2003 CHEVROLET CORVETTE tires

Cleaning the Convertible Top
Your convertible top should be cleaned often. If you use
an automatic car wash, use one with water jets and
hanging cloths. High pressure car washes may cause
water to enter your vehicle.
When you hand wash the top, do it in partial shade.
Use a mild soap, lukewarm water and a soft sponge. A
chamois or cloth may leave lint on the top, and a
brush can chafe the threads in the top fabric. Don't use
detergents, harsh cleaners, solvents or bleaching
agents.
Wet the entire vehicle and wash the top evenly to avoid
spots or rings. Let the soap remain on the fabric for
a few minutes. When the top is really dirty, use a mild
foam-type cleaner. Your dealer has a Convertible
Top Cleaner and Water Repellent. Thoroughly rinse the
entire vehicle, then let the top dry in direct sunlight.
To protect the convertible top:
·After you wash the vehicle, make sure the top is
completely dry before you lower it.
·Don't get any cleaner on the vehicle's painted
®nish; it could leave streaks.
·If you decide to go through an automatic car wash,
ask the manager if the equipment could damage
your top.
Cleaning Aluminum Wheels
Keep your wheels clean using a soft clean cloth with
mild soap and water. Rinse with clean water. After
rinsing thoroughly, dry with a soft clean towel. A wax
may then be applied.
The surface of these wheels is similar to the painted
surface of your vehicle. Don't use strong soaps,
chemicals, abrasive polishes, abrasive cleaners,
cleaners with acid, or abrasive cleaning brushes on
them because you could damage the surface. Do not
use chrome polish on aluminum wheels.
Don't take your vehicle through an automatic car wash
that has silicone carbide tire cleaning brushes. These
brushes can also damage the surface of these wheels.
Cleaning Tires
To clean your tires, use a stiff brush with tire cleaner.
Notice:When applying a tire dressing, always take
care to wipe off any overspray or splash from all
painted surfaces on the body or wheels of the
vehicle. Petroleum-based products may damage the
paint ®nish and tires.
5-80

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals speci®ed to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any ¯uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel ®ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOLž
coolant mixture if necessary. SeeEngine Coolant
on page 5-23for further details.
Windshield Washer Fluid Level Check
Check the windshield washer ¯uid level in the windshield
washer tank and add the proper ¯uid if necessary.
See
Windshield Washer Fluid on page 5-36for further
details.
At Least Once a Month
Tire In¯ation Check
Make sure tires are in¯ated to the correct pressures.
SeeTires on page 5-54for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-62for further details.
Power Antenna Service
Clean power antenna mast. SeeAudio System(s) on
page 3-62for further details.
6-8

Part C: Periodic
MaintenanceInspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-10.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc.
Tire and Wheel Inspection
Inspect the tires for uneven wear or damage. If there is
irregular or premature wear, check the wheel
alignment. Inspect for damaged wheels.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-35.
6-12

Audio System(s) (cont.)
Understanding Radio Reception.....................3-77
Automatic Transmission Check........................... 6-9
Automatic Transmission Shift Lock Control
System Check.............................................6-10
Automatic Transmission...................................2-21
Fluid..........................................................5-20
Operation...................................................2-24
B
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-17
Battery..........................................................5-40
Before Leaving on a Long Trip.........................4-24
Body Lubrication Service................................... 6-9
Brake Fluid....................................................5-37
Brake Wear...................................................5-39
Brake............................................................2-30
Parking......................................................2-30
System Inspection.......................................6-13
System Warning Light..................................3-35
Brakes..........................................................5-37
Braking in Emergencies..................................... 4-8
Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-47
Back-Up Lamps...........................................5-51
Halogen Bulbs............................................5-47Bulb Replacement (cont.)
Headlamps.................................................5-47
Replacement Bulbs......................................5-51
Taillamps and Turn Signal Lamps..................5-49
Buying New Tires...........................................5-59
C
California Fuel.................................................. 5-5
Canada ± Customer Assistance.......................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Speci®cations............................5-92
Carbon Monoxide...................4-27, 4-35, 2-11, 2-35
Care of.........................................................5-77
Safety Belts................................................5-77
Your Cassette Tape Player............................3-78
Your CD Player...........................................3-79
Your CDs ...................................................3-79
Cargo Cover..................................................2-42
Cassette Tape Messages.................................3-66
Cassette Tape Player Service............................. 6-8
CD Adapter Kits.............................................3-66
CD Changer, Trunk-Mounted............................3-71
Center Console Storage Area...........................2-39
Chains, Tires..................................................5-64
Check Engine Light.........................................3-38
Checking Coolant............................................5-25
Checking Engine Oil........................................5-13
2

Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-48
Check...........................................................3-38
Engine Light...............................................3-38
Gages Warning Light...................................3-42
Chemical Paint Spotting...................................5-81
Child Restraints..............................................1-26
Child Restraint Systems...............................1-26
Infants and Young Children...........................1-23
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-31
Older Children.............................................1-21
Securing a Child Restraint Designed for
the LATCH System...................................1-33
Securing a Child Restraint in the Passenger
Seat Position...........................................1-34
Top Strap Anchor Location............................1-31
Top Strap...................................................1-30
Cigarette Lighter.............................................3-21
Cleaning Aluminum Wheels..............................5-80
Cleaning Coated Moldings................................5-76
Cleaning Exterior Lamps/Lenses.......................5-78
Cleaning Fabric/Carpet....................................5-75
Cleaning Glass Surfaces..................................5-77
Cleaning Interior Plastic Components.................5-77
Cleaning Leather............................................5-76
Cleaning Removable Roof Panel.......................5-79
Cleaning the Convertible Top............................5-80
Cleaning the Security Shade and
Convenience Net.........................................5-77Cleaning the Top of the Instrument Panel...........5-76
Cleaning Tires................................................5-80
Cleaning Windshield and Wiper Blades..............5-79
Cleaning........................................................5-81
Fiberglass Springs.......................................5-81
Inside of Your Vehicle..................................5-75
Outside of Your Vehicle................................5-78
Titanium Exhaust System..............................5-81
Underbody Maintenance...............................5-81
Weatherstrips..............................................5-77
Climate Control System...................................3-22
Dual Automatic............................................3-22
Outlet Adjustment........................................3-28
Clutch, Hydraulic.............................................5-22
Compact Disc Messages..........................3-70, 3-75
Competitive Driving Mode................................4-11
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-42
Convertible Top..............................................2-49
Lowering the Convertible Top........................2-50
Raising the Convertible Top..........................2-53
Coolant.........................................................3-38
Engine Temperature Gage............................3-38
Heater, Engine............................................2-23
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Courtesy Lamps.............................................3-16
Cruise Control.................................................. 3-9
Cupholder(s)..................................................2-39
Current and Past Model Order Forms................7-11
3

Electrical System (cont.)
Power Windows and Other Power Options......5-85
Windshield Wiper Fuses...............................5-85
Emergency Trunk Release Handle
(Convertible Only)........................................2-13
Emissions Inspection and Maintenance
Programs...................................................3-40
Engine Accessory Drive Belt Routing.................5-95
Engine Compartment Fuse Block......................5-89
Engine Coolant Level Check.............................. 6-8
Engine Oil Additives........................................5-16
Engine Oil Level Check..................................... 6-8
Engine Oil Scheduled Maintenance..................... 6-5
Engine..........................................................5-18
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-40
Check and Service Engine Soon Light............3-38
Compartment Overview................................5-12
Coolant Heater............................................2-23
Coolant Temperature Gage...........................3-38
Coolant......................................................5-23
Cooling System Inspection............................6-13
Exhaust.....................................................2-35
Oil Pressure Gage.......................................3-41
Oil .............................................................5-13
Overheating................................................5-26
Starting......................................................2-21
Exit/Entry Lighting...........................................3-16
Express-Down Window....................................2-15Extended Mobility Tires....................................5-54
Extender, Safety Belt.......................................1-20
Exterior Lamps...............................................3-12
F
Filter.............................................................5-18
Engine Air Cleaner......................................5-18
Finding a Station....................................3-63, 3-67
Finish Care....................................................5-78
Finish Damage...............................................5-81
Fixed Mast Antenna........................................3-79
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-68
Floor Mats.....................................................2-40
Fluid.............................................................5-20
Automatic Transmission................................5-20
Manual Transmission....................................5-20
Power Steering...........................................5-35
Windshield Washer......................................5-36
FM ...............................................................3-77
Fog Lamps....................................................3-14
Footnotes........................................................ 6-5
Front Air Dam................................................2-19
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
5

