.
4. Remove the rear wiper motor assembly.

Disconnect the electrical connector (1).

Remove the screws (2).

Remove the rear wiper motor assembly (3).

WIPERS/WASHER SYSTEMS 9D–9
DAEWOO M-150 BL2
D19D530A
Caution: Because the wiper motor link plate is
fixed, do not separate the wiper motor from the
bracket.
D19D531A
Installation Procedure
1. Install the wiper motor assembly to the tailgate with
the screws.
2. Connect the electrical connector.
3. Install the tailgate inside trim. Refer to Section 9G, In-
terior Trim.
4. Install the wiper arm. Refer to “Windshield Wiper
Arm” in this section.
5. Connect the negative battery cable.
D109D523
WINDSHIELD WIPER LINKAGE
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Removal Procedure
1. Remove the windshield wiper arms. Refer to ”Wind-
shield Wiper Arm” in this section.
2. Remove the cowl vent grille. Refer to Section 9R,
Body Front End.
3. Separate the wiper linkage from the wiper motor.

Separate the wiper linkage from the wiper motor
linkage ball (1).
D109D532
4. Remove the wiper linkage.

Remove the wiper linkage nuts (1).

Remove the wiper linkage (2).

AUDIO SYSTEMS 9F–9
DAEWOO M-150 BL2
D109D557
FRONT SPEAKER COVERS
Removal Procedure
1. Remove the door trim panel. Refer to Section 9G, In-
terior Trim.
2. Remove the speaker cover from the door trim panel.

Remove the screws (1).

Remove the speaker cover (2).
D109D558
Installation Procedure
1. Install the speaker cover to the door trim panel with
the screws.
2. Install the door trim panel. Refer to Section 9G, Interi-
or Trim.
D109D559
REAR SPEAKERS
Removal Procedure
1. Disconnect the negative battery cable.
2. Open the tailgate.
3. Remove the rear speaker from the rear parcel side
shelf.

Disconnect the electrical connector (1).

Remove the screws (2).

Remove the rear speaker (3).
D109D560
Installation Procedure
1. Install the rear speaker to the rear parcel side shelf
with the screws.
2. Connect the electrical connector.
3. Connect the negative battery cable.

DAEWOO M-150 BL2
SECTION 9G
INTERIOR TRIM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 9G-2. . . . . . . . . . . . . . . . . .
Interior Trim Panels 9G-2. . . . . . . . . . . . . . . . . . . . . . . .
Pressure Relief Vent 9G-2. . . . . . . . . . . . . . . . . . . . . . .
Floor Console 9G-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Cable Cover 9G-2. . . . . . . . . . . . . . . . .
Floor Carpet 9G-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Component Locator 9G-3. . . . . . . . . . . . . . . . . . . . . . . .
Interior Trim 9G-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions 9G-4. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 9G-4. . . . . . . . . . . . . . . . . . . . . . . . . .
Front Door Trim Panel (Standard) 9G-4. . . . . . . . . . .
Front Door Trim Panel (Deluxe) 9G-5. . . . . . . . . . . . .
Rear Door Trim Panel (Standard) 9G-6. . . . . . . . . . . .
Rear Door Trim Panel (Deluxe) 9G-7. . . . . . . . . . . . . .
Rear Door Interior Garnish Molding 9G-8. . . . . . . . . .
Rear Door Exterior Garnish Molding 9G-9. . . . . . . . . Tailgate Trim Panel 9G-9. . . . . . . . . . . . . . . . . . . . . . . .
A–Pillar Trim Panel 9G-10. . . . . . . . . . . . . . . . . . . . . . .
Upper B–Piller Trim Panel 9G-10. . . . . . . . . . . . . . . . .
Lower B–Pillar Trim Panel 9G-11. . . . . . . . . . . . . . . . .
C–Pillar Trim Panel 9G-11. . . . . . . . . . . . . . . . . . . . . . .
Rear Parcel Shelf 9G-12. . . . . . . . . . . . . . . . . . . . . . . .
Rear Parcel Side Shelf 9G-13. . . . . . . . . . . . . . . . . . . .
Front Rocker Trim Panel 9G-13. . . . . . . . . . . . . . . . . .
Rear Rocker Trim Panel 9G-14. . . . . . . . . . . . . . . . . . .
Floor Console 9G-15. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Cable Cover 9G-15. . . . . . . . . . . . . . . .
Floor Carpet 9G-16. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage Compartment Wheelhouse
Trim Panel 9G-17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Special Tools and Equipment 9G-18. . . . . . . . . . . . . .
Special Tools Table 9G-18. . . . . . . . . . . . . . . . . . . . . . .

