2003 ASTON MARTIN DB AR1 Q power steering fluid

xi
Regular Checks
In the interests of safety and reliability, it is advisable to carry out the
following checks at the intervals suggested (more frequently if the vehicle is
heavily used or operating in adverse conditions), and always before starting
on a long journey. Refer to the Owner Maintenance section of this guide.
Each Day
Check that there is sufficient fuel for the intended journey, particularly at
night and before entering highways.
Weekly - (Daily if covering high mileage or touring)
Tyres - Check the tyres, including the spare (if fitted) for condition and
pressure. See the 'Specifications' section for the recommended tyre pressures.
Lights - Check that all exterior lights and direction indicators function
correctly and that the lenses are clean.
Engine Oil - With the vehicle standing on level ground, check the oil level
and top up if necessary with oil of the correct grade.
Engine Cooling System - With the engine cold, check the level of the engine
coolant. Top-up if necessary with coolant containing the required percentage
of anti-freeze. Any significant coolant loss should be investigated by your
Aston Martin Dealer.
Brake Fluid - Check the level of the fluid in the brake reservoir. Top-up if
necessary with the specified brake fluid from a new unopened container.
Power Steering Fluid - Check and top-up the level of fluid in the power
steering reservoir with fluid of the correct specification.
DB AR1 Owners Guide

F - Owner Maintenance
1-F-6
Fluid Level Checks
Engine Bay Component Location (Right Hand Drive Illustrated)
1 Engine Oil Dipstick 2 Engine Coolant Header Tank
3 Engine Oil Filler Cap 4 Power Steering Fluid Reservoir
5 Brake Fluid Reservoir 6 Windscreen Washer Fluid Reservoir
7 Clutch Reservoir (Man) 8 Engine Bay Covers
Note: Items 5 &7 move to the left corner on left hand drive cars.
In the following descriptions, numbers in parenthesis, e.g. (1), refer to the
numbered items in the diagram and list above.
All directions are described as viewed from the driver's seat. Thus the oil filler cap
(item 3) is on the left side of the car, the brake fluid reservoir (item 5) is on the right
side of the car.

F - Owner Maintenance
1-F-10
Power Steering Fluid Level Check
The power steering pump reservoir (4) is situated on the right inner
wing.
The reservoir level should be checked when the engine is cold. The
reservoir cap incorporates a dipstick. Top up the reservoir with clean
fluid of the recommended grade up to the lower mark on the dipstick.
DO NOT OVERFILL.
WARNING: Avoid touching the sides of the engine when working in the engine
compartment. The exhaust system will be hot if the engine has recently been run.
Caution: Take care that hydraulic fluid does not contact the paint work during the
topping up operation. Serious paint work damage can result. If a spillage does occur,
immediately flush the hydraulic fluid from the paint work with clean, fresh water and
then wipe with a clean damp cloth.

G - Specifications
1-G-1
Contents
Body ................................................................................................. 1-G-2
Engine ............................................................................................... 1-G-2
Power and Torque Graphs ................................................................. 1-G-3
Transmission - Manual....................................................................... 1-G-4
Transmission - Automatic ................................................................... 1-G-4
Final Drive ......................................................................................... 1-G-4
Steering ............................................................................................. 1-G-4
Suspension........................................................................................ 1-G-5
Brakes ............................................................................................... 1-G-5
Towing .............................................................................................. 1-G-5
Wheels and Tyres .............................................................................. 1-G-6
Exterior Features ................................................................................ 1-G-7
Interior Features ................................................................................ 1-G-7
Lights ................................................................................................ 1-G-8
Exterior Dimensions and Clearances.................................................. 1-G-9
Interior Dimensions .........................................................................1-G-10
Weights ........................................................................................... 1-G-10
Capacities........................................................................................ 1-G-11
Recommended Fluids ......................................................................1-G-12

G - Specifications
1-G-12
Recommended Fluids
Engine oil (Initial fill) Mobil 1 0w-40 Europe (0w-30 USA)
Engine oil API SJ/CF, ACEA A3/B3 OR ILSAC GF2
Mobil 1 recommended
Engine coolant 60% water, 40% Havoline OAT
Do not mix OAT with glycol based antifreeze
Manual gearbox oil Texaco 1863, Transam 7045, Mobil ATF or
Dexron III
Auto transmission fluid Esso LT 71141
Final drive oil Shell spirax super 90 TS or Mobilube SHC LS
Brake/Clutch fluid Mobil Universal Brake Fluid
Power steering fluid Mobil ATF or Dexron III
A/C refrigerant R134A (HFC134A)
Engine Oil
Synthetic oils must conform to API SJ/CF standards. Preferably with ACEA
A3/B3 and ILSAC GF2. The chart below gives oil grades for average ambient
temperatures and applies to both mineral and synthetic oils.
Caution: To achieve the desired high performance of synthetic lubricants, do not mix
with mineral oils.

