2003 CHEVROLET VENTURE boot

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Your Vehicle and the Environment....................6-2
Maintenance Requirements..............................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Scheduled Maintenance...................................6-5
Part B: Owner Checks and Services................6-10
At Each Fuel Fill..........................................6-10
At Least Once a Month.................................6-10
At Least Twice a Year...................................6-11At Least Once a Year...................................6-12
Part C: Periodic MaintenanceInspections.........6-15
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection............................6-15
Exhaust System Inspection............................6-15
Fuel System Inspection..................................6-16
Engine Cooling System Inspection...................6-16
Throttle System Inspection.............................6-16
All-Wheel Drive Inspection..............................6-16
Brake System Inspection................................6-16
Part D: Recommended Fluids and Lubricants. . . .6-17
Part E: Maintenance Record...........................6-19
Section 6 Maintenance Schedule
6-1

Part C: Periodic
MaintenanceInspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-10.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-42.
6-15

Hood............................................................5-10
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-7
How the System Works...................................3-23
How to Add Coolant to the Coolant
Recovery Tank............................................5-31
How to Add Coolant to the Radiator..................5-34
How to Add Fluid Automatic Transaxle Fluid.......5-22
How to Check Automatic
Transaxle Fluid...........................................5-20
How to Check Power Steering Fluid..................5-38
How to Check................................................5-61
How to Inspect the Engine Air Cleaner/Filter.......5-19
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-35
Hydroplaning..................................................4-18
I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light Is Flashing.....................................3-46
If the Light Is On Steady.................................3-47
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide To Pull A Trailer.....................4-37If You're Caught in a Blizzard...........................4-28
Ignition Positions.............................................2-31
Ignition Transaxle Lock Check..........................6-13
Infants and Young Children, Restraints...............1-58
In¯ation -- Tire Pressure..................................5-61
Inspection......................................................6-16
Brake System.............................................6-16
Engine Cooling System................................6-16
Exhaust System..........................................6-15
Fuel System...............................................6-16
Part C - Periodic Maintenance.......................6-15
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-15
Throttle System...........................................6-16
Transfer Care (Power Transfer Unit) and
Carrier Assembly-Differential (Rear Drive
Module) All-Wheel Drive............................6-16
Instrument Panel Brightness.............................3-17
Instrument Panel Fuse Block............................5-97
Instrument Panel.............................................3-36
Cluster.......................................................3-36
Overview..................................................... 3-4
Switchbank.................................................3-21
Interior Lamps Control.....................................3-17
Interior Lamps Override...................................3-17
Interior Lamps................................................3-17
8

M
Maintenance, Normal Replacement Parts..........5-104
Maintenance Schedule.....................................6-10
At Each Fuel Fill.........................................6-10
At Least Once a Month................................6-10
At Least Once a Year..................................6-12
At Least Twice a Year..................................6-11
Brake System Inspection..............................6-16
Engine Cooling System Inspection.................6-16
Exhaust System Inspection...........................6-15
Fuel System Inspection................................6-16
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-10
Part C - Periodic MaintenanceInspections......6-15
Part D - Recommended Fluids and
Lubricants...............................................6-17
Part E - Maintenance Record........................6-19
Scheduled Maintenance................................. 6-5
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-15
Throttle System Inspection............................6-16
Transfer Case (Power Transfer Unit) and
Carrier Assembly-Differential (Rear Drive
Module) All-Wheel Drive Inspection.............6-16Maintenance Schedule (cont.)
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-43
Making Turns.................................................4-41
Malfunction Indicator Light................................3-45
Manual Seats................................................... 1-3
Manual Windows............................................2-24
Matching Transmitter(s) to Your Vehicle............... 2-7
Message.......................................................3-57
All-Wheel Drive Disable Warning....................3-57
Center.......................................................3-50
Change Engine Oil......................................3-54
Charging System Indicator............................3-52
Door Ajar Warning.......................................3-55
Engine Coolant Temperature Warning.............3-51
Low Engine Oil Level...................................3-53
Low Fuel Warning.......................................3-57
Low Oil Pressure.........................................3-52
PASS-Key
žIII Security.................................3-56
Power Sliding Door Warning.........................3-54
Rear Hatch Ajar Warning..............................3-56
Service Traction System Warning...................3-50
Traction Active............................................3-51
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-5
10

Service (cont.)
Doing Your Own Work................................... 5-3
Engine Soon Light.......................................3-45
Publications Ordering Information...................7-10
Traction System Warning Message.................3-50
Setting Preset PTYs........................................3-86
Setting Preset Stations............3-63, 3-66, 3-73, 3-83
Setting the Temperature...........................3-30, 3-32
Setting the Time.............................................3-61
Radios with Radio Data Systems (RDS).........3-61
Radios without Radio Data Systems (RDS).....3-61
Setting the Tone
(Bass/Treble)......................3-63, 3-66, 3-74, 3-83
Sheet Metal Damage.......................................5-93
Shifting Into Park (P).......................................2-39
Shifting Out of Park (P)...................................2-41
Shoulder Belt Height Adjuster...........................1-38
Side Window Latches......................................2-25
Skidding........................................................4-14
Sliding Door Delayed Locking...........................2-13
Sliding Door Lock...........................................2-14
Sliding Door, Power........................................2-17
Sliding Door Security Lock...............................2-15
Sliding Doors, Dual.........................................2-13
Some Other Rainy Weather Tips.......................4-19
Spare Tire Check............................................6-11
Special Fabric Cleaning Problems.....................5-88
Speci®cations, Capacities...............................5-103
Speedometer..................................................3-38Split Bench Seats............................................. 1-8
Starter Switch Check.......................................6-12
Starting Your Engine.......................................2-32
Steering in Emergencies..................................4-11
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..............................6-15
Steering Tips..................................................4-10
Steering........................................................4-10
Stereo RCA Jacks..........................................3-94
Storage Areas................................................2-51
Compact Overhead Console..........................2-52
Convenience Center.....................................2-58
Convenience Net.........................................2-57
Cupholder(s)...............................................2-51
Front Seat Storage Net................................2-54
Glove Box..................................................2-51
Luggage Carrier..........................................2-55
Overhead Console.......................................2-52
Rear Storage Area.......................................2-57
Storing a Flat or Spare Tire and Tools...............5-82
Storing the Built-In Child Restraint.....................1-91
Storing the Spare Tire and Tools.......................5-83
Stowable Seat................................................1-26
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-26
Switchbanks, Instrument Panel..........................3-21
Switchbanks...................................................3-20
Overhead Console.......................................3-21
15