2003 ASTON MARTIN DB AR1 Q cooling

F - Owner Maintenance
1-F-41 Boot Fusebox
F1 10A Reverse Light Relay
F2 20A Security System & Tilt Sensors
F3 5A +12V Ignition
F4 5A Boot Switch Logic Relay, Security System Control Unit
F5 30A Accessory Terminal
F6 5A RH Fog Lamp, Powertrain Control Modules
F7 20A Fuel Pump 2, Secondary Powertrain Control Module
F8 10A HM Stop Light, LH Stop Light
F9 10A Boot Lamps, Radio Aerial Motor
F10 10A Accessory Socket
F11 20A Not Used
F12 20A Not Used
F13 10A Airbag Control Unit
F14 30A Not Used
F15 20A Fuel Pump 1, Primary Powertrain Control Module
F16 10A Rear Fog Light Relay
F17 10A Manual Gearbox Cooling Pump
F18 10A Accessory Terminal
F19 10A RH Tail, Side, Side Marker and
Number Plate Lamps
F20 20A Premium ICE Amplifier
F21 10A LH Tail, Side, Side Marker and
Number Plate Lamps
F22 20A Manual - Exhaust By-pass System
Automatic - Not Used

F - Owner Maintenance
1-F-59 When returning the car to normal service, set the tyre pressures to normal
specification before driving on the road.
Extended Storage
For storage periods exceeding six months the following additional measures
are recommended;
Run the car until there is as small a quantity of fuel in the tank as is practical
for storage purposes.
Caution: Do Not Drain The Fuel System
Add Engine Oil to the remaining fuel in the tank to ensure a concentration
of 2% (i.e. 20ml per 1 litre of fuel) and then run the engine for not less than
ten minutes to circulate the mixture thoroughly through the entire fuel
system.
Inspect the rubber connections of the cooling system and have them
renewed if necessary.
Wash the bodywork of the car thoroughly and repair any paint
blisters or patches of rust in order to prevent any further deterioration.
Apply a suitable polish.
Clean the carpets and upholstery thoroughly. Dust them with an
anti-moth powder and store in a dry place. Treat all leather upholstery
with an appropriate leather conditioner.
If the storage building is dry leave the car windows slightly open. If
there is any tendency towards dampness close the car doors and
windows and place an anti-moisture compound such as Silica desiccant
bags in an open metal container inside the car.
Cover the car with it's fabric cover.

G - Specifications
1-G-11
Capacities
Europe UK USA
Engine sump (incl. filter) 11 litres (20.0 pints) (11.5 Qts)
Engine sump (excl. filter) 10 litres (18 pints) (10.3 Qts)
Engine cooling system 14.35 litres (25.25 pints) (15.2 Qts)
Screen washer reservoir 2.8 litres (5.0 pints) (3.2 Qts)
Manual gearbox 4.0 litres (7.0 pints) (4.2 Qts)
Automatic gearbox 12.8 litres (22.5 pints) (13.5 Qts)
Final drive 1.6 litres (2.8 pints) (1.7 Qts)
Fuel tank 82 litres (18 galls) (21.5 galls)
Note: Approximately 7 litres of the total fuel capacity specified above is
required to prime the fuel system and is therefore not usable.

A - Service Schedules
2-A-6
Road Test
Engine
Clutch (manual only)
Manual transmission
Auto transmission
Rear axle differential
Steering
Brakes
Wheel balance
Dampers
Noise vibration or harshness
Air conditioning performance
Instruments operation
Seat belt and buckle operation
Steering wheel alignment
Traction control
Final Checks
Drive belt tensions
Fuel / brake pipe security
Fuel / fluid leaks
Cooling systems hose security
Exhaust catalyst security
Hand-over Preparation
Assemble / Check function of all keys
and key fobs
Clean bodywork
Clean off all transit labels
Valet Vehicle
Degrease windscreen
Fit carpets
Remove interior protection
Check Owner's Guide/Quick Guide
Check tools
Install license plates

