2002 ISUZU AXIOM Service Repair Manual

HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
1A±119
Power Transistor
1. Remove the power transistor connector (C±34) from
the evaporator assembly.
2. Check the conduction between the power transistor
side terminals.
C01R200006
MAX HI Relay
1. Remove the MAX ± HI relay connector (C±35) from
the blower assembly.
2. Check the conduction between the MAX ± HI relay
side terminals.
C01R200011
In Car Sensor
1. Turn on the ignition switch (the engine is started).
Start the air conditioner in ªAutoº.
2. Make sure that the in car sensor suctions cigarette
smokes and such.
In Car Sensor
1. Dismount the in car sensor from the automatic
heater/air conditioner control unit. Connect (+) end
and (±) end of the battery to the aspirator motor side
terminals No.I17±1 and No.I17±2, respectively, then
check if the motor runs normally.
C01R200010

1A±120
HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
Heater (X±1) And Compressor (X±2) Relay
1. Disconnect relays and check for continuity and
resistance between relay terminals.

For handling of these relays, refer to
Heater Relay
in this section.
C01R200011
Thermostat (X±8) Relay
1. Disconnect relays and check for continuity and
resistance between relay terminals.

For handling of these relays, refer to
Heater Relay
in this section.
C01R200012
Triple Pressure Switch
1. Disconnect the connector and check for continuity
between pressure switch side connector terminals (1)
and (2).
2. Reconnect the connector to activate the A/C switch,
and check to see if there is continuity between the
chassis side connector terminal (3) and (4) and the
fan operates.
875R200020

HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
1A±121
On-Vehicle Service
Power Transistor
874R200014
Legend
(1) Glove Box
(2) MAX HI Relay
(3) Power Transistor Connector
(4) Power Transistor
Removal
1. Remove the glove box.
2. Remove the MAX±HI relay.
3. Disconnect the power transistor connector.
4. Remove the power transistor.
Installation
To install, follow the removal step in the reverse order.
Automatic Heater/Air Conditioner
Control Unit
865R200007
Legend
(1) Display
(2) Audio & Switch Assembly
(3) Automatic Air Conditioner Control Unit
(4) Knee Pad (RH)
(5) Center Cluster
(6) Center Cluster Upper
(7) Knee Pad (LH)
Removal
1. Disconnect the battery ground cable.
2. Remove the knee pad (R/LH).
3. Remove the center cluster upper.
4. Remove the center cluster.

Refer to
Instrument Panel Assembly in Body
Stractur section.
5. Disconnnect the six connectors.
6. Remove the automatic air conditioner control unit.
Installation
To install, follow the removal step in the reverse order.

1A±122
HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
In Car Sensor
865R200001
Legend
(1) Meter Cluster
(2) In Car Sensor
Removal
1. Disconnect the battery ground cable.
2. Remove the meter cluster.

Refer to
Instrument Panel Assembly in Body
Structure section.
3. Remove the in car sensor.
Installation
To install, follow the removal step in the reverse order.
Ambient Sensor
875R200018
Legend
(1) Ambient Sensor
(2) Ambient Sensor Connector
(3) Horn (LH)
Removal
1. Disconnect the battery ground cable.
2. Remove the horn (LH).
3. Disconnect the ambient sensor connector.
4. Remove the ambient sensor.
Installation
To install, follow the removal step in the reverse order.

HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
1A±123
Sun Sensor
865R200002
Legend
(1) Sun Sensor
(2) Center Cluster Upper
Removal
1. Disconnect the battery ground cable.
2. Remove the center cluster upper.
3. Disconnect the sun sensor connector.
4. Remove the sun sensor.
Installation
To install, follow the removal step in the reverse order.
Duct Sensor
874R200010
Legend
(1) Sensor Part
(2) Evaporator Core
(3) Duct Sensor Assembly
(4) Evaporator Assembly
Removal
1. Disconnect the battery ground cable.
2. Remove the evaporator assembly.

Refer to
evaporator assembly in this section.
3. Remove the duct sensor assembly.
Installation
To install, follow the removal step in the reverse order.

1A±124
HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
Mode Actuator
840R200005
Legend
(1) Driver Knee Bolster Assembly
(2) Instrument Panel Driver Lower Cover
Assembly
(3) Actuator Rod
(4) Mode Actuator
Removal
1. Disconnect the battery ground cable.
2. Remove the instrument panel driver lower cover
assembly.
3. Remove the driver knee bolster assembly.

Refer to the
Instrument Panel Assembly in Body
Structure section.
4. Remove the actuator rod.
5. Remove the mode actuator.
Installation
To install, follow the remove step in the reverse order.
Mix Actuator
840R200006
Legend
(1) Center Cluster Upper
(2) Center Cluster
(3) Knee Pad (RH)
(4) Actuator Rod
(5) Mix Actuator
(6) Knee Pad (LH)
(7) Audio & Switch Assembly
Removal
1. Disconnect the battery ground cable.
2. Remove the knee pad (R/RH).
3. Remove the center cluster upper.
4. Remove the center cluster.