2-A-5
A - Service Schedules
Pre-delivery Inspection (PDI)
Before you receive your DB AR1, it will undergo a comprehensive pre-
delivery inspection at the Dealer's premises to ensure that it meets Aston
Martin's quality standards. The following checks will be made:
Levels and Leaks
Engine oil
Power steering oil
Brake Fluid
Clutch fluid (manual only)
Engine coolant level
Engine coolant specific gravity
Windscreen washer fluid
Fuel system
Gearbox oil/Auto transmission fluid
Rear axle oil - Differential
Battery
Mechanical Functions
Auto transmission
Selection and P & N functions
Manual gear selection
Clutch operation (manual only)
Throttle pedal operation
Parking brake operation
Steering column adjustment and lock
operation
Seat adjuster rails
Bonnet (Hood) release and catch
Door operation and locks
Storage compartments
Rear view mirror
Wheels and Tyres
Road wheel nuts
Tyre pressures
Front wheel tracking
Electrical Checks
Battery condition
Heated windscreen
Windscreen washers
Windscreen wipers
Air-conditioning controls
Gauges and warning lights
Radio/Cassette/CD player
Navigation (where fitted)
All speakers
Electric aerial
Inertia switch
Window mechanisms
Side and headlights (main and dip)
Front fog lights
Rear fog lights (where fitted)
Hazard warning lights
Instrument illumination and dimmer
Air conditioning panel illumination
Auto Trans. PRNDL illumination
Horns
Interior/map lights
Cigar lighter
Seat adjustment - all functions
Door mirror adjustments
Reset clock (if necessary)
Door / boot courtesy lights
Central locking system
Filler flap lock operation
Seat belt operation
Seat belt warning system
Security system / Remote control
Clutch pedal start inhibit
Interrogate DTC codes (not N.
America)
Record battery open-circuit voltage

2-A-7
A - Service Schedules
Service Schedules
The following service schedules are recommended for DB AR1. The schedules may
be modified if necessary. Please consult your Aston Martin Dealer for details of any
service schedule updates.
Road Test Evaluation
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Pre-Maintenance Road Test Evaluation
Fluids Filters and Leaks Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Renew the engine oil
x x x Renew the engine oil filter
x x x Check for engine oil leaks
- - x Renew the air cleaner elements
x x x Check auto transmission for leaks
x x x Check man. gearbox for leaks.
Top-up if necessary
- - x Renew rear axle oil
x - - Check / top-up rear axle oil
- x - Check rear axle for leaks, top up if necessary
- - 30000 Renew engine coolant - check S.Gravity
x x x Check/top-up engine coolant
x x x Check cooling and heating systems for leaks
- - 60000 Renew fuel filters
x x x Check for fuel leaks
Every 2 years 30,000 miles Renew brake fluid
x x x Check / top-up brake fluid reservoir
x x x Check / top-up clutch fluid reservoir
x x x Check / top-up power steering reservoir
x x x Check power steering system for leaks
x x x Check brake hoses, pipes and unions for leaks
x x x Check suspension dampers for leaks
x x x Top-up windscreen washer reservoir
x x x Check exhaust system for leaks
x x x Check air conditioning system for leaks

Index
5-A-2
C
Care and Maintenance of Seat Belts 1-F-57
Catalytic Converters 1-C-4
Child Safety Seats
Child Seats and Passenger Airbags 1-A-20, 1-A-21
Warnings 1-A-19
Clock 1-B-17
Column Switchgear
Left Hand Stalk 1-B-12
Right Hand Stalk 1-B-14
Console Mounted Controls 1-B-16
D
Door Edge Lights 1-F-52
Door Locks 1-A-5
Door Sealing 1-A-5
Driving in Wet Conditions 1-C-9
E
Electric Window Reset Procedure 1-F-52
Electrics
Battery 1-F-30
Engine Bay 1-F-6
Engine Coolant Temperature Gauge 1-B-11
Engine Immobiliser 1-A-4
F
Fluid Level Checks 1-F-4
Brake Fluid Reservoir 1-F-11
Clutch Hydraulic Fluid Reservoir 1-F-9
Engine Oil Level 1-F-7
Power Steering Reservoir 1-F-10
Footbrake 1-C-19
Front Indicator Lights / Front Parking Lights 1-F-47
Front Interior Lights 1-F-51
Fuel 1-C-2
Fuel Cut-Off Switch 1-C-8
Fuel Filler Cap 1-C-3
Fuel Filling 1-C-3
Fuel Gauge 1-B-10
Fuse Boxes 1-F-38
Fuse Lists - Right Hand Drive 1-F-39