2-A-7
A - Service Schedules
Service Schedules
The following service schedules are recommended for DB AR1. The schedules may
be modified if necessary. Please consult your Aston Martin Dealer for details of any
service schedule updates.
Road Test Evaluation
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Pre-Maintenance Road Test Evaluation
Fluids Filters and Leaks Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Renew the engine oil
x x x Renew the engine oil filter
x x x Check for engine oil leaks
- - x Renew the air cleaner elements
x x x Check auto transmission for leaks
x x x Check man. gearbox for leaks.
Top-up if necessary
- - x Renew rear axle oil
x - - Check / top-up rear axle oil
- x - Check rear axle for leaks, top up if necessary
- - 30000 Renew engine coolant - check S.Gravity
x x x Check/top-up engine coolant
x x x Check cooling and heating systems for leaks
- - 60000 Renew fuel filters
x x x Check for fuel leaks
Every 2 years 30,000 miles Renew brake fluid
x x x Check / top-up brake fluid reservoir
x x x Check / top-up clutch fluid reservoir
x x x Check / top-up power steering reservoir
x x x Check power steering system for leaks
x x x Check brake hoses, pipes and unions for leaks
x x x Check suspension dampers for leaks
x x x Top-up windscreen washer reservoir
x x x Check exhaust system for leaks
x x x Check air conditioning system for leaks

A - Service Schedules
2-A-8
Mechanical Function Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
- x x Lubricate all door locks and hinges
- x x Grease all points excluding hubs
x x x Check / adjust all drive belt tensions,
renew if necessary
x x x Lubricate handbrake links and cables
x x x Check handbrake security
- - 30,000 Check condition of handbrake shoes
- x x Inspect brake pad wear and condition of discs
- x x Check and renew wiper blade inserts
if necessary
- - 30000 Renew wiper blades
- - 30000 Clean out engine and A/C radiators
x x x Check condition and operation of all seat belts
x x x Check security of exhaust system mountings
x x x Check brake hoses, pipes and unions
x x x Check power steering pipes and unions for
corrosion and mechanical defects
- - x Check security and condition of fuel hoses
x x x Check cooling system hoses security
and condition
x - - Check air conditioning hoses security
and condition
x x x Check condition and security of steering unit
joints and gaiters
x x x Check security and condition of
suspension fixings
- - x Check tightness of propshaft and driveshaft bolts
x x x Check interior rear view mirror for security and
function
- - x Check the condition of underbody protection
Electrical Function Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
- - 45,000 ml Renew spark plugs
- - x Check / top-up battery electrolyte
x x x Clean and grease the battery connections

2-A-9
A - Service Schedules
x - x Check and if necessary adjust headlight
alignment
x x x Check operation of all lights
x x x Check operation of ABS warning lamp
x x x Check operation of all warning indicators
x x x Check audible warnings including
security system
x x x Check operation of the horns
x x x Check operation of the windscreen wipers
x x x Check operation of the windscreen washers
x x x Clean the radio aerial mast
x x x Check exterior rear view mirrors for security and
function
x x x Interrogate DTC P codes (not N. America)
x x x Check man. transmission cooling pump (PDU)
Wheels and Tyres Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Check for correct tyre size, type and rotation
x x x Check and report tyre tread depth
x x x Check tyres for uneven / excessive
wear or damage
x x x Check / adjust the tyre pressures(including spare)
to comfort or high speed pressures as required
x x x Check torque of road wheel nuts
x x x Check road wheel rims for inner
and outer damage
Final Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
- x x Degrease windscreen
x x x Carry out road test
x x x Check ABS and Traction Control operation
x x x Check operation of all seat belts and buckles
x x x Check that fuel filler bowl rain drain is clear

Index
5-A-1
Index
A
ABS Warning Light 1-C-22
Adjustments Before Driving 1-A-7
Air Conditioning System 1-D-2
Defrost 1-D-6
Door Mounted Vents 1-D-4
Face Level Vents 1-D-3
Fan Speed Control 1-D-5
Heating/Cooling 1-D-2
Internal Air Flow 1-D-3
Mode Switch 1-D-6
Temperature Control 1-D-5
Temperature Differential Control 1-D-9
Ventilation 1-D-3
Airbags
Child Seats - Passenger Airbags 1-A-20
Alarm
Key Fob 1-A-3
Locking the DB AR1 1-A-4
The Security System 1-A-3
Turning off the Alarm 1-A-4
Turning on the Alarm 1-A-4
Unlocking the DB AR1 1-A-4
Anti-Lock Braking System (ABS) 1-C-21
Ashtray 1-B-22
Automatic Locking Retractors 1-A-15
B
Battery
Battery Conditioner 1-F-33
Battery Disconnect Switch 1-F-32
Electrical Start from Another Vehicle 1-F-36
Quiescent Battery Drain 1-F-31
The Battery Reconnect Switch 1-F-35
Boot (Trunk) Lock Control 1-E-6
Brake System Warning Light 1-C-22
Brake Warning Indications During Driving 1-C-21
Braking Systems 1-C-19
Bulb and Fuse Replacement 1-F-42