Refer to the
Instrument Panel Assembly in Body
Structure section.
5. Disconnect the six connectors.
6. Remove the Audio & Switch Assembly.
7. Remove the actuator rod.
8. Remove the mix actuator.
Installation
To install, follow the remove step in the reverse order.

HEATING, VENTILATION AND AIR CONDITIONING (HVAC)
1A±125
Intake Actuator
873R200003
Legend
(1) Evaporator Assembly
(2) Intake Actuator
(3) Intake Actuator Connector
Removal
1. Disconnect the battery ground cable.
2. Discharge and recover refrigerant.

Refer to
Refrigerant Recovery in this section.
3. Remove the evaporator assembly.

Refer to
Evaporator Assembly section.
4. Disconnect the intake actuator connector.
5. Remove the intake actuator.
Installation
To install, follow the remove step in the reverse order.

POWER±ASSISTED STEERING SYSTEM2A±1
AXIOM
STEERING
POWER-ASSISTED STEERING SYSTEM
CONTENTS
Service Precaution 2A±2. . . . . . . . . . . . . . . . . . . . . .
Diagnosis 2A±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description 2A±8. . . . . . . . . . . . . . . . . . . . .
Power Steering System Test 2A±10. . . . . . . . . . . . . .
Maintenance 2A±11. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid Level 2A±11. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bleeding The Power Steering System 2A±11. . . . . .
Bleeding Procedure 2A±11. . . . . . . . . . . . . . . . . . . . .
Flushing The Power Steering System 2A±11. . . . . .
Steering Wheel Free Play Inspection 2A±12. . . . . .
Front End Alignment Inspection and
Adjustment 2A±12. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Main Data and Specifications 2A±16. . . . . . . . . . . . .
Special Tools 2A±17. . . . . . . . . . . . . . . . . . . . . . . . . .
Power Steering Unit 2A±18. . . . . . . . . . . . . . . . . . . . .
Power Steering Unit and Associated Parts 2A±18
Removal 2A±18. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation (4y2 Model) 2A±19. . . . . . . . . . . . . . . .
Installation (4y4 Model) 2A±19. . . . . . . . . . . . . . . .
Power Steering Unit Disassembled View 2A±20. .
Disassembly 2A±21. . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Repair 2A±21. . . . . . . . . . . . . . . . . .
Reassembly 2A±21. . . . . . . . . . . . . . . . . . . . . . . . . .
Main Data and Specifications 2A±22. . . . . . . . . . .
Special Tools 2A±22. . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Steering Pump 2A±23. . . . . . . . . . . . . . . . . . . .
Power Steering Pump and Associated Parts 2A±23
Removal 2A±23. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 2A±23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Steering Pump Disassembled View 2A±24
Disassembly 2A±24. . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Repair 2A±25. . . . . . . . . . . . . . . . . .
Reassembly 2A±25. . . . . . . . . . . . . . . . . . . . . . . . . .
Main Data and Specifications 2A±27. . . . . . . . . . .
Transfer Gear Assembly 2A±28. . . . . . . . . . . . . . . . .
Transfer Gear Assembly and Associated
Parts 2A±28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removal 2A±28. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Repair 2A±28. . . . . . . . . . . . . . . . . .
Installation 2A±28. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Supplemental Restraint System Steering
Wheel & Column 2A±29. . . . . . . . . . . . . . . . . . . . . . .
Service Precaution 2A±29. . . . . . . . . . . . . . . . . . . .
SRS Connectors 2A±29. . . . . . . . . . . . . . . . . . . . . .
Inflator Module 2A±31. . . . . . . . . . . . . . . . . . . . . . . . . .
Inflator Module and Associated Parts 2A±31. . . . .
Removal 2A±31. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Repair 2A±32. . . . . . . . . . . . . . . . . .
Installation 2A±32. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Wheel 2A±33. . . . . . . . . . . . . . . . . . . . . . . . .
Steering Wheel and Associated Parts 2A±33. . . .
Removal 2A±33. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 2A±35. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Combination Switch 2A±36. . . . . . . . . . . . . . . . . . . . .
Combination Switch and Associated Parts 2A±36
Removal 2A±36. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 2A±38. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Cylinder 2A±40. . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Cylinder and Associated Parts 2A±40. . . . . .
Removal 2A±40. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 2A±42. . . . . . . . . . . . . . . . . . . . . . . . . . . .
System Inspection 2A±43. . . . . . . . . . . . . . . . . . . . .
Steering Column 2A±44. . . . . . . . . . . . . . . . . . . . . . . .
Steering Column and Associated Parts 2A±44. . .
Removal 2A±44. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection 2A±46. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 2A±48. . . . . . . . . . . . . . . . . . . . . . . . . . . .
System Inspection 2A±49. . . . . . . . . . . . . . . . . . . . .
Supplemental Restraint System Steering
Wheel & Column and Associated Parts 2A±50. . . .
Main Data and Specifications 2A±50. . . . . . . . . . .
Special Tools 2A±50. . . . . . . . . . . . . . . . . . . . . . . . . .