LATCH System (cont.)
Latches, Seatback............................................ 1-5
Leaving Your Vehicle With the Engine Running
(Automatic Transmission)..............................2-32
Leaving Your Vehicle.......................................2-10
Lifting From the Front......................................5-66
Lifting From the Rear......................................5-67
Lifting Your Corvette, Tires...............................5-64
Lighted Visor Vanity Mirrors..............................2-15
Light.............................................................3-37
Active Handling System................................3-37
Air Bag Off .................................................3-33
Air Bag Readiness.......................................3-32
Anti-Lock Brake System Warning...................3-36
Brake System Warning.................................3-35
Check Gages Warning.................................3-42
Malfunction Indicator....................................3-38
Safety Belt Reminder...................................3-31
Security.....................................................3-42
TCS Warning Light......................................3-36
Traction Control System (TCS) Warning..........3-36
Limited-Slip Rear Axle.....................................4-11
Loading Your Vehicle.......................................4-33
Lockout Protection..........................................2-10
Locks............................................................. 2-9
Door........................................................... 2-9
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door................................................2-10Loss of Control...............................................4-17
Lowering the Convertible Top............................2-50
M
Magnesium Wheel Finish.................................5-81
Magnetic Speed Variable Assist Steering............4-13
Maintenance, Normal Replacement Parts............5-94
Maintenance Schedule...................................... 6-8
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-8
At Least Once a Year.................................... 6-9
At Least Twice a Year................................... 6-9
Brake System Inspection..............................6-13
Engine Cooling System Inspection.................6-13
Exhaust System Inspection...........................6-12
Fuel System Inspection................................6-13
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services............... 6-8
Part C - Periodic MaintenanceInspections......6-12
Part D - Recommended Fluids and
Lubricants...............................................6-14
Part E - Maintenance Record........................6-16
Rear Axle Service........................................6-13
Scheduled Maintenance................................. 6-4
Steering and Suspension Inspection...............6-12
8

Tires.............................................................5-54
Buying New Tires........................................5-59
Chains.......................................................5-64
Extended Mobility........................................5-54
If a Tire Goes Flat.......................................5-68
In¯ation -- Tire Pressure...............................5-56
Lifting Your Corvette....................................5-64
Pressure Monitor System..............................5-57
Rotation.....................................................5-58
Tire and Wheel Inspection............................6-12
Tire In¯ator Kit............................................5-70
Uniform Tire Quality Grading.........................5-60
Wheel Alignment and Tire Balance.................5-61
Wheel Replacement.....................................5-61
To Use The Engine Coolant Heater...................2-23
Top Strap Anchor Location...............................1-31
Top Strap......................................................1-30
Torque Lock (Automatic Transmission)...............2-33
Towing..........................................................4-33
Recreational Vehicle.....................................4-33
Towing a Trailer..........................................4-35
Your Vehicle...............................................4-33
Traction.........................................................4-10
Active Handling System................................4-10
Control System (TCS).................................... 4-9
Control System Warning Light.......................3-36
Limited-Slip Rear Axle..................................4-11
Selective Ride Control..................................4-12
Transmission Operation, Automatic....................2-24
Transmission Operation, Manual........................2-27Transmission..................................................5-20
Fluid, Automatic...........................................5-20
Fluid, Manual..............................................5-20
Transportation Options...................................... 7-8
Trunk/Hatch...................................................2-11
Trunk-Mounted CD Changer.............................3-71
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
Twilight Sentinel
ž(Optional in United States,
Standard in Canada)....................................3-14
U
Underbody Flushing Service.............................6-11
Understanding Radio Reception........................3-77
Uniform Tire Quality Grading............................5-60
United States ± Customer Assistance.................. 7-4
Unlocking the Theft-Deterrent Feature After a
Power Loss................................................3-76
V
Vehicle Identi®cation........................................5-83
Number (VIN).............................................5-83
Service Parts Identi®cation Label...................5-83
Vehicle Personalization....................................2-55
Memory.....................................................2-55
Vehicle Storage..............................................5-40
13