INTERIOR TRIM 9G–9
DAEWOO M-150 BL2
D109E551
REAR DOOR EXTERIOR GARNISH
MOLDING
Removal Procedure
1. Pry off the interior garnish molding. Refer to “Rear
Door Interior Garnish Molding” in this section.
2. Pry off the exterior garnish molding.

Remove the screw (1).

Pry off exterior garnish molding (2).
D109E552
Installation Procedure
1. Install the exterior garnish molding with the screw.
2. Install the interior garnish molding. Refer to “Rear
Door Interior Garnish Molding” in this section.
D19E553A
TAILGATE TRIM PANEL
Removal Procedure
1. Open the tailgate.
2. Remove the trim from the tailgate.

Remove the clips by pushing the center of the clip
(1).

Remove the trim (2).
D19E554A
Installation Procedure
1. Install the trim to the tailgate.
Notice: In case of the loose clips, replace the clips with
the new ones.

INTERIOR TRIM 9G–11
DAEWOO M-150 BL2
D110A501
LOWER B–PILLAR TRIM PANEL
Removal Procedure
1. Remove the bolt on the lower B–pillar trim panel.

Remove the bolt (1).

Remove the spacer and the spring washer (2).

Remove the plastic protector from the seat belt an-
chor.
D109E559
2. Pry off the lower B–pillar trim panel.
D109E560
Installation Procedure
1. Install the lower B–pillar trim panel.
2. Install the bolt on the lower B–piller trim panel. Refer
to Section 8A, Seat Belts.
D109E561
C–PILLAR TRIM PANEL
Removal Procedure
1. Disconnect the negative battery cable.
2. Open the tailgate.
3. Disconnect the rear speaker electrical connector.

9G –12 INTERIOR TRIM
DAEWOO M-150 BL2
D109E562
4. Remove the rear parcel side shelf. Refer to “Rear
Parcel Side Shelf” in this section.
5. Remove the rear seatback.
6. Remove the rear seat belt bolt on the C–pillar trim
panel. Refer to Section 8A, Seat Belts.
7. Pry off the C–pillar trim panel.

Pry off the C–pillar trim panel by hands (1).
D109E563
Installation Procedure
1. Install the C–pillar trim panel.
2. Install the rear seat belt bolt on the C–pillar trim panel.
Refer to Section 8A, Seat Belts.
3. Install the rear seatback.
4. Install the rear parcel side shelf. Refer to “Rear Parcel
Side Shelf” in this section.
5. Connect the rear speaker connector.
6. Connect the negative battery cable.
D109E564
REAR PARCEL SHELF
Removal Procedure
1. Open the tailgate.
2. Remove the rear parcel shelf (1).
D109E565
Installation Procedure
1. Install the rear parcel shelf.

INTERIOR TRIM 9G–13
DAEWOO M-150 BL2
D109E566
REAR PARCEL SIDE SHELF
Removal Procedure
1. Disconnect the negative battery cable.
2. Open the tailgate.
3. Remove the seatback.
4. Remove the rear seat parcel shelf. Refer to “Rear
Parcel Shelf” in this section.
5. Remove the rear speaker from the rear parcel shelf.
Refer to Section 9F, Audio Systems.
6. Remove the rear parcel side shelf.

Remove the screws (1).

Remove the rear parcel side shelf (2).
D109E567
Installation Procedure
1. Install the rear parcel side shelf with the screw.
2. Install the rear speaker to the rear parcel shelf. Refer
to Section 9F, Audio Systems.
3. Install the rear parcel shelf. Refer to “Rear Parcel
Shelf” in this section.
4. Install the seatback.
5. Connect the negative battery cable.
D109E568
FRONT ROCKER TRIM PANEL
Removal Procedure
1. Pry off the rocker trim panel.

Remove the clip (1).

Remove the screw (2).

Pry off the rocker trim panel (3).
D109E569
Installation Procedure
1. Install the rocker trim panel with the clip and the
screw.